4JB1柴油发动机简介基础

1、 1.3 4JB1 发动机总成4JB1 ENGINE ASSYrWWwnrfi=tl序号NO.部件代号CodeBQ1000100-30A0-BQ1000100-34A0-BQ1000100-34A1-1.3 4JB1发动机总成4JB1发动机总成4JB1发动机总成4JB1发动机总成部件名称Name4JB1 ENGINE ASSY4JB1 Engine assy4JB1 Engine assy4JB1 Engine assy数量Qty适用车型备注Vehicle model RemarksAJD、AJHI、AJHIIAJD、AJHI、AJHIIAJD、AJHI、AJHII机械扇电子扇电子扇不带“IS

2、UZU ” 标1.3-01 供油系统 FUEL SYSTEM1514Oi16-v1616131&J1416竺；V1620 一22301 供油系统 FUEL SYSTEM序号NO.部件代号Code部件名称Name数量Qty适用车型Vehicle mode备注l Remarks1XN1104210000第1缸高压油管总成High P ressure pipe assy-No. 112XN1104220000第2缸咼压油管总成High p ressure pipe assy-No. 213XN1104230000第3缸咼压油管总成High p ressure pipe assy-No. 314XN1

3、104240000第4缸高压油管总成High p ressure pipe assy-No. 415XN1104150000高压油管管夹总成Cli p assy-High p ressure pipe26KBA L-P 001F喷油器总成Fuel injector assy48XN1112347001O型圈一喷油器壳体0-ring of fuel in fector cover49XN1112349000垫块Block410XN1112344001喷油器固定压板Pressure board-fuel injector412XN1112345001螺栓一喷油器压板Bolt-fuel in fec

4、tor p ressure board413XN1104114000喷油嘴间软管Hose-fuel no zzle to no zzle314XN1104170000燃油回油软管Hose-no zzle leak off115XN1104116000油嘴帽Cap-no zzle end116XN1104270000橡胶软管管夹Cli p-rubber hose917NJ-VE4/12F1900LNJ01喷油泵Fuel inject ion pump assy118XN1111240000喷油泵后托架总成Support bracket assy-injector pump-rear119XN11

5、11237000喷油泵后支架Bracket-injector pump-rear120XN1000420000带垫圈螺栓Bolt with washer221XN1000360000带垫圈螺栓Bolt with washer2序号NO.222324252627部件代号CodeQ1420825Q40108XN1110120000XN1110130000XN1002506000XN1000380000螺栓组合件平垫圈高怠速执行器部件名称NameBolt modulesP lain washerActuator-fast idle控制高怠速电磁阀（随机附 件）0型圈一前支架到正时齿轮C室Gasket

6、-fr ont bracket to tim ing gear caseElectromag netism valve-c on trol fast idle齿轮室盖接缝螺栓Bolt-gear case数量Qty2适用车型备注Vehicle model Remarks02 曲柄连杆机构 CRANKSHAFT AND CONNECTING ROD3*处%8 6r J丘以令Kiel02 曲柄连杆机构 CRANKSHAFT AND CONNECTING ROD序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle modelRemarks1 1XN1002411001曲轴上

7、轴瓦Upper beari ng kit-cra nkshaft51 2XN1002412001曲轴下轴瓦Lower beari ng kit-cra nkshaft52XN1002413001曲轴止推片Thrust-cra nkshaft beari ng23XN1004030000活塞P isto n44 1XN1004025000第一道压缩环Pressure ring-piston-N o.144 2XN1004026000第二道压缩环Pressure ring-piston-N o.244 3XN1004020000油环Oil scra per ring45XN1004040001连杆

8、总成Connecting rod assy46XN1004058000连杆螺栓Bolt-c onn ecti ng rod87XN1004062000连杆螺母Nut-c onnecting rod88XN1004065001连杆衬套Bush in g-c onnecting rod49XN1004068001连杆轴瓦Beari ng set-c onnecting rod810XN1004018001活塞销P isto n pin411XN1004021000钢丝挡圈Steel ring812XN1005021001曲轴Cran kshaft113E180203GB279-79轴承Beari

9、ng-radial ball cran kshaft114XN1005120000飞轮总成Flywheel assy115XN1005125000齿圈Gear rin g-flywheel116XN1005217000螺栓一飞轮至曲轴Bolt-flywheel to cran kshaft817XN1005126000垫片一飞轮固定用Washer for fixing flywheel1序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks18XN1005048000平键P lain key119XN1006204000齿轮一曲轴Gear-

10、era nkshaft120XN1005060000减震器皮带轮Belt p ulley-da mper121XN1005035000甩油盘Thrower-dust seal122XN1005045001螺栓一减震器皮带轮Bolt-da mper belt p ulley123XN1601400000离合器从动盘总成Clutch drive n disc assy124XN1601500000离合器压盘及盖总成Plate and cover assy for p ressure clutch125XN1601510000压盘螺钉Bolt-p ressure pl ate603 缸盖 CYLIN

11、DER HEAD ASSY191615*6514252717-?卧岔 18101312 03 缸盖 CYLINDER HEAD ASSY序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks1XN1003240001气缸垫片Gasket-cyli nderGASKET; CYL. HEAD12XN1003313000衬垫一气缸盖罩Gasket-cyli nder cover13XN3770112000电热塞连接片Conn ector-glow plug13-1XN3770113000电热塞接头Junction-glow plug14XN37

12、70110000电热塞Glow p lug45XN1000340000带垫圈螺栓Bolt with washer26XN1002642000发动机吊钩Han ger for lift ing engine17XN1003118001气缸盖螺栓Bolt-cyli nder cover188XN1003107000气门导管Guide pip e-valve89XN1003104000碗形塞片Cup-seali ng drilled p ass510XN1003105000气门座圈一进气Valve seat in sert-i niet411XN1003106000气门座圈一排气Valve seat

13、 in sert-exhaust412XN1003103000碗形塞片Cup-seali ng-cyli nder head313XN1003102000碗形塞片一气缸盖用Cup-seali ng-cyli nder cover714XN1003332000气缸盖罩隔音海绵Spon ge-so und in sulati on-cyli nder cover115XN1003340000气缸盖罩壳Cyli nder cover shell116XN1003340000气缸盖罩总成Cyli nder cover assy117XN1003115000垫圈Washer218Q1420816气缸盖及

14、罩壳联结螺栓Connecting bolt-cyli nder cover and shell219XN1014110000曲轴箱通风阀总成Ven tilated valve assy-cra nkshaft1序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks20Q2320408螺钉组合件Screw modules421XN1003314000盖形螺母一气缸盖罩用Nut with cap-cyli nder cover322XN1003320000衬垫一气缸盖罩螺母用Gasket-cyli nder cover nut323XN1003

15、316001加机油口盖Oil filler cap124XN1003318000密封垫圈P ack in g-oil filler cap125XN8104111000空调压缩支架A/C comp ressor bracket126Q151C1060TF2压缩机安装支架螺栓Bolt-co mp ressor bracket227Q1420860压缩机安装支架螺栓Bolt-co mp ressor bracket204 进排气机构 INTAKE AND EXHAUST SYSTEM2111024.1813XL23221716197 6in12 gI 252004 进排气机构 INTAKE AND

16、 EXHAUST SYSTEM序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks1XN1003100001缸盖Cyli nder cover12XN1008120000衬垫一排气歧管用Gasket-exhaust mani fold pipe13XN1008125001排气歧管Exhaust mani fold pipe14XN1008126000双头螺柱一排气歧管用Stud-exhaust mani fold pipe45XN1003116000双头螺柱Stud26Q40308弹簧垫片Spring washer27Q340B08螺母N

17、ut29Q1420835螺栓组合件Bolt modules610XN1008150000进气歧管上壳总成Upper cover assy-I niet mani fold pipe111Q1420628联接螺栓一进气歧管Connecting bolt-i nIet mani fold pipe812XN1008103000螺母一进气歧管Nut- inlet mani fold pipe213XN1003117000双头螺柱Stud214Q1420825螺栓组合件Bolt modules615XN1008140000入口管Ini et pipe116XN1014118000曲轴通风软管固定卡箍F

18、ix ing cli p-cran kshaft ven tilated hose117XN1014123000曲轴通风软管Ven tilated hose-cra nkshaft118XN1014117000通风管卡子Ven tilated hose cli p219Q1420816支承卡箍螺栓Bolt-hose cli p120入口管密封垫P ack in g-i niet pipe121Q142025螺栓组合件Bolt modules2序号NO.22232425部件代号CodeXN1008132000XN1008153000XN1008152000XN1008102000进气歧管下壳部件

19、名称NameLower cover- inlet mani fold pipe衬垫一进气歧管上、下壳Pad-upper and lower covers of ma ni fold套圈一进气歧管衬垫一进气歧管Gasket-i niet mani foldGad-i nIet mani fold数量Qty.1适用车型备注Vehicle model Remarks 1.3-05 冷却系统 COOLING SYSTEM、3 1 V罚*吃 12f 05 冷却系统 COOLING SYSTEM序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle modiel Remarks1

20、Q341C10螺母Nut-ge nerator fixing12Q40310垫圈Spring washer13XN1306110000调温器总成Thermostat1BQ1306020-30A0-4XN1306152000垫片一出水管Gasket-outlet pipe15XN1303104000旁通橡胶管Rubber hose-by pass16XN1000390000带垫圈螺栓Bolt with washer27XN1306160000双钢丝式环箍Steel cli p-water hose28XN1306153000内六角圆锥螺塞Inner hexa ngular coni cal bo

21、lt29XN1306144000垫片一调温器壳体Pad-thermostat hous ing110XN1306151001出水管Water outlet pipe111XN1306154000电线夹Harn ess cli p112Q1460830螺栓组合件Bolt modules213XN1303230000双钢管总成conn ector; htra nd cooler hose114Q1420816钢管固定螺栓bolt115Q1840812螺栓bolt116XN1303252000进水胶管hose rubber oil cooler tothermo ini117XN1303253000

22、回水胶管hose rubber oil cooler to thermo exh118XN1303150000支承双管卡箍cli p; hose, w/csd119XN1306160000双钢丝式环箍cli p; hose, w/csd820XN1303254000机冷器进水胶管hose; water, oil cooler; ini121XN1303255000机冷回水胶管hose; water, oil cooler; exh1212325r1.3-06 配气机构 VALVES AND VALVES TRAIN1718192022272629121513141110436261606 配气

23、机构 VALVES AND VALVES TRAIN序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks1XN1007107001挺柱Tappet82XN1007120000推杆Pushi ng rod83XN1007105000气门卡块Block collar-valve164XN1007106000上弹簧座Seat-upper spring85XN1007109000气门弹簧Sprin g-vavle86XN1003110000油封一气门导管Seal-valve guide pipe87XN1003108000气门弹簧垫圈Spring

24、 washer-valve88XN1007110000排气门Exhaust valve49XN1007101000进气门Inlet valve410XN1006103000平键Plain key-camshaft111XN1006104000止推片一凸轮轴Thrust-camshaft112Q1420816螺栓组合件Bolt modules213XN1006201000齿轮一凸轮轴Gear-camshaft114XN1006202000平垫圈一凸轮轴齿轮Plain washer-camshaft gear115XN1006203000八角头螺栓一凸轮轴齿轮Hexa ngular bolt-ca

25、mshaft gear116XN1006105000凸轮轴Camshaft117Q40110100HV垫圈Plain washer-rocker arm shaft418Q151C1060TF2螺栓Bolt-rocker bracket fixing119XN1007136001支架一摇臂轴Bracket-rocker arm shaft420XN1007142000垫圈一摇臂轴Washer-rocker arm shaft6序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks21XN1007144000摇臂轴支架双头螺栓Stud-roc

26、ker arm shaft bracket fixing122XN1007141000六角头螺栓一摇臂轴支架Hexa ngular bolt-rocker arm shaft bracket223XN1007133000六角螺母一调整螺钉Hexa ngular nu t-adjusti ng screw824XN1007132000调整螺钉一摇臂Adjusti ng screw-rocker arm825Q43119挡圈Collar-rocker arm226XN1007138001弹簧一摇臂Sprin g-rocker arm327XN1007134001摇臂轴Rocker arm shaf

27、t128XN1007135000碗形塞片PI ug-rocker end229XN1007140000摇臂Rocker arm837 235* -36/435 341.3-07 外设机构 PERIPHERAL DEVICE19FRONT033cP213220Z/0021241 X23心* “勺。熔r咎F40LH38391816S07 外设机构 PERIPHERAL DEVICE序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks1Q1420825螺栓组合件Bolt modules22Q40108垫圈一发电机调节板Washer-ge ner

28、ator adjusti ng p late13XN3701122000发电机安装调节板Adjust ing p late for fixing gen erator14Q341C10螺母Nut for fixing gen erator15Q40310垫圈Washer16XN3701110001交流发电机Alter nat ing curre nt gen erator17XN3701121000六角头螺栓Hexa ngular bolt-fix ing gen erator18Q341B12螺母Nut29Q40312垫圈Spring washer210Q40112垫圈P lain wash

29、er211XN3708110000起动机Starter assy112XN3708122000六角头螺栓Hexa ngular bolt-fix ing starter213XN3701411000螺母Nut414Q40310垫圈Washer415XN1001233000左支座Support seat-left116XN1001080000右橡胶支承板总成Support p late assy-right rubber cushi on117XN1001060000左橡胶支承板总成Support p late assy-left rubber cushi on118XN1001220000右支

30、座Support seat-right119XN1021120000左侧隔音盖板合件Cover assy-so und in sulate-left120Q1420825垫片Washer2序号NO.部件代号Code部件名称Name数量Qty.适用车型Vehicle mode备注l Remarks21XN1021130000右侧隔音盖板Cover assy-so und in sulate-right122XN1021132000右侧隔音海绵Spon ge-so und in sulate-right123XN3701123000发电机支架Gen erator bracket124XN37011

31、41000固定发电机支架螺栓Bolt-fix ing gen erator bracket225XN1000460000螺栓Bolt-ge nerator bracket126Q1420825螺栓Bolt327Q40108垫片Washer328Q40108螺栓组合件Bolt229XN1000430000螺栓Bolt130Q40110垫片Washer131XN1000470000螺栓Bolt132XN3510113000橡胶软管Rubber hose-pump to cyli nder block133XN3510105000卡子 真空泵回油管Clip-vacuum hose fix234XN1

32、000119000眼圈螺栓Bolt-joi nt oil pipe to block135XN3510530000眼圈螺栓密封垫P ack in g-bolt236XN3510600000机油管总成（不带隔热套）Pipe assy-oil feed137XN1000110000固定左支架螺栓Bolt-left bracket fixi ng138XN1004650000固定左支架螺栓Bolt-left bracket fixi ng139XN1000430000固定右支架螺栓Bolt-right bracket fixing440XN1000430000固定左支架螺栓Bolt-left bra

33、cket fixi ng241Q40110垫片Washer1序号NO.4243部件代号CodeQ40310Q40110垫片垫片部件名称NameWasherWasher数量Qty.2适用车型备注Vehicle model Remarks352308 风扇及正时齿轮机构 FAN AND TIMING GEAR DEVICE31413317Ml383239371413V121143315$322s M y16、274250、S230 08 风扇及正时齿轮机构 FAN AND TIMING GEAR DEVICE序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle mode

34、lRemarks1XN1308110010带硅油离合器风扇总成Fan assy with silic on oil clutch1BQ1304010-30A2XN1307152000六角螺母风扇用Hexa ngular nu t-fa n fixing43XN1307151000双头螺柱Stud-fa n p ulley44XN1308132000风扇皮带Fan belt1BQ130001-30AC5XN1308120001风扇皮带轮Belt pulley-fa n16Q1420855螺栓组合件Bolt modules-water pump57XN1307110001水泵总成Water pum

35、p assy18XN1307114000水泵密圭寸圈Pack ing-pump to cyli nder to block19XN1000330000带垫圈螺栓Bolt with washer410XN1002530000正时齿轮室盖罩总成Timing gear house cover assy111XN1002510000曲轴前油封Oil seal-cra nkshaft-fr ont112Q1420614螺栓组合件Bolt modules413XN1002512001正时齿轮室盖Cover-tim ing gear case114XN1002516000O型圈一齿轮室盖与齿轮 室O-rin

36、 g-case to cover115Q1420845螺栓组合件Bolt modules216XN1002502001正时齿轮室Timing gear case117XN1002504001垫片一齿轮室与缸体Pad-gear case to cyli nder118XN1002508000线缆夹Wire clip119Q1460612螺栓组合件Bolt modules-cli p to tim ing p ulley120XN1006207000眼圈螺栓Joi nt bolt1序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle modelRemarks21XN10

37、06208000密封垫一油管总成Pack ing-pipe assy122XN1006250000油管总成一润滑齿轮用Pipe assy-lubrica nt gear123Q1420855带垫圈螺栓Stud with washer-ma ni fold to cyli nder head224XN1006206000止推片一惰轮AThrust-idle gear A125XN1006240000惰轮A齿轮带衬套总成Gear with sleeve assy-idle gear A126XN1006205000轴一惰轮AShaft-idle gear127XN1006211000六角螺栓一惰轮

38、B轴Hexa ngular-idle gear shaft B128XN1006202000垫圈一一惰轮B用Washer-idle gear B129XN1006221000齿轮一惰轮BGear-idle gear B130XN1006209001轴一惰轮BShaft-idle gear B131XN1001246000右加强板Stren gthe n board-right132XN1001248000左加强板Stren gthe n board-left133XN1000460000带垫圈螺栓Bolt with washer334XN1002458001后盖板一一气缸体Plate-cyli

39、 nder-rear135XN1002459000六角头螺栓一后盖板Hexa ngular bolt-rear p late336Q1460825螺栓组合件Bolt modules237XN1011100010机油泵带集滤器总成Oil pump assy with stra iner138XN1011161000O型圈一输油管0-rin g-oil pipe139XN1011160001输油管总成一机油泵到气 缸体Pipe assy-oil pump to cyli nder140Q1420830螺栓组合件Bolt modules441XN1012111000机油滤密封垫Pack in g-o

40、il filter1序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle modelRemarks42XN1012120000机油滤清器总成（带机冷 器）Oil filter assy (with cooler)143XN1002525001橡胶垫一正时齿轮室盖罩Rubber p ad-ti ming gear case cover144XN1002522000盖板一正时齿轮室检查孔Cover-ti ming gear case check ing hole245XN1002523000垫片一正时齿轮室检查孔 盖Pack in g-ti ming gear case

41、 check ing hole cover246XN1003117000双头螺栓Stud-water pump247Q32008螺母Nut-water pump248Q1420860螺栓组合件Bolt module-cover to case149XN1000156000内六角圆柱螺钉Hexa ngular bolt-cover to case150XN1000320000带垫圈螺栓Bolt with washer-cover to case851XN1002454000圆柱销Straight pin252Q1420820螺栓组合件Bolt modules-cover to case61910

42、221923 09 缸体 CYLINDER BLOCKs38702711202117IB31321228a ；/636829343516 09 缸体 CYLINDER BLOCK序号部件代号部件名称数量适用车型备注NO.CodeNameQty.Vehicle modelRemarks1XN1002432000内六角圆锥螺塞Inner hexa ngular coni cal bolt22XN1002442000接头（真空泵一输油管）Conn ecter-vacuum bump to oil pipe13XN1009101000放油螺塞Plug-oil emit ing14XN1002434000垫圈一油道螺塞Pack in g-oil way plug15XN1002307000碗形塞片Cup-seali ng16XN1009021000后橡胶隔垫Rubber p ad-rear17XN1002456000六角头螺栓Hexa ngular