氟碳漆施工工艺方案.doc

氟碳漆施工方案氟碳金属漆涂装工艺一、流程图 施工工艺描述一 分格线1、 分格缝设置、定位、分格缝的长度、宽度、深度以及横竖方向按甲方要求进行。2、 分格缝的切割：根据分格进行切割，切割要横平竖直。分格缝切割后，用凿子剔平，并用水清洗缝内灰尘。3、 分格缝填充与修补:待批刮好粗腻子后,分次填充分格缝腻子,要深浅均匀,每次填充补前要用砂纸打磨并用水润湿分格缝,对缺脚等进行修补,做到棱角分明。4、 用圆弧形管拉成半弧形，待氟碳面漆喷完后，用羊毛刷着色。二找平腻子1、 用批刀在分割好的板块上沿水平方向满批一道腻子，用刮尺沿水平方向用力刮平，若有凹陷，则用腻子填充刮平。2、 待其完全干后，再沿垂直方向满批腻子一道，然后用另一把刮尺沿垂直方向竖刮，若有凹陷，则用找平腻子填充刮平。3、 若平整度仍达不到要求，重复上述步骤，直到满足平整度要求为止。三细腻子1、 将本品的甲乙组分拌和均匀（要求再4小时内用完），必要时加适当清水调节粘度。2、 满批细腻子1-2遍，间隔的时间为4-6小时，每遍腻子层厚度约为1-2mm。3、 干燥后用180#-240#砂纸打磨腻子表面。四渗透底漆:环氧底漆N5050C54201、 将环氧底漆N5050C5420按漆：固4：1重量比搅拌均匀后，再加入适量的稀释剂调节施工粘度。可用刷涂、滚涂、喷涂。2、 用喷枪吹干净细腻子表面的浮尘，开始刷涂环氧底漆N5050C5420，先横向刷涂一遍，再竖向刷一遍。3、 干燥24小时，无需打磨。五光面腻子1、 将光面腻子按比例配比混合均匀后，开始批刮。2、 满批光面腻子一遍，厚度大约为0.5mm。必要时可批刮第二遍光面腻子，但需间隔6小时。3、 施工光面腻子需干燥24小时之后采用400#砂纸打磨平整。(六)氟碳专用底漆:（氟碳中间漆U5800/C5800）1、 将氟碳中间漆U5800/C5800按漆:固12:1重量比搅拌均匀后，再加入适量的稀释剂调节施工粘度。静止5分钟消泡、熟化。可用刷涂、滚涂、喷涂。2、 调整喷枪的空气流量、出油量和喷雾幅宽，用喷枪吹干净基面的浮尘后，开始喷涂作业。3、 先横向喷涂一遍，再竖向喷涂一遍。注意喷涂图形的搭接，即去枪和回枪的运行轨迹有三分之一的部分相互重叠。这样重复1-2个过程。空压机的压力应的0.2Mpa-0.5Mpa之间。4、 底漆需至少干燥24小时后，用400#-600#砂纸打磨完全平整光滑为止。(七)氟碳面漆:氟碳金属漆F5801J/C58001、 将氟碳金属漆F5801J/C5800按漆:固=15:1面漆、固化剂、稀释剂按比例混合搅拌均匀后，静止5分钟消泡、熟化，用200目的过滤网过滤到喷枪壶内。2、 调整喷枪的空气流量、出油量和喷雾幅宽，用喷枪吹干净基面的浮尘后，开始喷涂作业。3、 先横向喷涂一遍，后竖向喷涂一遍。注意喷枪图形的搭接，即去枪和回枪的运行轨迹有三分之一的部分相互重叠。这样重复1-2个过程。注意事项1、 在易开裂的墙面，为了防止开裂，必须挂网。2、 找平腻子用刮尺刮两遍，使平整度小于2mm。必须严格做到。3、 腻子要注意保养和干燥时间，否则会引起水泡和开裂现象。4、 渗透底漆的漆膜不要喷涂太厚，以免影响干燥时间。渗透底漆也可以滚涂。5、 光面腻子不要一次批刮太厚，可以添加慢干稀释剂来调节干燥速度和粘度以便易于施工。6、 氟碳专用底漆的漆、固比例要掌握好，否则影响干燥速度。7、 面漆尤其金属面漆要掌握好环境温度和稀释剂的调整，应用慢干稀释剂来调整。8、 如要罩光,一定要掌握好漆固的配比比例,否则会引起色差。9、 要注意好氟碳漆整套体系中漆、固化剂和稀释剂的配套。10、喷涂氟碳漆面漆时，要把架子拆掉，用吊篮喷涂作业。11、每个工地要配发一定的慢干稀释剂（VX-03），以便调整挥发速度。12、氟碳漆达到最佳效果需要养护7天，因为它是一个慢速交联过程。 成都宇华建筑工程有限公司13880065868 2011-7-15 g an employment tribunal claimEmployment tribunals sort out disagreements between employers and employees.You may need to make a claim to an employment tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dismissed unfairly.For more information about dismissal and unfair dismissal, seeDismissal.You can make a claim to an employment tribunal, even if you haventappealedagainst the disciplinary action your employer has taken against you. However, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to appeal.Remember that in most cases you must make an application to an employment tribunal within three months of the date when the event you are complaining about happened. If your application is received after this time limit, the tribunal will not usually accept it.If you are worried about how the time limits apply to you, take advice from one of the organisations listed underFurther help.Employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.Most people find making a claim to an employment tribunal challenging. If you are thinking about making a claim to an employment tribunal, you should get help straight away from one of the organisations listed underFurther help.If you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee out of your compensation if you win the case. This is known as adamages-based agreement. In England and Wales, your solicitor cant charge you more than 35% of your compensation if you win the case.If you are thinking about signing up for a damages-based agreement, you should make sure youre clear about the terms of the agreement. It might be best to get advice from an experienced adviser, for example, at a Citizens Advice Bureau. To find your nearest CAB, including those that give advice by e-mail, click onnearest CAB.For more information about making a claim to an employment tribunal, seeEmployment tribunals.The (lack of) air up there Watch mCayman Islands-based Webb, the head of Fifas anti-racism taskforce, is in London for the Football Associations 150th anniversary celebrations and will attend Citys Premier League match at Chelsea on Sunday.I am going to be at the match tomorrow and I have asked to meet Yaya Toure, he told BBC Sport.For me its about how he felt and I would like to speak to him first to find out what his experience was.Uefa hasopened disciplinary proceedings against CSKAfor the racist behaviour of their fans duringCitys 2-1 win.Michel Platini, president of European footballs governing body, has also ordered an immediate investigation into the referees actions.CSKA said they were surprised and disappointed by Toures complaint. In a statement the Russian side added: We found no racist insults from fans of CSKA.Age has reached the end of the beginning of a word. May be guilty in his seems to passing a lot of different life became the appearance of the same day; May be back in the past, to oneself the paranoid weird belief disillusionment, these days, my mind has been very messy, in my mind constantly. Always feel oneself should go to do something, or write something. Twenty years of life trajectory deeply shallow, suddenly feel something, do it.一字开头的年龄已经到了尾声。或许是愧疚于自己似乎把转瞬即逝的很多个不同的日子过成了同一天的样子；或许是追溯过去，对自己那些近乎偏执的怪异信念的醒悟，这些天以来，思绪一直很凌乱，在脑海中不断纠缠。总觉得自己自己似乎应该去做点什么，或者写点什么。二十年的人生轨迹深深浅浅，突然就感觉到有些事情，非做不可了。The end of our life, and can meet many things really do?而穷尽我们的一生，又能遇到多少事情是真正地非做不可？During my childhood, think lucky money and new clothes are necessary for New Year, but as the advance of the age, will be more and more found that those things are optional; Junior high school, thought to have a crush on just means that the real growth, but over the past three years later, his writing of alumni in peace, suddenly found that isnt really grow up, it seems is not so important; Then in high school, think dont want to give vent to out your inner voice can be in the high school children of the feelings in a period, but was eventually infarction when graduation party in the throat, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already cant remember his appearance.童年时，觉得压岁钱和新衣服是过年必备，但是随着年龄的推进，会越来越发现，那些东西根本就可有可无；初中时，以为要有一场暗恋才意味着真正的成长，但三年过去后，自己心平气和的写同学录的时候，突然就发现是不是真正的成长了，好像并没有那么重要了；然后到了高中，觉得非要吐露出自己的心声才能为高中生涯里的懵懂情愫划上一个句点，但毕业晚会的时候最终还是被梗塞在了咽喉，后来再次站在他曾经挥汗如雨的球场，看着他投过篮球的球框时，突然间发现自己已经想不起他的容颜。Originally, this world, can produce a chemical reaction to an event, in addition to resolutely, have to do, and time.原来，这个世界上，对某个事件能产生化学反应的，除了非做不可的坚决，还有，时间。A persons time, your ideas are always special to clear. Want, want, line is clear, as if nothing could shake his. Also once seemed to be determined to do something, but more often is he backed out at last. Dislike his cowardice, finally found that there are a lot of love, there are a lot of miss, like shadow really have been doomed. Those who do, just green years oneself give oneself an arm injection, or is a self-righteous spiritual.一个人的时候，自己的想法总是特别地清晰。想要的，不想要的，界限明确，好像没有什么可以撼动自己。也曾经好像已经下定了决心去做某件事，但更多的时候是最后又打起了退堂鼓。嫌恶过自己的怯懦，最终却发现有很多缘分，有很多错过，好像冥冥之中真的已经注定。那些曾经所谓的非做不可，只是青葱年华里自己给自己注射的一支强心剂，或者说，是自以为是的精神寄托罢了。At the moment, the sky is dark, the air is fresh factor after just rained. Suddenly thought of blue plaid shirt; Those were broken into various shapes of stationery; From the corner at the beginning of deep friendship; Have declared the end of the encounter that havent start planning. Those years, those days of do, finally, like youth, will end in our life.此刻，天空是阴暗的，空气里有着刚下过雨之后的清新因子。突然想到那件蓝格子衬衫；那些被折成各种各样形状的信纸；那段从街角深巷伊始的友谊；还有那场还没有开始就宣告了终结的邂逅计划那些年那些天的非做不可，终于和青春一样，都将在我们的人生中谢幕。Baumgartner the disappointing news: Mission aborted. r plays an important role in this mission. Starting at the ground, conditions have to be very calm - winds less than 2 mph, with no precipitation or humidity and limited cloud cover. The balloon, with capsule attached, will move through the lower level of the atmosphere (the troposphere) where our day-to-day weather lives. It will climb higher than the tip of Mount Everest (5.5 miles/8.85 kilometers), drifting even higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. As he crosses the boundary layer (called the tropopause),e can expect a lot of turbulence.The supersonic descent could happen as early as Sunda.The weatheThe balloon will slowly drift to the edge of space at 120,000 feet ( Then, I would assume, he will slowly step out onto something resembling an Olympic diving platform.Below, the Earth becomes the concrete bottom of a swimming pool that he wants to land on, but not too hard. Still, hell be traveling fast, so despite the distance, it will not be like diving into the deep end of a pool. It will be like he is diving into the shallow end. Skydiver pre