白酒企业标准.doc

_Q320922SWT003-20036 配料6.1 配料表季节醅别粮醅比粮曲比粮辅料比备注旺季（春前后）大渣1:4.5-5.521-23%18-19%6.5车醅二渣1:4.521-23%18-19%7车醅三渣1:5.516-18%14-15%4.5车醅回渣全醅20-23%10-12kg5-6车醅平季（秋冬）大渣1:4.5-522-24%19-21kg6.5车醅二渣4:4.522-24%19-21%6.5车醅三渣1:5.021-24kg15-16%4.5车醅回渣全醅23-25kg10-12kg5车醅淡季（夏前后）大渣1:4.5-522-24%21-22%6.5-7车醅二渣1:4.5-522-24%21-22%6.5-7车醅回渣全醅23-25kg20-26kg4.5-5车醅62 分渣配料。粮粉、量水、辅料、曲（酒母）、底醅是合理配料的五大基本材料。按老五甑工艺要求，五大基本材料按不同配方分大渣1、大渣2、小渣3、回缸、面糟、量化分开打推配料。注过夏保醅不打三渣。6.3 粮食在使用前12小时，分3个渣打推润料。在高温季节，润料在使用前1-2小时进行。6.4 稻壳按五甑醅不同比例使用（见配料表）。6.5 合理配用底醅的工艺原则：6.5.1 根据季节和气温调整底醅用量。6.5.2 根据上排醅发酵升温情况，合理调整底醅使用量。-5-Q320922SWT003-20038.2温度。 根据季节适当控制扬凉温度，见入池条件一览表。冬天凉渣加浆加曲拌匀后，要打堆后入池，以保证入池温度水份，收渣要准要快。8.3撒曲。 曲粉入渣前，渣醅温度不超过30-35，曲粉先与熟渣1：2拌匀后再撒曲，撒曲要匀，凉渣板上的醅要收两边清理，减少曲损失。8.4 在凉渣、加浆、加曲过程中注重卫生。 每轮凉渣前要打扫场地，必要时，第一甑凉渣前要用85以上的热水清洗扬凉设备灭菌处理。不允许生粮生料混进，场地经常保持卫生。9 入池、封池、发酵管理9.1 入池条件表：季 节渣 别温度淀粉%酸 度 水份备 注旺季（温和季节）大渣18-2315-190.8-1.555-57约9.5车醅二渣17-2315-190.8-1.655-58约10车醅三渣20-2214-161.0-1.656-586-7车醅回渣23-258-101.2-1.856-595-6车醅平季（低温季节）大渣21-2215-180.8-1.655-579.5车醅二渣20-2214-170.7-1.656-589.5车醅三渣23-259-111.0-1.757-586.5 车醅回渣26-2816-181.0-1.757-585.5车醅淡季（高温季节）大渣低室温16-181.2-1.855-589.5车醅二渣低室温16-17.51.2-2.255-5910车醅回渣平室温9-121.3-2.356-585-6车醅9.2 做好当日出池后的窖池保养维护工作。首先将准备入窖池打扫干净，去除池边霉变退化的窖泥（每年两次对老窖壁用人工窖池重泥涂，保证微生物和有益菌的栖息繁殖代谢），四周池壁和池底用酒尾或已酸菌液（用-10-Q320922SWT003-20039.8 严格抓好发酵工艺条件“四大变量”。即温度、淀粉、酸度和水份，这四大变量主要靠合理配料制约。本排掌握为下排调整提供依据。9.9 “低温入池，定温发酵”。是根据不同季节和天气变化制定的入池温度和配料酸度、水份和淀粉浓度，还要根据上排发酵情况合理科学的调整执行。确保符合发酵“前缓、中挺、后缓落”的温度管理原则。10、酒醅出池10.1 出池条件（1.2渣）表：季节水份淀粉酸度备 注旺季60-647-111.5-3.1温暖季节平季60-638-121.6-3.2天冷季节淡季61-658-131.6-3.6高温季节10.2 开窖。首先全部清除池头泥，放到泡池泥的地中，以备下次封池用。然后，清扫池头池口，取清上层面糟堆放到场地上，蒸馏后作丢糟处理，池头池口再清扫一次，铺上一块塑料布到池口通道边，备用停放斗车，依次取出回、小渣、二渣、大渣酒醅及双轮底酒醅，运置操作场地打推、严格按出池条件配料。10.3 出池要分层清，不同酒醅不能混出，否则会影响质量接酒。10.4 出池后的每层酒醅到场地打推要满足老五甑配料要求，以甑为单位，以车为计量。10.5 出池完毕后要打扫池窖，维护保养池窖。11 老五甑酿造操作工艺11.1 五醍浆酿造工艺路线按老五甑法：将窖中发酵完毕后的酒醅分成五甑蒸馏和配醅的传统操作方法。在正常情况下，窖内有四甑酒醅，即大渣、-12-江苏震洲五醍浆酒业有限公司zz/sc-7.5-0.1浓香型大曲酒酿造作业指导书第A版 0次修改第9页 共11页匀打堆，再进行撒曲，加曲量见入池条件表，加曲时不准开动鼓风机，加曲后，快速收好凉饭两边料，并打扫干净，然后开动打饭机拌料和人工抄料，温高季节摊凉拌曲料凉时间过长，造成米查醅僵便，打饭机总打饭遍数不超过4遍为宜，以免造成米查醅无骨力，粘腻。收米查入池要准、快、净。3.7.3 扬凉温度控制：见入池条件表：3.8 入池、封池3.8.1 入池条件：各项指标值为园排后指标，生池时可作参考，做3-6月时可适当调整。指标见下表：季 节米查 别温度淀粉%酸 度 水份旺季（温和季节）大米查18-2315-190.8-1.555-57二米查19-2315-190.8-1.655-58三米查20-2214-161.0-1.656-58回米查23-258-101.2-1.856-59平季（低温季节）大米查21-2215-180.8-1.655-57二米查20-2215-180.7-1.656-58三米查23-2514-171.0-1.757-58回米查26-289-111.0-1.757-58淡季（高温季节）大米查低室温16-181.2-1.855-58二米查低室温14-18.51.2-2.255-59回米查平室温9-121.3-2.356-583.8.2入池顺序：先入大米查、依次为二米查、三米查、回米查再增加适量的糟封顶。3.8.3 入池要求：每甑米查入池后均需摊平，前三甑米查入池时分别用熟稻壳间隔，回糟入池后用竹片间隔上层面糟。在三甑米查入池后，根据季节适宜踩窖。水份为阶梯水份。生池时适当放宽，见生产计划单。3.8.4 入池前和入池完毕后，均需保持池内池头清洁卫生、上池口不准有霉变，天天进行保养维护池。3.8.5 封池，在四甑料入池后，根据池头大小，适量幅盖面糟。拍紧拍平整理后，加8-10cm厚封池泥，封池泥用原封池泥70%和新泥30%加热水拌和，具有一定粘性，泥平整池季节水分淀粉酸度旺季60-647-111.5-3.1平季60-638-121.6-3.2淡季61-658-131.6-3.6季节水分淀粉酸度旺季60-647-111.5-3.1平季60-638-121.6-3.2淡季61-658-131.6-3.6季节水分淀粉酸度旺季60-647-111.5-3.1平季60-638-121.6-3.2淡季61-658-131.6-3.665度白酒标准量折算表原酒度小数 折算率原酒度00.10.20.30.40.50.60.70.80.9200.28370.28100.28660.28800.28950.29090.29240.29380.29530.2967210.29820.29970.30110.30260.30400.30550.30690.30840.30980.3113220.31270.31420.31570.31710.31860.32000.32150.32290.32440.3259230.32730.32880.33020.33170.33320.33460.33610.33760.33900.3405240.34200.34340.34490.34630.34780.34930.35070.35220.35370.3551250.35660.35810.35960.36100.36250.36400.36540.36690.36840.3698260.37130.37280.37430.37570.37720.37870.38020.38160.38310.3846270.38610.38750.38900.39050.39200.39340.39490.39640.39790.3994280.40080.40230.40380.40530.40680.40830.40970.41120.41270.4142290.41570.41720.41860.42010.42160.42310.42460.42610.42760.4291300.43060.43200.43350.43500.43650.43800.43950.44100.44250.4440310.44550.44700.44850.45000.45150.45300.45450.45600.45750.4590320.46050.46200.46350.46500.46650.46800.46950.47100.47250.4740330.47550.47700.47850.48000.48150.48310.48460.48610.48760.4891340.49060.49210.49360.49520.49670.49820.49970.50120.50270.5043350.50800.50730.50880.51040.51190.51340.51490.51640.51800.5195360.52100.52260.52410.52560.52710.52870.53020.53170.53330.5348370.53630.53790.53940.54090.54250.54400.54550.54710.54860.5502380.55170.55320.55480.55630.55790.55940.56100.56250.56410.5656390.56710.56870.57020.57180.57330.57490.57640.57800.57950.5811400.58270.58420.58580.58730.58890.59040.59200.59360.59510.5967410.59820.59980.60130.60290.60450.60610.60760.60920.61080.6132420.61390.61550.61710.61860.62020.62180.62340.62490.62650.6281430.62970.63120.63280.63440.63600.63760.63920.64070.64230.6439440.64550.64710.64870.65030.65190.65350.65500.65660.65820.6598450.66140.66300.66460.66620.66730.66940.67100.67260.67420.6758460.67740.67900.68060.68220.68390.68550.68710.68870.69030.6919470.69350.69510.69670.69840.70000.70160.70320.70480.70640.7081480.70970.71130.71290.71460.71620.71780.71940.72100.72270.7233490.72600.72760.72920.73090.73250.73410.73580.73740.73900.7407500.74230.74400.74560.74720.74890.75050.75220.75380.75550.7571510.75880.76040.76210.76370.76540.76700.76870.77040.77200.7737520.77530.77700.77860.78030.78200.78360.78530.78700.78860.7903530.79200.79360.79530.79700.79870.80030.80200.80370.80540.8070540.80870.81040.81210.81380.81540.81710.81880.82050.82220.8239550.82560.82730.82900.83060.83230.83400.83570.83740.83910.8408560.84250.84420.84590.84760.84930.85100.85270.85450.85620.8579570.85960.86130.86300.86470.86640.86810.86990.87160.87330.8750580.87670.87850.88020.88190.88360.88540.88710.88880.89050.8923590.89400.89570.89750.89920.90100.90270.90440.90620.90790.9096600.91140.91310.91490.91660.91840.92010.92190.92360.92540.9271610.92890.93060.93240.93410.93590.93770.93940.94120.94290.9447620.94650.94820.95000.95180.95360.95530.95710.95890.96070.9624630.96420.96600.96780.96950.97130.97310.97490.97670.97850.9803640.98200.98380.98560.98740.98920.99100.99280.99460.99640.9982651.00001.00181.00361.00541.00721.00901.01081.01271.01451.0163661.01811.01991.02171.02351.02541.02721.02901.03081.03261.0345671.03631.03811.03991.04181.04361.04541.04731.04911.05091.0528681.05461.05641.05831.06011.06201.06381.06571.06751.06941.0712691.07311.07491.07681.07861.08051.08271.08421.08611.08781.0898701.09171.09351.09541.09731.09921.10101.10291.10481.10661.1085711.11041.11231.11421.11601.11791.11981.12171.12361.12551.1274721.12921.13111.13301.13491.13681.13871.14061.14251.14441.1463731.14831.15021.15211.15401.15591.15781.15971.16171.16361.1655741.16741.16931.17131.17321.17511.17701.17901.18091.18291.1848751.18671.18871.19061.19261.19451.19641.19841.20031.20331.2042761.20621.20811.21001.21201.21401.21601.21791.21991.22181.2238771.22581.22771.22971.23171.23371.23571.23761.23961.24161.2436781.24561.24761.24961.25151.25351.25551.25751.25951.26151.2635791.26551.26751.26951.27151.27361.27561.27761.27961.28161.2836801.28571.28771.28971.29171.29381.29581.29781.29991.30191.3039811.30601.30801.31011.31211.31421.31621.31831.32031.32241.3244821.32651.32861.33061.33271.33481.33681.33891.34101.34301.3451831.34721.34931.35141.35341.35551.35761.35971.36181.36391.3660841.36811.37021.37321.37741.37651.37871.38081.38291.38511.3871851.38921.39141.39351.39561.39781.39991.40201.40421.40631.4085861.41061.41281.41491.41471.41921.42141.42361.42571.42791.4301871.43221.43441.43661.43881.44101.44321.44531.44751.44971.4519881.45411.45631.45851.46081.46301.46521.46741.46961.47181.