粘合剂MSDS.doc

物 资 安 全 资 料 表Material Safety Date Sheet一、 物品与厂商资料 Identification of the substance / preparation and company物品名称 Product Information :胶粘剂 粘合剂 制造商/供货商名称： Information on Producer/Supplier Name: 地址： Address: 电话/传真：Phone/Fax：紧急联络电话：Emergency Phone：二、 资料 Composition / Information on Ingredients纯物质 Single:名称：粘合剂English Name: Bond同义名称：synonyms:化学文摘社登记号码：（CAS NO）Chemical Abstracts Number ：（CAS NO）混合物Mixing：化学性质Chemical Character危害物质成分之中英文名称Foe Components Name化学文摘社登记号码（CAS NO）浓缩比（成分百分比）Concentration/Percentage危害物质分类及图示Foe Symbols合成橡胶incorporated latex203树脂colophony203混合有机溶剂Mix organic impregnant603三、危害辨识资料 Hazards Identification主要危害效应 Major Hazard Effect健康危害效应：头痛、晕眩、困倦、呕吐Hazard Warnings for Health: Headache , Qualm , Vomit and drowsiness.环境影响：空气污染和水污染Hazard Warnings for Environment : Air pollution and water pollution. 物理性及化学性危害：易燃、易爆炸溶剂Physical and Chemical Dangerous : Exploslve and water pollution.特殊症状 Special harm:主要症状：头痛、晕眩、困倦、呕吐。Major Sate : headache , dizziness ,vomit and drowsiness四、急救措施 First Aid Measures不同暴露途径之急救方法：Emergency and First Aid Procedures:吸入 Inhalation:1、 立即将患者移至新鲜空气处 Remove to fresh air 2、 若呼吸停止，施予人工呼吸，若心脏停止跳动，则施予心肺复苏术，立即就医。Not expectted to require first aid measures.皮肤接触 Skin Contact1、 用温水缓和冲洗15分钟。Wash skin with soap and water for at least 15 minutes.2、 若仍有刺激感，反复冲洗并立即送医。Get medical attention if irritation develops or Persists.眼睛接触 Eyes contact:撑开眼皮，立即用温水缓和冲洗，若刺激仍在应立即送医In case of contact , immediately flush eye with plenty of water for at least 15 minutes .Lifting upper and lower eyelids occasilnally. Call . apysician if irritation persists.食入 Inhalation 1、 若患者即将失去意识，已失去意识或痉挛，不可喂食任何东西，不可催吐。Never give anything by mouth to an unconscious person.2、若患者意识清醒给患者水或牛奶饮用。 Induce vomiting immediately as directed by medical personnel.3、 立即就医。Call a physician.最重要的症状及危害效应：头痛、晕眩、困倦、呕吐。Major Disease and Harm Effect : headache , dizziness, vomit and drowsiness.对急救人员之防护：戴防护手套，以免接触污染物。First Aid Personal Protection : Wear respirator, rubber gloves, goggles and protecitive clothing. 对医师之提示：树脂种类。Prompt to Doctor: kind of resin.五、灭火措施 Fire Fighting Measures适用灭火剂：干粉、泡沫、二氧化碳Suitable Extinguishing Media : Powder . Foam .CO: Extinguisher.灭火时可能遭遇之特殊危害：蒸气传播可能造成回火。Special Exposure Hazards : Formation of carbon monoxide , nitrogen oxides , isocyanate vapors and Traces of hydrogen eyanate may occur .消防人员之特殊防护设备：戴防护口罩、护目镜及防护衣。Special Protection Equipment : Wear respiratory protection equipment ,goggles and protective clothing.六、泄露处理方法Accidental Release Measures个人应注意事项：戴口罩、橡胶手套、护目镜及防护衣。Personal protection : Wear respirator , rubber gloves , goggles protective clothing.环境注意事项：避免流入下水道以免阻塞。Environmental Protection : Prevent entry into the sewage system , rick of blocdage due to polymer.清理方法：以吸湿物质覆盖，再以铁锹装入容器。Methods for Cleaning Up: Cover residues with humid substance , then fill into container by shovel. 七、安全处置与储存方法 Handling and Storage处置：工作区域保持通风良好。Handling : Ensure efficient eshaust ventilation in the working area.储存：容器保持密封，并储存于阴凉处。Storage : Keep container tightly closed and store at dry place.八、暴露预防措施 Exposure Controls/Personal Protetion工程控制 Engineering Control:控制参数： Control Factor八小时日时量平均容许浓度/短时间量平均容许浓度/最高容许浓度/生物指标TWA:100rrs/STEL:125rrs/CEILING:-/BEI:-个人防护设备 Personal Protection Equipment呼吸防护：可配戴吸附有机溶剂用之防护具。Respiratory protection : Wear air-supplied respirator.手部防护：戴手套 Hand Protection :Wear gloves.眼睛防护：护目镜，耐有机溶剂之脸部防护设备，洗眼设备。Eye Protection :Wear goggles.皮肤及身体防护：化学防护衣。Skin & Body Protection : Wear protective clothing.卫生措施 Hygiene Procedures:1、 工作后尽速脱掉污染之衣物，洗净后才可再穿戴或丢弃。2、 工作场所严禁抽烟或饮食。3、 处理此物后，须彻底洗手。4、 维持作乐场所清洁。Observe the common precautionary measures, contaminated clothes must be changed immediately , wash hands after work is completed. 九、物理及化学性质 Physical and Chemical Properties物质状态 Appearance: 糊状物 Liquid形状 Form:颜色 Color:浅黄色粘稠液体 light yellow气味:Odor:溶剂味 solventPH 值 PH value:沸点 / 沸点范围 Boiling Point/Boiling Renge:85C-110C分解温度 Decomposition Temperature:-闪为点 Flash Point:-15C-4C测试方法 Test Method: 闭杯 Close Cup自燃温度 Spontancous Temperature:-爆炸界限 Exposure Range :爆炸下限 （LEL）: 12%爆炸上限 （ULE）:7.1%蒸气压 Vapor Pressure :70-90mmHg 20C蒸气密度（Air=1） Vapor Density : 2.0-3.1密度 Specific Gravity (Water=1) :0.8-0.9水中溶解度 Solubility in Water :水不溶性 NO. 十、安定性及反应性 Stability and Reactivity安定性 Stability:安定 Stable特殊情况下可能之危险反应 Special Conditions of Hazardous Reaction:- 应避免之情况：正常情况下安定，但因其可形成过氧化物，在长期储存或长期暴露与空气或受热下，则可能爆炸，故应避开火焰、火花、静电、热及其他引火源。Conditions to Avoid : Keep away from flame应避免之物质 Incompatibility : 强碱强酸 Strong aldalis and strong acids.危害分解物：爆炸性过氧化物，如丁酮过氧化物，热分解产生一氧化碳、二氧化碳。Hazardous Decomposition Products : Formation of conbustible and noxious fumes during themal decomposition .十一、毒性资料 Toxicological Information急毒性 Acute Toxicity : LDen (测试动物、吸收途径) 5g/kg (大鼠口服)LCen (测试动物、吸收途径) 5320ppm/6hrs (大鼠吸入)局部效应 Local Effects:-致敏感性 Sensitive:-慢毒性或长期性 Chromic:对神经、肝及皮肤有影响 Nervous breakdown 特殊效应 Exceptional Effect:-十二、生态资料 Ecological Information可能之环境影响/环境流失：污染水源，勿排入河川，沟渠或地表。Possibility of Environmental Impact / Move:Hazardous to water,Must not enter the Waters,Drains or Ground.十三、废弃处理方法 Disposal Considerations废弃处理方法：依环保署、交通部及各政府法令办理。Disposal Considerations : Should be disposed of appropriate incincration unit observing official local regulations.十四、运送资料 Transport Information国际运送规定 International Transport Information:-联合国编号 The United Nations Number(Un-No):-国内运送规定 Internal Transport Information:- 特殊运送方法几注意事项：远离食品、酯及碱，并放置于阴凉处。Special