混凝土加固施工方案_第1页
混凝土加固施工方案_第2页
混凝土加固施工方案_第3页
混凝土加固施工方案_第4页
混凝土加固施工方案_第5页
全文预览已结束

下载本文档

版权说明:本文档由用户提供并上传,收益归属内容提供方,若内容存在侵权,请进行举报或认领

文档简介

is one of the practical form of values. The so-called values refers to the objective things are of no value and the value of fundamental perspective. Different values, peoples behaviour, attitudes, ways are different. People-oriented focus on human value and reality, we need the broadest masses as values. Adhere to people-oriented values, is to make the economy more development, improve democracy, cultural prosperity, and live a happier; is deeply concerned that human development and human values, development of social and human development of rational unified, insisted in the material civilization, political civilization and spiritual civilization in the overall advancement of Socialist civilization to a higher level. Also want to see that persons value is not only meet your needs, also is to meet the needs of others and the community. Adhere to people-oriented, to strongly advocate every community member, serve others, beneficial to the community of people. The so-called Outlook, attitude is on the record, including who, how to create a record of achievements, how to evaluate performance, and so on. What values, what kind of Outlook. Adhere to people-oriented Outlook, is on the premise of respecting the interests and power of people, creating a popular, warm hearts, steady heart performance, creating serve for one officer, the benefit of achievements, and overall construction of well-off society and promoting the all-round development of peoples performance. Achievement evaluation in both economic accomplishments, take another look at the effectiveness of social progress; changes in both urban and rural change; both hard environment to strengthen and take another look at the soft environment improvement momentum of development at present, depending on the potential for sustainable development. Leave people to talk about values are worthless and leave people to talk about Outlook is not what the performance. 4. people responded to the starting point of the question, and replied to questions point. Man is the sum of social relationships. We cannot leave the chichuanyongdu, housing, tourism and entertainment, entertaining, and even certain political, economic, cultural and social environment, and so on. Due to human needs, all walks of life will come into being. People create for their survival, and continue enjoying the results of the construction. Colorful in the transformation of the people of the world, community vitality in the creation of man. Therefore, any work we do, the starting point is human, what are people. Us speed up development, the core of which is to meet the needs of people, including survival needs, emotional needs and self-actualization needs. It should be noted that people are not machines, not the slave of an object, not to be controlled. People have their own personality, has its own personality, has its own dignity. Person in need of care, you need to understand, need to meet. It is said that in the agricultural society, people plant; in industrial society, man is an animal; the information society, return第一章 加固施工方案第一节 加固施工原则一、 剪力墙新开洞口加固采用粘贴钢板方法加固;板加固采用板底加型钢方法进行加固;柱加固采取外粘型钢及粘贴钢板加固;局部柱加大截面。二、 自上而下、由内而外原则;先堵后扒原则;先加固后加荷原则;只能加强、不能削弱原则。三、 在施工和安全上,要求施工中要充分考虑抗震要求,确保使用年限,在施工中安全第一,工期要服从安全。四、 在墙体支护上,主体完成后拆除,确保施工期间墙体稳定。第二节 加固方案一、 钢筋植筋工程1. 植筋施工工艺钻孔定位钻 孔清 孔钢筋下料固化养护注 胶钢筋除锈植 筋检查验收植筋工程施工流程图A、钻孔定位放线:根据设计图纸,在需要植筋的部位进行定位放线(以甲方提供基准线为准)。图纸所标注的原结构的尺寸大小与实际值可能有一定的误差,因此对于添加构件的定位必须结合原有结构的实际尺寸进行综合的定位放线,首先确定构件的轮廓线,然后再确定植筋钻孔的位置,并由总包测量人员检测是否准确。B、打磨:对确定要植筋部位的梁进行打磨,打磨厚度35mm,除去结构面浮土。C、钻孔:使用电锤在标定的位置钻孔,遇到钢筋时,可调整钻孔位置,合理避开钢筋,孔深必须达到设计图纸或技术交底要求。D、清孔:钻孔完成后,将孔周围灰尘清理干净,用毛刷将孔内清理干净。再用棉丝沾丙酮清刷孔洞内壁,使孔内达到清洁干燥;如果孔内较潮湿,必须用热风机对孔内进行干燥处理。清孔处理完毕后,用干净的棉纱将孔洞严密封堵,以防有灰尘和异物落入。E、钢筋除锈:锚固用的钢筋必须严格按照设计要求的型号、规格选用,根据锚固长度及部位做好除锈处理,除锈长度大于埋设长度5厘米左右。用钢丝刷将除锈清理长度范围内的钢筋表面打磨出金属光泽。要求除锈均匀干净,不得有漏刷部位。将所有处理完的钢筋分类码放整齐,并按类别标示清楚。F、注胶必须饱满,植筋注胶必须饱满,胶层内无气泡和空鼓;不能偷工减料,减少用胶量。G、植筋:结构胶灌注法:将粘结剂灌入孔中至孔深三分之二左右,同时将钢筋锚固部分一面旋转一面插入孔中,将孔中空气排出,放置钢筋时要沿一个方向,稍加礅实即可固定钢筋,植入困难时应及时用锤敲击,对较长筋应做好预绑,尽量不让歪斜;钢筋植入后以少量胶体溢出孔口为宜。H、固化养护:植好的钢筋,应做保护,不能让其松动,以免影响其粘结强度,在未固化前一定要避免与水及油类接触, 固化养护(室外温度)时间一般为24-36小时,24-36小时后经监理工程师检验合格后即可绑扎钢筋。在固化期间,不得对钢筋有任何扰动直至达到强度,派专人进行看护或做防护栏进行保护。I、各工序完工后报请有关人员检查验收,验收合格并报隐蔽工程检查记录后方可进入下道工序施工。2. 施工质量控制点及质量保障措施A、钻孔开洞:根据设计图纸或甲方要求在需开洞部位弹线,要求位置正确,尺寸偏差不超过5mm。放线完毕后报请专业工程师检验,合格后报请监理工程师检验,签字确认后方可进行下一步施工。水钻切割时应做好相应部位的安全防护,较大面积的楼板拆除应将需拆除部分破碎成容易半动的块体由人工运至楼板上然后进行清理。切割下来的混凝土渣土应派专人及时清理,运至甲方指定地点,保持施工现场的整洁有序。B、植筋工程:钢筋加工一定满足长度要求,钢筋表面应无锈斑,植入前需将钢筋锚固端打磨干净。钻孔深度应满足钢筋锚固深度,孔径应大于需植入钢筋直径1mm2mm,孔洞必须用高压气泵清理干净,并保持孔洞清洁、干燥。植筋前应用丙酮擦拭钢筋及钢筋植入孔。植筋胶一次拌和不宜过多,胶粘剂拌和时应用搅拌器沿同一方向搅拌,必须保证甲乙胶搅拌均匀。钢筋植入后应注意养护(不可扰动),养护时间一般为24小时以上,如环境温度较低应延长养护时间,增加保温措施。二、 粘贴钢板 1、加固材料选择:(1) 钢板均采用Q345。(2) 粘贴材料选用建筑结构胶。2、工艺流程:被粘混凝土和钢板表面处理裁料、放样、焊接放样钻孔粘结剂配制涂敷胶粘贴钢板固定加压固化检验防腐处理。3、施工方案及顺序:(1) 对预贴表面的处理:用磨光机装金刚石磨片除去23厚表面层,直至完全露出新面,梁体不直或不平,要进行打凿或找平,并用无油压缩空气吹除粉尘或清水冲洗干净之后,再脱脂棉沾丙酮擦拭干净。(2) 对预贴钢板表面的处理:钢板粘接面,须进行除锈和粗糙处理,采用砂轮机打磨,直至出现金属光泽,打磨粗糙度越大越好,打磨纹路应与钢板受力方向垂直,其后用脱脂沾丙酮擦拭干净。(3) 裁料、放样及焊接:按图纸设计要求一次性进行裁剪。由于现场梁体部分不平直,须放样进行裁剪,根据结构胶的特性及设计要求,粘贴前应进行焊接完成,且做到满焊。(4) 放样钻孔:上述工作完成之后,再把预粘钢板放样,保证达到要求时进行钢板钻孔,混凝土梁体钻孔,钻孔时采用无损冲击电钻钻孔,钻孔深度及钻孔规格按有关设计要求。待钻孔完成后再次放样预贴,间定锚栓。 (5) 粘结剂配制:本施工采用建筑结构胶,按甲、乙重量比配制好后,用搅拌器搅拌,待无单组分条块,色泽均匀时即可使用。(6) 涂胶:将调配好的胶用抹刀或腻刀同时涂抹在已处理好的钢板表面上,厚度13,中间厚边缘薄,然后将钢板贴于预定位置。(7) 固定加压:钢板贴于梁面上时,应及时拧紧螺栓,适当加压,以使胶液刚刚从钢板边挤出为度。(8) U型箍粘贴方法同钢板一样。(9) 固化:结构胶在现时温度下40分钟初凝,3天后可受力使用。(10) 检验:粘贴钢板后,可用小锤轻敲钢板,如无空洞声,表示已贴密实,钢件与混凝土贴合面应达90%以上。(11) 防腐处理:加固后,钢板表面涂一层改性环氧,以防止钢板腐蚀生锈。Now, we are in a new historical stage of all-round construction of a well-off society. In perform duties, and carried out work of process in the, we to put people as a guide principles, and a test standard, efforts from masses most hope do of things do up, from masses most care of hot problem grabbed, from masses most not satisfaction of place modified up, not make nominal of formalism, not do grandstanding of cosmetic, to seeking of style, help masses share, is people benefit. (C) the investee people is not only an idea, it is a job requirement. Philosophy through to the people-oriented thought in the work of the Office, must be clear work objectives. Party Office in the city this year remains: Advanced civil strife, local brand. The County (City) Party Committee offices and units directly under the Office to hold high the banner of first to excellence, people-oriented requirements, strengthen the construction and management of the Office towards the work a higher level. Investee 1. political participation based on conspiracy to adhere to people-oriented, will be around to promote coordinationDevelopment events, great searchings. The 16 session of the partys scientific Outlook on development, is the new Central collective leadership to the development of connotation, development essentials, further deepen the essence of development and innovation, is our partys ruling idea a leap. At present, establishing and implementing the scientific concept of development has become the partys important work. As the Office of party Committee, working party should service center, initiative to claim leadership of the decision, the current focus is to focus on promoting comprehensive, coordinated and sustainable development with more suggestions, do more research, summarized the typical. One is drafted to raise the level of your presentation. Your presentation is the main Office of products, is the basic carrier staff service, is important to measure service levels. The quality of your presentation, mainly depends on how much we drafted a document recognized by the leadership, how many are listening to the people in favour of the report, how many paid dividends in the practical work. Improve presentation drafting level, requirements we accurate

温馨提示

  • 1. 本站所有资源如无特殊说明,都需要本地电脑安装OFFICE2007和PDF阅读器。图纸软件为CAD,CAXA,PROE,UG,SolidWorks等.压缩文件请下载最新的WinRAR软件解压。
  • 2. 本站的文档不包含任何第三方提供的附件图纸等,如果需要附件,请联系上传者。文件的所有权益归上传用户所有。
  • 3. 本站RAR压缩包中若带图纸,网页内容里面会有图纸预览,若没有图纸预览就没有图纸。
  • 4. 未经权益所有人同意不得将文件中的内容挪作商业或盈利用途。
  • 5. 人人文库网仅提供信息存储空间,仅对用户上传内容的表现方式做保护处理,对用户上传分享的文档内容本身不做任何修改或编辑,并不能对任何下载内容负责。
  • 6. 下载文件中如有侵权或不适当内容,请与我们联系,我们立即纠正。
  • 7. 本站不保证下载资源的准确性、安全性和完整性, 同时也不承担用户因使用这些下载资源对自己和他人造成任何形式的伤害或损失。

评论

0/150

提交评论