10-35KV金属氧化物避雷器说明书.doc

金属氧化物避雷器安装使用说明书目 录一概述1二正常使用条件1三型号及意义1四复合外套金属氧化物避雷器主要技术参数21、电站用无间隙金属氧化物避雷器22、配电用无间隙金属氧化物避雷器33、并联补偿电容器用无间隙金属氧化物避雷器34、发电机、电动机、电机中性点保护用无间隙金属氧化物避雷器45、变压器中性点用无间隙金属氧化物避雷器56、带串联间隙的金属氧化物避雷器57、电气化铁道无间隙的金属氧化物避雷器68、线路用复合外套无间隙的金属氧化物避雷器6五复合外套金属氧化物避雷器外形结构及安装尺寸图7六瓷外套金属氧化物避雷器11七瓷外套金属氧化物避雷器外形结构及安装尺寸图13八用户须知16 金属氧化物避雷器简介一、 概述金属氧化物避雷器（MOA）是用于保护输变电设备的绝缘免受过电压危害的重要保护电器，它具有响应快、伏安特性平坦、性能稳定、通流容量大、残压低、寿命长、结构简单等优点，广泛使用于发电、输电、变电、配电等系统中。复合外套金属氧化物避雷器是用硅橡胶复合材料做外套，和传统的瓷外套避雷器相比，具有尺寸小、重量轻、结构坚固、耐污性强、防爆性能好等优点。本厂产品规格齐全，各类繁多。不但有各种常规产品，而且各种非标的、大容量的、大爬距的、高原防污的、全绝缘内出线式的等都可生产。本厂避雷器产品采用标准为：IEC60099-4：1991、GB11032-2000、JB/T6479-1992 。为适应国际市场的需要，本厂还可以按英标、美标或出口商指定的技术标准进行生产。二、 正常使用条件1、 环境温度不低于40，不高于40；2、 海拔高度不超过2000m（瓷套式不超过1000 m）；3、 电源频率不小于48 Hz、不大于62 Hz；4、 安装地点凤速不超过35m/s；5、 长期施加在避雷器上的工频电压不超过避雷器的持续运行电压（无间隙MOA）或额定电压（串联间隙MOA）。6、 地震裂度8度以下地区；三、 型号及意义四、复合外套金属氧化物避雷器主要技术参数1、 电站用无间隙金属氧化物避雷器技术参数产品型号系统标称电压避雷器额定电压避雷器持续运行电压直流参考电压KV2ms方波电流A 陡波冲击残压雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY5WZ-5/13.5354.07.215015.513.511.52HY5WZ-10/276108.014.415031.027.023.02HY5WZ-12/32.410129.617.415037.232.427.65、8HY5WZ-15/40.5101512.021.815046.540.534.55、8HY5WZ-17/45101713.624.015051.845.038.35、8HY5WZ-12.5/45*1012.76.624.015051.845.038.35、8HY5WZ-16.5/45*1016.513.624.015051.845.038.35、8HY5WZ-42/134*354223.473.04001541341141114HY5WZ-51/134355140.874.04001541341141114HY5WZ-51/130355140.873.04001501301121114HY5WZ-51/125355140.873.04001441251071114HY5WZ-52.7/1343552.742.275.04001541341141114HY5WZ-52.7/1303552.742.274.04001501301121114HY5WZ-52.7/1253552.742.273.04001451251101114HY5WZ-53/134355342.275.04001541341141114HY5WZ-54/134355443.276.04001541341141114HY5WZ-54/130355443.275.04001501301121114HY5WZ-51/125355443.274.04001451251101114注：带*者为旧标准型号2、 配电用无间隙金属氧化物避雷器技术参数产品型号系统标称电压避雷器额定电压避雷器持续运行电压直流参考电压KV2ms方波电流A 陡波冲击残压雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY1.5W-0.28/1.30.220.280.240.650/1.3/1HY1.5W-0.5/2.60.380.50.421.250/2.6/1HY5W-5/15354.07.510017.31512.83HY5W10/306108.01510034.63025.63HY5W-12/35.810129.618.010041.235.830.66、9HY5WS-15/45.6101512.02310052.545.639.06、9HY5WS-17/50101713.62510057.550.042.56、9HY5WS-7.6/30*67.64.01510034.630.025.66、9HY5WS-12.7/50*1012.76.62510057.550.042.56、9HY5WS-16.5/45*1016.513.62415051.045.038.06、9注：带*者为旧标准型号3、 并联补偿电容器用无间隙金属氧化物避雷器技术参数产品型号系统标称电压避雷器额定电压避雷器持续运行电压直流参考电压KV2ms方波电流A 雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY5R-5/13.5354.07.240013.510.54HY5R-10/276108.014.440027.021.04HY5R-12/32.410129.617.440032.425.27、10HY5R-15/40.5101512.021.840040.531.57、10HY5R-17/45101713.624.040045.035.07、10HY5R-51/134355140.873.04001341051114HY5R-51/125355140.871.04001251051114HY5R-52.7/1343552.742.274.54001341051114HY5R-52.7/1253552.742.274.54001251051114HY5R-54/134355443.375.04001341051114HY5R-7.6/17*67.64.01040017.014.54HY5R-32/84*203225.64640084.071.81114HY5R-42/134*354223.8704001341051114注：带*者为旧标准型号4、 发电机、电动机、电机中性点用无间隙金属氧化物避雷器技术参数产品型号电机额定电压避雷器额定电压避雷器持续运行电压直流参考电压KV大电流冲击耐压KA2ms方波电流A 陡波冲击残压雷电冲击残压操作冲击残压图号备注KV（有效值）KV（峰值）HY5WD-4/9.53.1543.25.76540010.79.57.64发电机用HY5WD-8/18.76.386.311.26540021.018.715.04HY5WD-13.5/3110.513.510.518.66540034.731.025.07、10HY5WD-17.5/4013.817.513.824.46540044.840.032.07、10HY5WD-20/4515.82015.828.06540050.445.036.07、10HY5WD-23/51182318.031.96540057.251.040.87、10HY5WD-25/56.5202520.035.46540062.956.245.07、10HY2.5WD-4/9.53.1543.25.76540010.79.57.64电动机用HY2.5WD-8/18.76.386.311.26540021.018.715.04HY2.5WD-13.5/3110.513.510.518.66540034.731.025.07、10HY2.5WD-3.8/9.5*3.153.82.05.640200/9.5/3HY2.5WD-7.6/19*6.37.64.011.340200/19.0/3HY2.5WD-12.7/31*10.512.76.618.940200/31.0/6、9HY2.5WD-16.7/40*13.816.79.024.840200/40.0/6、9HY2.5WD-19/45*15.81910.528.240200/45/6、9HY2.5WD-13.2/31*10.513.210.518.940200/31.0/6、9HY1.5W-2.4/63.152.41.93.465200/6.053电机中性点用HY1.5W-4.8/126.34.83.86.865200/12.0103HY1.5W-8/1910.586.411.465200/19.015.93HY1.5W-10.5/2313.810.58.414.965400/23.019.23HY1.5W-12/2615.8129.617.065400/26.021.66、9HY1.5W-13.7/29.218.013.711.019.565400/29.224.36、9HY1.5W-15.2/31.72015.212.221.665400/31.726.43HY1W-2.3/6*3.152.31.93.440200/6.0/3HY1W-4.6/12*6.34.63.86.940200/12.0/3HY1W-7.6/19*10.57.66.411.340200/19.0/注：带*者为旧标准型号5、 变压器中性点用无间隙金属氧化物避雷器技术参数产品型号系统标称电压避雷器额定电压避雷器持续运行电压直流参考电压KV大电流冲击耐受KV2ms方波电流A 雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY1W-51/155*1105140.873654001551341114注：带“*”者为旧标准型号6、 带串联间隙的金属氧化物避雷器技术参数产品型号系统标称电压避雷器额定电压工频放电电压2ms方波电流A 1.2/50冲击放电电压标称放电电流下残压图号KV（有效值）KV（峰值）HY5CS-3.8/1533.89100151524HY5CS-7.6/2767.616100272724HY5CS-12.7/451012.7261004545710HY5CZ-3.8/1233.89100121234HY5CZ-7.6/2467.616100242434HY5CZ-12.7/411012.7261504141710HY5C-3.8/13.833.8910013.813.834HY2.5CD-3.8/8.633.87.61008.618.624HY2.5CD-7.6/1767.615200171734HY2.5CD-12.7/281012.725150282834HY5C-22/582022424005858710HY5CZ-42/1243542804001241241114注：带“*”者为旧标准型号7、 电气化铁道用无间隙金属氧化物避雷器技术参数产品型号电机额定电压避雷器额定电压避雷器持续运行电压直流参考电压KV大电流冲击耐压KA2ms方波电流A 陡波冲击残压雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY5WT-42/12027.54234.067654001381209812、13HY5WT-41/11527.54132.867654001331159412、13HY10WT-42/12027.54234.0661004001381209812、13HY10WT-41/11527.54132.8661004001331159412、138、 线路用复合外套无间隙金属氧化物避雷器技术参数产品型号电机额定电压避雷器额定电压避雷器持续运行电压直流参考电压KV大电流冲击耐压KA2ms方波电流A 陡波冲击残压雷电冲击残压操作冲击残压图号KV（有效值）KV（峰值）HY5WX-17/50101713.6256540057.55042.56HY5WX-42/134354223.8736540015413411415、16HY5WX-51/134355140.8746540015413411415、16HY5WZ-52.7/1343552.742.2746540015413411415、16HY10WX-54/140355443.2766540016114012015、16HY5WX-54/150355443.2806540016915012815、16五、复合外套金属氧化物避雷器外形结构及安装尺寸图 17六、瓷外套金属氧化物避雷器瓷外套金属氧化物避雷器典型性产品技参数产品型号系统标称电压避雷器额定电压持续运行电压直流1mA参考电压陡波冲击残压标称放电电流下残压操作冲击残压4/10s冲击耐受2次2ms方波通流容量参考重量图号KV（有效值）KVKV（峰值）kAAkgY5WS-5/15354.07.017.315.012.8/10031Y5WS-10/306108.015.034.630.025.44010041Y5WS-17/50101713.625.057.550.042.54010042Y5WZ-10/276108.014.431.027.023.04015041Y5WZ-17/45101713.624.051.845.038.34015042Y5WR-12/32.410129.617.4-32.425.2404004.54Y5WR-17/46101713.624.0-46.035.0404004.54Y5WR-51/134355140.873.0-134.0105.065400705Y5WR-42/134*354223.470.0154134114.040400705Y2.5WD-8/18.76.386.311.221.018.715.0/40043Y1.5W-4.8/126.34.83.86.8-12.010.04020041Y1.5W-8/1910.57.66.411.4-19.015.94020041Y5WZ-42/134*354223.473.0154134114.040400705Y5WT-42/120354234.065.013812098.040400705Y5W-51/134355140.873.0154134114.065400805Y5W-52.7/1343552.742