外墙面砂胶砖施工方案.doc

We will continue to improve the companys internal control system, and steady improvement in ability to manage and control, optimize business processes, to ensure smooth processes, responsibilities in place; to further strengthen internal controls, play a control post independent oversight role of evaluation complying with third-party responsibility; to actively make use of internal audit tools detect potential management, streamline, standardize related transactions, strengthening operations in accordance with law. Deepening the information management to ensure full communication zero resistance. To constantly perfect ERP, and BFS+, and PI, and MIS, and SCM, information system based construction, full integration information system, achieved information resources shared; to expand Portal system application of breadth and depth, play information system on enterprise of Assistant role; to perfect daily run maintenance operation of records, promote problem reasons analysis and system handover; to strengthening BFS+, and ERP, and SCM, technology application of training, improve employees application information system of capacity and level. Humanistic care to ensure zero. To strengthening Humanities care, continues to foster company wind clear, and gas are, and heart Shun of culture atmosphere; strengthening love helped trapped, care difficult employees; carried out style activities, rich employees life; strengthening health and labour protection, organization career health medical, control career against; continues to implementation psychological warning prevention system, training employees health of character, and stable of mood and enterprising of attitude, created friendly fraternity of Humanities environment. To strengthen risk management, ensure that the business of zero risk. To strengthened business plans management, will business business plans cover to all level, ensure the business can control in control; to close concern financial, and coal electric linkage, and energy-saving scheduling, national policy trends, strengthening track, active should; to implementation State-owned assets method, further specification business financial management; to perfect risk tube control system, achieved risk recognition, and measure, and assessment, and report, and control feedback of closed ring management, improve risk prevention capacity. To further standardize trading, and strive to achieve according to law, standardize and fair. Innovation of performance management, to ensure that potential employees zero fly. To strengthen performance management, process control, enhance employee evaluation and levels of effective communication to improve performance management. To further quantify and refine employee standards . Work, full play party, and branch, and members in five type Enterprise construction in the of core role, and fighting fortress role and pioneer model role; to continues to strengthening four good leadership construction, full play levels cadres in enterprise development in the同科汇丰国际二期D1、2、16D18#楼工程外墙面砂胶砖施工方案编制人: 审批人： 江苏省江天建设工程有限公司同科工程项目部2012年10月第一章 工程概况同科汇丰国际D1、2、16D18#楼工程；工程建设地点：巨龙路东、苍梧路北；属于框架结构；地上28层；地下2层；建筑高度：89.7m；标准层层高：2.9m。本工程由江苏两淮盐化有限公司投资建设，苏州六度建筑设计有限公司设计，连云港市永发监理有限公司监理，江苏省江天建设工程有限公司组织施工。根据设计院及建设单位要求（见监理工程师通知单（工程变更类）B25-转发的设计变更及联系单）：底部架空层（3.6m标高以下）为干挂花岗岩造型；住宅部分的一、二、三层（标高3.6至12.3）外墙面为砂胶砖（仿花岗岩颜色见效果图）；住宅四层（12.3m）以上外墙面为米黄色砂胶砖（仿面砖尺寸：400*160mm，缝宽15mm、仿花岗岩尺寸： 600mm见方，）。仿面砖按照标高41.3m线条及其上方北侧做出的外墙仿面砖样板颜色进行施工。室外落水管色彩同墙面。第二章 施工计划安排一、D区五幢楼的外墙面砂胶砖计划在2012年12月底完成（如因气候条件等不可抗力影响顺延）。由于天气温度逐渐下降，在可能的情况下，D2、16#楼前期应尽可能先施工背立面，朝阳面可在气温较低的情况下施工。由于受拆除脚手架的影响，D1、17、18#楼其总体施工顺序原则上为由上而下依次进行。二、D区五幢楼外墙面砂胶砖的材料必须统一厂家，统一品牌，确保工程质量。第三章 施工工序及施工方法一、施工流程砂胶砖具有一定的装饰性和艺术性，主要用于高层建筑、别墅等高档装修。砂胶砖形成的漆膜具有一定的柔性，能弥补墙体细裂纹，并且颜色持久亮丽。其施工流程如下：墙面基层清理干净刮外墙专用防水腻子滚涂黑底漆两遍弹分格线贴分格胶带批刮砂胶砖料揭条并修正面层喷涂罩面剂二、施工准备1、主要材料：1）专用防水腻子， 2遍，参考配比：水：粉料1: 2，参考用量：1-2 kg/m22）砂胶砖涂料，一遍，参考用量：34kg/3）罩面漆，参考用量：812m2/L除以上配套材料外，尚需美纹分格纸及基层局部修补用的修补砂浆等。2、主要机具：简便水平器、线包、毛滚、刷子、开刀、角磨机、粗细沙纸、钢丝刷、抹子等。三、作业条件：1. 门窗按设计要求安装好，并堵抹洞口四周的缝隙。2、墙面基层处理完毕，并符合设计工艺要求，按抹灰面标准验收，满足施工条件，完成雨水管卡、设备洞口管道的安装，并将洞口四周用水泥砂浆抹平，所有的墙面需晾干。3、活动吊蓝，要符合国家安全规范要求。4、所有的成品门窗要提前保护四、操作工艺：1、基面处理：在基层处理之前，墙体需要一定时间的养护，一般新水泥墙面冬天的养护时间为28天，夏天的养护时间为14天。养护到基层的pH值小于10，含水率小于10%后再进行基面处理。基层处理前应彻底清除疏松、起皮、空鼓、粉化的基层，然后，去除灰尘、油污等污染物。2、批刮外墙专用防水腻子，在外墙外保温施工完毕后的墙面上批刮外墙专用防水腻子，厚度约1-1.5mm。3、 滚涂黑色底漆两遍，横竖交叉滚涂，不漏涂。4、弹出分隔线、按分隔线贴胶带条 滚涂黑色底漆两遍后，用色线根据砖面设计要求，弹出分割线条。然后用厚度约1.2mm的胶带条，按照横墨线下边和竖墨线的左边贴出分割线线条，整条的贴，然后用裁纸刀切割不需要分割线部分和横竖重叠部分胶带。在贴分格线条时必须考虑砖块分格尺寸的美观，在美观的前提下，可适当调整分格尺寸。5、批刮砂胶砖涂料用批刀按照胶带厚度批刮砂胶砖涂料，要求批刮密实，批刮收刀的方向一致。6、揭分割线条胶带批刮砂胶砖涂料后约10-15分钟（表面稍干后），揭掉胶缝胶带，此时砖与缝即成型。 7、喷涂罩面漆：注意待砂胶砖涂料完全干透后（一般晴天至少保持3天），方可喷涂罩面漆，施工时注意保持粘度，气压，喷口大小一致，注意预防流挂现象。五、施工注意事项施工环境：保证环境温度应大于5，相对湿度小于70%，无大风的天气下施工，雨天或者即将下雨的天气也不得施工，施工时多关注一下天气预报。六、储运要求1储存条件：涂料在通风、干燥、温度在535的环境下储存。2保质期：产品有效储存期为一年。3. 运输条件：运输按非危险品运输规则办理。第四章 质量保证措施一、材料：1、为保证五幢楼色质一致，必须使用同一品牌的材料。2、所使用的材料进场后必须经检测合格后方可用于本工程。3、材料配比、色质严格按送建设单位样板施工。二、施工：1、严格按工艺要求的施工顺序进行施工。2、每道工序必须经监理签字确认合格后方可进行下道工序。3、气温低于5度及雨天时，不得进行施工。4、各分格必须先排砖后弹线分格，确保立面美观。门急诊医技楼外脚手架采用悬挑式单排脚手架，基础回填后改为落地式双排脚手架，脚手架搭设高度为23m。病房医技楼外脚手架采用悬挑双排脚手架，分四次悬挑of backbone backbone role; to full strengthening members youth work, full play youth employees in company development in the of force role; to improve independent Commission against corruption work level, strengthening on enterprise business key link of effectiveness monitored. , And maintain stability. To further strengthen publicity and education, improve the overall legal system. We must strengthen safety management, establish and improve the education, supervision, and evaluation as one of the traffic safety management mechanism. To conscientiously sum up the Olympic security controls, promoting integrated management to a higher level, higher standards, a higher level of development. Employees, today is lunar calendar on December 24, the ox Bell is about to ring, at this time of