服装品质控制QC词汇.doc

服装品质控制（QC）词汇APPROVED SWATCH 已批的布办 ART. NO./STYLE NO. 款号 AUTOLOCK ZIPPER 自动锁拉链 BACK STITCHES 回针/返针 BAD JOINED STITCHES 驳线不良 BROKEN HOLE 破洞 BROKEN STITCHES 断线 BROKEN YARN 断纱 BUBBLING 起泡 BUMP AT PLACKET EDGE 筒边钮门位不顺直 CENTER BACK RIDES UP 后幅起吊 CHECKS / STRIPES NOT MATCH 格仔/条子不对称 COLLAR POINTS HI / LOW 领尖高低 COLOR FADING 褪色 COLOR FASTNESS PROBLEM 褪色问题 COLOR FIBRE WOVEN IN 杂色纤维织入 COLOR SHADING 色差 COLOR THREAD LEFT INSIDE 藏色线 COLOR TOO DULL / BRIGHT 颜色太哑/闪 COLOR YARN 色纱 COMBI PROGRAM 配色组合 CONTRAST COLOR 撞色 CREASE MARK 折痕 CROCKING TEST 摩擦测试 CROSSED BACK VENT 背叉搅 CUFF EDGE NOT LEVELED 鸡英边高低 DIRTY DOT （较小的）污点 DIRTY MARK 污渍 DIRTY SPOT （较大的）污点 DROP TEST 跌落测试 DRY RUB 干擦 EXCESS EXTENSION 突咀 FABRIC DEFECT 布疵 FABRIC TOO CLOSED TO ZIPPER 面布车得太贴近拉链 FLAP STRICKING UP 袋盖反翘 FLUO.=FLUORESCENCE 荧光 FLYING UP 飞起，翘起 FTY.STICKER 工厂的贴纸 GAPPING 藏木虱（烫工） GLAZE MARK （熨烫）起镜 HEM NOT LEVELED 高低脚 HI / LOW POCKET 高低袋 HIKING AT BOTTOM OF PLACKET 前筒吊脚 HIKING UP 起吊 HORIZONTAL SEAM NOT LEVELED 水平缝骨不对称 INNER CUFF VISIBLE 介英反光 IRON MARK 烫痕 KNOT 结头 LASTEST SIZE SPECIFICATION 最新的尺寸表 LINING TOO FULL / TIGHT 里布太多/太紧 MAJOR DEFECT 大疵 MATCH COLOR 配色 MATERIAL DEFECT 物料疵点 MINOR DEFECT 小疵 MIXED COLOR YARN 色纱 NECK DROP PUCKER 筒顶起皱 NEEDLE DAMAGE 针损坏布料 NEEDLE HOLE 针孔 OFF GRAIN 布纹歪 OIL STAIN 油渍 OPEN SEAM 爆口 OVERLAPPED COLLAR 迭领，踏领 OVERLAPPED LIPS 迭唇 OVERPRESS 熨烫过度 OVERWASH 洗水过度 PLACKET BOTTOM SPREAD OPEN 筒脚张开 PLACKET WAVY 前筒起蛇（皱） PLEATED SEWING 打褶 POCKET OPENING SPRAY OPEN 口袋“笑口” POOR BACK-STITCHES 回针不佳 POOR IRONING 烫工不良 PRESSING MARK 压痕 PREVIOUS SHIPMENT 以前走的货 PRODUCTION STATUS 生产情况 PUCKER 起皱 QC STICKER QC贴纸，“鸡纸” RAW EDGE 散口 RUN OFF STITCHES (车缝）落坑 PRINTING SCRIMP 印花裂痕 SEAM OVERTURN 止口反骨 SEWN IN WASTE 车缝时混有杂物 SHADING GARMENT TO GARMENT 衫与衫之间色差 SHADING WITHIN 1PCS GARMENT 衣服裁片色差 SHIPMENT UNDER CONSIGNMENT 寄卖 SHORT SHIPMENT 短装 SKIPPED STITCHES 跳线 SLANTING POCKET 歪袋 SLUB 毛粒 SMILING POCHET 袋“笑口” STICKER 贴纸 STITCHES NOT IN SEAM SHADOW 缝线没被盖住 STRIPES/CHECKS NOT MATCHING 不对条/格 SUB-CONTRACTOR 外发厂 SUBSTITUTE FABRIC 代用布 SUPPORT SITCHES VISIBLE 辅助线外露 FABRIC SWATCH 布办 TENSION 张力 THICK YARN 粗纱 TOPPEST PLACKET PUCKER 筒顶起皱 TOTAL DIFFERENT COLOR 颜色完全不同 TRAPPED COLOR THREAD 藏色线 TWIST 扭 TWIST LEG 扭髀 UNCUT THREAD ENDS 线头 UNDER STITCHES VISIBLE 底线露出 UNDERPLY TURN OUT 反光 UNDERPLY VISIBLE OUTSIDE 反光 UNDERPRESS 熨烫不够 UNDESIREABLE ODOR 臭味，不可接受的气味 UNEVEN COLLAR 歪领 UNEVEN COLOR 深浅色 UNEVEN LENGTH OF PLACKET 长短筒 UNEVEN LENGTH OF SLEEVE 长短袖 UNEVEN LIPS 大小唇 UNEVEN STITCHING DENSITY 针步密度不均匀 UNMATCHED CROTCH CROSS 下裆十字骨错位 UNMEET BACK VENT 背叉豁 WET RUB 湿擦 WRONG COMBO 颜色组合错误 WRONG PATTERN 图案错误 WRONG SIZE INDICATED 错码 YARN DRAWN OUT 抽纱 ZIPPER NOT MOVABLE 拉链不能拉验货用语资料成品检验Checking of finished products检验，检查inspection, check商检commodity inspection领面松wrinkles at top collar领面紧top collar appears tight领面起泡crumples at top collar领外口松collar edge appears loose领外口紧collar edge appears tight底领伸出collar band is longer than collar底领缩进collar band is shorter than collar底领里起皱wrinkles at collar band facing底领外露collar band lean out of collar倘领偏斜collar deviates from front center line领窝不平creases below neckline后领窝起涌bunches below back neckline驳头起皱wrinkles at top lapel驳头反翘top lapel appears tight 驳头外口松lapel edge appears loose驳头外口紧lapel edge appears tight驳口不直lapel roll line is uneven串口不直gorge line is uneven领卡脖tight neckline领离脖collar stand away from neck小肩起皱puckers at shoulders塌肩wrinkles at shoulder袖隆起皱creases at underarm袖隆缝起皱puckers at underarm seam塌胸lack of fullness at chest省尖起泡crumples at dart point拉链起皱wrinkles at zip fly止口不直front edge is uneven止口缩角front edge is out of square止口反翘front edge is upturned止口反吐facing leans out of front edge止口豁split at front edge止口下部搭迭过多crossing at front edge底边起皱wrinkles at hem后身起吊back of coat rides up背衩豁开split at back vent背衩搭迭过多crossing at back vent绗棉起皱puckers at quilting絮棉不均padded cotton is uneven边缘缺棉empty hem绱袖不圆顺diagonal wrinkles at sleeve cap袖子偏前sleeve leans to front袖子偏后sleeve leans to back前袖缝外翻inseam leans to front袖口起皱wrinkles at sleeve opening袖里拧diagonal wrinkles at sleeve lining袋盖反翘top flap appears tight袋盖反吐flap lining leans out of edge袋盖不直flap edge is uneven袋口角起皱creases on two ends of pocket mouth 袋口裂split at pocket mouth腰头探出end of waistband is uneven腰缝起皱wrinkles at waistband facing里襟里起皱creases at right fly夹裆tight crotch短裆short seat后裆下垂slack seat前浪不平wrinkles at front rise裆缝断线bursting of crotch seam裤脚前后two legs are uneven脚口不齐leg opening is uneven吊脚pulling at outseam or inseam烫迹线外撇crease line leans to outside烫迹线内撇crease line leans to inside腰缝下口涌bunches below waistline seam裙裥豁开 split at lower part of skirt裙身吊split hem line rides up裙浪不匀skirt flare is uneven 线路偏移stitch seam leans out line双轨接线 stitch seam is uneven跳针 skipping尺码不符 off size缝制不良stitching quality is not good洗水不良washing quality is not good熨烫不良pressing quality is not good极光iron-shine水渍water stain锈迹rust污渍spot色差color shade, off shade, color deviation褪色fading, fugitive color线头thread residue毛头raw edge leans out of seam绣花不良embroidery design out line is uncoveredQC评语The out-come / appearance of the frills of sealing sample is not ccceptable, it looks very flat / dead, must be more balanced / natural look as standard sample DD 28.8.02.前中荷叶边太死太平，不够生动，请以2002年8月28日的办做标准。Sort out the major material defects.挑出严重布疵。Take care for trimming + cleaning.留意剪线和清洁。Stringholes from plastic string ( for washing ) at pocket flap visible, must be removed.袋盖上有洗水时打的枪针洞，请消除。Front horizontal seam not leveled.前幅横骨不对称。Handfeel slightly softer than approved sample.手感比批办稍软。Armhole pipping ( inside) 2mm more than sealing sample.夹圈滚条宽度比原办大了2mm。Pls. add one more button for bigger sizes.请在大码的衣服上加多一颗钮扣。Make sure inner facing is long enough in order to avoid pulling at placket bottom.确保襟贴足够长以避免前襟起吊。Pay attn. the workmanship of ironing, dont press the seam too much and avoid the seam allowance see through by heavy pressing.注意烫工，骨位不要烫太重，避免缝骨止口起痕。Center front collar not overlap but also not spray.领子前中不要重迭但也不要张开。Bust dart seam allowance must be ironed upward.胸折止口要烫向上面。Uneven width of top-stitches at closure edge.前襟边面线宽度不均匀。Pls. add one more button for all sizes as the distance from hem is too big.请在所有尺码的衣服上加多一颗钮扣，因为离衫脚的距离太大。Pls. fix pocket with movable stitches as sealing sample.请跟原办在口袋上车上（可拆去的）假缝线。The collar band must not visible at back when wear.衣服穿着时下级领不能外露。Pls. make sure the collar are balanced on both sides.请确保领子两边对称。Found 3 colors shade within 10 pcs!十件衣服中有三种色差！3