玉柴ECI故障码表.doc

故障代码故障名称中文解释11Intake cam / distributor position进气凸轮轴位置错误16Never crank synced at start启动以后曲轴不同步24Exhaust cam position排气凸轮轴位置错误91FP low voltage燃料压力传感器电压低92FP high voltage燃料压力传感器电压低107MAP low voltage进气压力电压低108MAP high pressure进气压力电压高111IAT higher than expected 1IAT（进气温度） 温度超过期望值1112IAT low voltageIAT（进气温度）电压低113IAT high voltageIAT（进气温度）电压高116ECT higher than expected 1ECT（冷却液温度） 温度超过期望值1117ECT / CHT low voltageECT（冷却液温度）/CHT（缸盖温度）传感器电压低118ECT / CHT high voltageECT（冷却液温度）/CHT（缸盖温度）传感器电压高121TPS1 lower than TPS2TPS（节气门位置传感器）1 低于TPS（节气门位置传感器）2122TPS1 low voltageTPS1（节气门位置传感器）电压低123TPS1 high voltageTPS1（节气门位置传感器）电压高127IAT higher than expected 2IAT（进气温度）温度超过期望值2129BP low pressure环境压力电压低134EGO open / lazy pre-cat 1催化器前氧传感器1开路或怠工140EGO open / lazy post-cat 1催化后氧传感器1开路或怠工154EGO open / lazy pre-cat 2/post-cat 1催化器前氧传感器2或催化后氧传感器1开路或怠工160EGO open / lazy post-cat 2催化器后氧传感器2开路或怠工171AL high gasoline bank1汽油自适应高172AL low gasoline bank1汽油自适应低174AL high gasoline bank2汽油自适应高175AL low gasoline bank2汽油自适应低182FT gasoline low voltage汽油温度电压低183FT gasoline high voltage汽油温度电压高187FT gaseous fuel low voltage气体燃料温度电压低188FT gaseous fuel high voltage气体燃料温度电压高217ECT higher than expected 2ECT（冷却液温度）温度超过期望值2219Max govern speed override发动机转速超最高调速转速221TPS1 higher than TPS2TPS（节气门位置传感器）1 高于TPS（节气门位置传感器）2222TPS2 low voltageTPS2（节气门位置传感器）电压低223TPS2 high voltageTPS2（节气门位置传感器）电压高234TIP control overboostTIP（节气门前压力传感器）控制超过目标压力236TIP active节气门前压力传感器忙碌237TIP low voltage节气门前压力传感器电压低238TIP high voltage节气门前压力传感器电压高261Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路262Injector Coil Shorted喷射线圈短路264Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路265Injector Coil Shorted喷射线圈短路267Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路268Injector Coil Shorted喷射线圈短路270Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路271Injector Coil Shorted喷射线圈短路273Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路274Injector Coil Shorted喷射线圈短路276Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路277Injector Coil Shorted喷射线圈短路279Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路280Injector Coil Shorted喷射线圈短路282Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路283Injector Coil Shorted喷射线圈短路285Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路286Injector Coil Shorted喷射线圈短路288Injector Loop Open or Low-Side Short to Ground喷射回路开路或低端驱动端对地短路289Injector Coil Shorted喷射线圈短路299TIP control underboostTIP（节气门前压力传感器）控制低于目标压力301Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏302Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏303Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏304Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏305Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏306Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏307Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏308Emissions/catalyst damaging misfire失火导致排放恶化或催化器损坏326Knock1/2 excessive signal爆震传感器1/2传感器信号太强327Knock1/2 sensor open爆震传感器1/2传感器开路331Knock1/2 excessive signal爆震传感器1/2传感器信号太强332Knock1/2 sensor open爆震传感器1/2传感器开路336Crank sync noise曲轴传感器同步干扰337Crank loss曲轴传感器信号丢失341Cam sync noise凸轮轴传感器同步干扰342Cam loss凸轮轴传感器信号丢失359Fuel run-out longer than expected燃料逃逸出发动机比期望值长420Gasoline cat monitor汽油催化器监视430Gasoline cat monitor汽油催化器监视502Roadspeed lossRoadspeed 信号丢失508IAC ground shortIAC（怠速空气控制）传感器对地短路509IAC coil open/shortIAC（怠速空气控制）传感器线圈开路或短路521Oil pressure high (sender type)机油压力高（压力感应塞故障模式）522Oil pressure sender low voltage机油压力感应塞电压超低523Oil pressure sender high voltage机油压力感应塞电压超高524Oil pressure low机油压力低524Oil pressure low (sender type)机油压力低（压力感应塞故障模式）562Voltage low电池电压低563Voltage high电池电压高601Flash checksum invalid闪存检查非法604RAM failure随机存储器失败606COP failure微处理器COP部分 故障615Start relay coil open启动继电器线圈开路616Start relay control ground short启动继电器对地短路617Start relay coil short to power启动继电器对电源短路627Fpump relay coil open燃料泵继电器线圈开路628FPump motor loop open or high-side shorted to ground燃料泵电机回路开路或高端驱动端对地短路628FPump relay control ground short燃料泵继电器对地短路629FPump motor high-side shorted to power燃料泵电机高端驱动端对电源短路629Fpump relay coil short to power燃料泵继电器线圈对电源短路6425VE1 low voltage5V输出1（19号针脚）电压低6435VE1 high voltage5V输出1（19号针脚）电压高650MIL open故障指示灯开路6525VE2 low voltage5V输出2（49号针脚）电压高6535VE2 high voltage5V输出2（49号针脚）电压低685Relay coil open主电源继电器线圈开路686Relay control ground short主电源继电器控制对地短路687Relay coil short to power主电源继电器线圈对电源短路1111Fuel rev limit燃料转速限制1112Spark rev limit点火转速限制1121FPP1/2 simultaneous voltages out of range (redundancy lost)FPP（油门位置传感器)1/2 电压同时超出范围（超静电性丢失）1122FPP1/2 do not match each other or the IVS (redundancy lost)FPP（油门位置传感器)1/2互不匹配或与IVS（怠速开关）不匹配（超静电性丢失）1131WGP high voltage废气旁通控制阀压力电压高1132WGP low voltage废气旁通控制阀压力电压低1151CL high LPGLPG闭环修正量高1152CL low LPGLPG闭环修正量低1153CL high NGNG闭环修正量高1154CL low NGNG闭环修正量低1155CL high gasoline bank1汽油闭环修正量高1156CL low gasoline bank1汽油闭环修正量低1157CL high gasoline bank2汽油闭环修正量高1158CL low gasoline bank2汽油闭环修正量低1161AL high LPGLPG 自适应高1162AL low LPGLPG 自适应低1163AL high NGNG自适应高1164AL low NGNG自适应低1165LPG cat monitorLPG催化器监视1166NG cat monitorNG催化器监视1171MegaJector delivery pressure higher than expected电控调压器传输压力高于期望值1172MegaJector delivery pressure lower than expected电控调压器传输压力低于期望值1173MegaJector comm lost电控调压器通讯丢失1174MegaJector voltage supply high电控调压器电压超高1175MegaJector voltage supply low电控调压器电压超低1176MegaJector internal actuator fault detection检测到电控调压器内部执行器故障1177MegaJector internal circuitry fault detection检测到电控调压器内部电路故障1178MegaJector internal comm fault detection检测到电控调压器内部通讯故障1182Fuel impurity level high燃料杂质过多1183MegaJector autozero / lockoff failed电控调压器归零/切断失效1311Misfire detected检测到失火1312Misfire detected检测到失火1313Misfire detected检测到失火1314Misfire detected检测到失火1315Misfire detected检测到失火1316Misfire detected检测到失火1317Misfire detected检测到失火1318Misfire detected检测到失火1411EMWT1/2 high voltageEMWT（排气岐管水温）传感器1/2 电压高1412EMWT1/2 high voltageEMWT（排气岐管水温）传感器1/2 电压高1413EMWT1/2 low voltageEMWT（排气岐管水温）传感器1/2 电压低1414EMWT1/2 low voltageEMWT（排气岐管水温）传感器1/2 电压低1415EMWT1/2 higher than expected level 1EMWT（排气岐管水温）传感器1/2 电压高于期望值1级1416EMWT1/2 higher than expected level 1EMWT（排气岐管水温）传感器1/2 电压高于期望值1级1417EMWT1/2 higher than expected level 2EMWT（排气岐管水温）传感器1/2 电压高于期望值2级1418EMWT1/2 higher than expected level 2EMWT（排气岐管水温）传感器1/2 电压高于期望值2级1421ERWT1/2 high voltageERWT（排气岐管出口温度）传感器1/2 电压高1422ERWT1/2 high voltageERWT（排气岐管出口温度）传感器1/2 电压高1423ERWT1/2 low voltageERWT（排气岐管出口温度）传感器1/2 电压低1424ERWT1/2 low voltageERWT（排气岐管出口温度）传感器1/2 电压低1425ERWT1/2 higher than expected level 1ERWT（排气岐管出口温度）传感器1/2 电压高于期望值1级1426ERWT1/2 higher than expected level 1ERWT（排气岐管出口温度）传感器1/2 电压高于期望值1级1427ERWT1/2 higher than expected level 2ERWT（排气岐管出口温度）传感器1/2 电压高于期望值2级1428ERWT1/2 higher than expected level 2ERWT（排气岐管出口温度）传感器1/2 电压高于期望值2级1511AUX analog PU1 high辅助模拟量PU1（38号针脚）电压高1512AUX analog PU1 low辅助模拟量PU1（38号针脚）电压低1513AUX analog PU2 high辅助模拟量PU2（39号针脚）电压高1514AUX analog PU2 low辅助模拟量PU2（39号针脚）电压低1515AUX analog PD1 high辅助模拟量PD1（12号针脚）电压高1516AUX analog PD1 low辅助模拟量PD1（12号针脚）电压低1517AUX analog PU3 high辅助模拟量PU3电压高1518AUX analog PU3 low辅助模拟量PU3电压低1521CHT higher than expected 1CHT（缸盖温度）超过期望值11522CHT higher than expected 2CHT（缸盖温度）超过期望值21531IVS/Brake/Trans-Park interlock failureIVS/Brake/Trans-Park 互锁功能失败1541AUX analog PUD1 high辅助模拟量PUD1（46号针脚）电压高1542AUX analog PUD1 low辅助模拟量PUD1（46号针脚）电压低1543AUX analog PUD2 high辅助模拟量PUD2电压高1544AUX analog PUD2 low辅助模拟量PUD2电压低1545AUX analog PUD3 high辅助模拟量PUD3电压高1546AUX analog PUD3 low辅助模拟量PUD3电压低1547AUX analog PUD4 high辅助模拟量PUD4电压高1548AUX analog PUD4 low辅助模拟量PUD4电压低1551AUX DIG1 high辅助数字量DIG1 电压高1552AUX DIG1 low辅助数字量DIG1电压低1553AUX DIG2 high辅助数字量DIG2电压高1554AUX DIG2 low辅助数字量DIG2电源低1555AUX DIG3 high辅助数字量DIG3电压高1556AUX DIG3 low辅助数字量DIG3电压低1561AUX analog PD2 high辅助模拟量PD2电压高1562AUX analog PD2 low辅助模拟量PD2电压低1563AUX analog PD3 high辅助模拟量PD3电压高1564AUX analog PD3 low辅助模拟量PD3电压低16115VE1/2 simultaneous out-of-range5V输出1（19号针脚）/2（49号针脚）同时超出范围1612RTI 1 loss微处理器故障-RTI1 丢失1613RTI 2 loss微处理器故障-RTI2 丢失1614RTI 3 loss微处理器故障-RTI3 丢失1615A/D loss微处理器故障-数模转换丢失1616Invalid interrupt微处理器故障-非法干扰1621Rx InactiveRx 不起作用1622Rx NoiseRx 干扰1623Invalid Packet Format存储器格式无效1624Shutdown Request关机请求1625Shutdown Request关机请求1626CAN Tx failureCAN Tx 失败（电控调压器的CAN通讯有故障）1627CAN Rx failureCAN Rx 失败（电控调压器的CAN通讯有故障）1628CAN address conflict failureCAN 通讯地址冲突1629J1939 TSC1 message receipt lostJ1939 TSC1（扭矩/速度控制）消息接收失败1630J1939 ETC message receipt lostJ1939 ETC（电子节气门控制）消息接收失败1631PWM1-Gauge1 open / ground shortPWM1 开路或者对地短路1632PWM1-Gauge1 short to powerPWM1 对电源短路1633PWM2-Gauge2 open / ground shortPWM2 开路或者对地短路1634PWM2-Gauge2 short to powerPWM2 对电源短路1635PWM3-Gauge3 open / ground shortPWM3 开路或者对地短路1636PWM3-Gauge3 short to powerPWM3 对电源短路1637PWM4 open / ground shortPWM4 开路或者对地短路1638PWM4 short to powerPWM4 对电源短路1639PWM5 open / ground shortPWM5 开路或对地短路1640PWM5 short to powerPWM5 对电源短路1641Buzzer control ground short蜂鸣器控制端对地短路1642Buzzer open蜂鸣器开路1643Buzzer control short to power蜂鸣器控制对电源短路1644MIL control ground short故障指示灯控制端对地短路1645MIL control short to power故障指示灯对电源短路1651J1939 ETC message loss while in-gear挂档时J1939 ETC 消息丢失1661PWM6 open / ground shortPWM6 开路或对地短路1662PWM6 short to powerPWM6 对电源短路1663PWM7 open / ground shortPWM7 开路或对地短路1664PWM7 short to powerPWM7 对电源短路1665PWM8 open / ground shortPWM8 开路或对地短路1666PWM8 short to powerPWM8 对电源短路1669PWM9 open / ground shortPWM9 开路或对地短路1670PWM9 short to powerPWM9 对电源短路2111Unable to reach lower TPS实际节气门位置高于命令值2112Unable to reach higher TPS实际节气门位置低于命令值2115FPP1 higher than IVS limitFPP1电压高于IVS限制2116FPP2 higher than IVS limitFPP2电压高于IVS限制2120FPP1 invalid voltage and FPP2 disagrees with IVS (redundancy lost)FPP1 电压非法并且FPP2和IVS不一致2121FPP1 lower than FPP2FPP1低于FPP22122FPP1 high voltageFPP1电压高2123FPP1 low voltageFPP1电压低2125FPP2 invalid voltage and FPP1 disagrees with IVS (redundancy lost)FPP2电压非法并且FPP1和IVS不一致2126FPP1 higher than FPP2FPP1 高于FPP22127FPP2 low voltageFPP2电压低2128FPP2 high voltageFPP2电压高2130IVS stuck at-idle, FPP1/2 matchIVS 保持怠速，FPP1/2相匹配2131IVS stuck off-idle, FPP1/2 matchIVS保持非怠速，FPP1/2相匹配2135TPS1/2 simultaneous voltages out of rangeFPP1/2 电压同时超出范围2139FPP1 lower than IVS limitFPP1电压低于IVS限制2140FPP2 lower than IVS limitFPP2电压低于IVS限制2229BP high pressure环境压力电压高2300Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2301Primary Coil Shorted主线圈短路2303Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2304Primary Coil Shorted主线圈短路2306Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2307Primary Coil Shorted主线圈短路2309Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2310Primary Coil Shorted主线圈短路2312Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2313Primary Coil Shorted主线圈短路2315Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2316Primary Coil Shorted主线圈短路2318Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2319Primary Coil Shorted主线圈短路2321Primary Loop Open or Low-Side Short to Ground点火线圈主回路开路或低端驱动端对地短路2322Primary Coil Shorted主线圈短路2324Primary Loo