C3400PR声级测试.doc

非控制性文本 祇作參考用途 CPI COROPRATE 題目 聲級測試 SOUND PRESSURE LEVELS PRODUCT INTEGRITY 編號 0006 3400 版本號 PR 日期 01 01 96 QUALITY AND SAFETY EDM NO 0006 001 作者 E Isaacs 修改 OPERATING PROCEDURE 翻 譯 F Liang校核 批準 QSOP 0006 3400 PR第 1 頁 共 10 頁 1 1 SCOPESCOPE 適用範圍適用範圍 1 1 1 1 ProductsProducts andand ComponentsComponents CoveredCovered 所包括的產品和部件所包括的產品和部件 All products intended to produce a measurable sound pressure level Including toy rattles 所有會產生可測量聲級的產品 包括rattle玩具 1 2 1 2 ExemptionsExemptions 例外情況例外情況 1 2 1 Toys into which a child must blow air to obtain sounds e g whistles and other musical wind instruments 必須通過孩童吹氣才能發聲的玩具 例如 口哨和其它吹風樂器 1 2 2 Toy percussion instruments e g a toy drum 敲擊樂器 如 玩具鼓 1 2 3 Toys with volume control with the exception of limiters such as hi lo switches e g radios tape players etc 有音量控制的玩具 限制器除外 如高低音開關 例如 收音機 磁帶錄放機 2 2 PERFORMANCEPERFORMANCE REQUIREMENTSREQUIREMENTS 性能要求性能要求 2 1 TableTable 1 1 shows the acceptable average maximum sound pressure levels in age categories for different noise types excluding caps 表1列出了包括不同年齡層次對于不同噪音種類的可接受的平均最大聲級 火帽除外 AgeAge CategoryCategory 年齡分類年齡分類 TypeType ofof NoeisNoeis 噪音種類噪音種類 Avg Avg Max Max SPLSPL dB A dB A 平均最大聲級平均最大聲級 Under 18 months Continuous 連續式聲音 75 18個月以下 Impulse 脈衝式聲音 100 18 36 months Continuous 連續式聲音 85 18 36個月 Impulse 脈衝式聲音 100 0ver 36 months Continuous 連續式聲音 100 36個月以上 Impulse 脈衝式聲音 100 非控制性文本 祇作參考用途 CPI COROPRATE PRODUCT INTEGRITY QSOP 0006 3400 PR第 2 頁 共 10 頁 TABLE 1 Average Sound Pressure Levels 表1 平均聲級標準 NOTE NOTE IfIf a a productproduct forfor childrenchildren overover 3636 monthsmonths ofof ageage exceedsexceeds 8585 dB A dB A productproduct CANNOTCANNOT bebe shippedshipped toto Australia Australia NotifyNotify ProductProduct IntegrityIntegrity immediatelyimmediately toto notifynotify InternationalInternational Marketing Marketing 注意 如果對于適合于36個月以上兒童的產品 其噪音超過85dB A 則該 產品不能運到澳洲銷售 并立即通知品質部以便通知國際市場部 2 2 Toy caps when tested per section 3 3 3 must meet the following requirements 根據3 3 33 3 3測試的火帽玩具必須符合以下要求測試的火帽玩具必須符合以下要求 a The highest average reading in any orientation must be less than or equal to 158 dB A 任意方向的最高平均讀數必須小于或等于158 dB A b If the average reading in any orientation exceeds 138 dB A then the warning statements and notifications to the Consumer Product Safety Commission CPSC as required by 16 CFR 1500 86 a 6 must be observed 如果任意方向的讀數超過138dB A 必須按16CFR1500 86 a 6 要求向消費者安全委員 CPSC 會發出警告聲明和通知 3 3 TESTTEST METHODSMETHODS 測試方法測試方法 3 1 3 1 EquipmentEquipment 儀器儀器 3 1 1 B Warning statements and notification to CPSC per 16 CFR 1500 86 a 6 required 2 2 Max avg symbol 163 f Symbol s 9 138 dB A If max max avgavg symbol 62 f Symbol s 9 138 dB A but symbol 163 f Symbol s 9 158 dB A then Warning statements and notification to CPSC per 16 CFR 1500 86 a 6 required 4 5 Max avg symbol 163 f Symbol s 9 138 dB A If max max avgavg symbol 62 f Symbol s 9 138 dB A but symbol 163 f Symbol s 9 158 dB A then Warning statements and notification to CPSC per 16 CFR 1500 86 a 6 required 1500 86 a 6 No requirement for sound level Warning statement required Warning Do not fire near eye