卡丁车构造图解2010.doc

目 录图一、车架总成（G、D）FRAME ASSEMBLY ( G、D)-1图二、车架总成（F）FRAME ASSEMBLY (F)-3图三、橡塑件RUBBER & PLASTICS ASSEMBLY-6图四、运动系统RUNNING SYSTEM -9图五、转向系统STEERING SYSTEM-12图六、刹车系统BRAKE SYSTEM -16图七、离合器系统CLUTCH SYSTEM -18图八、护栏总成PROTECTING COLUMN ASSEMBLY-20图九、发动机ENGINE-22说明：1、本图解清册有效期自2010年6月1日至2010年12月31日。 The valid period of the catalogue is from 1st. Jun.2010 to 31st. Dec.2010.2、本图解清册的美元价格是以1：6.8的汇率计算。若需变动，以当日中国银行美元汇率为准。The exchange rate of this catalogue is 6.8RMB to the USD. If anything to be changed, we will stander for the CHINA BANKS USD exchange rate of that day.车 架 总 成（G）编 号N O配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME 单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD1001车架总成（G）Frame assembly（G）1台34005001002发动机护架（G）Engine protection（G）1台280411003后护栏（D）Bear protection colume（D）1个90131004链条护板Chain protection1个304.51005其他1套842124FRAME ASSEMBLY（G）车 架 总 成（D、F）FRAME ASSEMBLY（D、F）编 号N O配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME 单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD2000车架总成Frame assembly2001车架Frame1个32004702002上护栏Theupperprotection column1个120182003上护栏螺丝M6Theupperprotection column boltM64个10.12004上护栏弹簧垫Spring washer of theupperprotection column4个10.12005上护栏螺母Nut of theupperprotection column4个10.12006后防护罩Rear protection cover1个340502007防护罩巨型圈Countersunk washer of rear protection cover2个101.52008防护罩螺丝Bolt of rear protection cover4个10.12009防护罩螺母Nut of rear protection cover4个10.12010脚蹬Pedal 2个120182011脚蹬螺栓M8Bolt M8 of pedal2个10.12012脚蹬垫片Washer of pedal8个10.12013脚蹬螺母M8Nut M8 of pedal4个10.12014脚蹬回位簧Retractingspringof pedal 2个101.52015脚蹬限位螺丝Fitting bolt for Pedal3个10.12016脚蹬限位螺母Fitting nut for Pedal6个10.12017链条护板Protection for chain 1个16024车 架 总 成（D、F）FRAME ASSEMBLY（D、F）编 号N O配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME 单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD2018底板Floor tray1块260382019螺丝M6 Screw M66个10.12020橡胶垫片Rubber washer6个10.12021螺母Nut 6个10.12022管塞Closing plug2个101.52023油门安全弹簧Safety spring1只101.52024座椅螺栓M8*50Bolt for seat M8*502个30.42025座椅螺栓M8*25Bolt for seat M8*252个20.32026座椅螺帽Nut for seat4个10.12027座椅铝垫圈Washer (aluminium) of seat4只812028安全带垫片Safety belt washer4个10.12029安全带固定螺丝M10Bolt for safety belt1个30.42030安全带固定螺母M10Nut for safety belt1个10.12031链条护板支撑架Bumper for chain2个812032支撑架固定螺丝Fixing bolt for bumper2个10.12033支撑架固定螺母Fixing nut for bumper2个10.12034后标志牌上支撑Upper support of bear faring1个2032035后标志牌下支撑Below support of bear faring2个203橡 塑 件RUBBER &PLASTICS ASSEMBLY编 号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD3001座椅Seat1只280413002侧防撞箱Side fairing 2只160243003前标志牌Front fairing 1只140203004后标志牌Rear fairing 1只507.43005缓冲胶垫Countersunk washer13个1523006前轮胎（104.505）Front tire(104.505)2条140213007后轮胎（117.105）Rear tire(117.105)2条180273008安全带Safety belt1条12018运 动 系 统RUNNING SYSTEM编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD4001后轴Rear axle1根360534002后轮毂Rear wheel hub2个240354003前轮毂Front wheel hub2个220324004轮毂固定螺丝M8Screw M8 for Wheel hub joint6个101.54005前轮轴承Axle of front wheel hub4只101.54006平键Key special axle4个101.54007后轴轴承架Rear bearing shell2套90134008后轴轴承Rear bearing axle2个4064009后轴轴承固定螺栓M10Stud bolt M10 for Rear bearing axle9个20.34010后轴轴承定位螺丝垫片Washer for securityfor Rear bearing axle9个10.14011后轴轴承固定螺丝垫圈Stud screw washer for Rear bearing axle9个20.34012后轴轴承固定螺母M10Stud nut M10 for Rear bearing axle 9个10.14013刹车盘接毂Friction lining carrier1个120184014刹车盘Brake disc 1个90134015刹车盘接毂螺栓M8Stud bolt M8 for brake disc carrier4个10.14016刹车盘接毂垫片Washer for friction lining carrier4个10.14017刹车盘接毂螺母M8Nut M8 for brake disc carrier4个10.14018链条Chain 1根80124019链轮接毂Sprocket carrier1个12018运 动 系 统RUNNING SYSTEM编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD4020链轮Sprocket1个80124021链轮接毂螺栓M8the screw M8 for sprocket carrier4个20.34022链轮接毂垫片Washer for sprocket carrier4个10.14023链轮接毂螺母M8Nut M8 for sprocket carrier4个10.14024轮毂接头Wheel hub joint 2个220324025轮毂接头紧固螺栓M8Bolt M8 for Wheel hub joint2个20.34026轮毂接头紧固螺丝垫片Washer for Wheel hub joint6个10.1转 向 系 统STEERING SYSTEM编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD5000转向系统总成Steeringsystem assembly5001方向盘Steering wheel1个280415002方向盘固定座Steering wheel hub1个180275003方向盘固定座螺丝Screwofsteering wheel hub3个20.35004方向盘固定座固定螺栓Stud bolt of steering wheel hub2个10.15005方向盘固定座弹簧垫片Washer of steering wheel spring hub2个10.15006方向盘固定座固定螺母Nutof steering wheel hub2个10.15007方向杆固定套Steering wheel column supp1个3045008固定座螺栓M8Stud bolt of fairing support1个20.35009固定座平垫Washeroffairing support2个10.15010固定座螺母M8NutM6offairing support1个10.15011前标志牌支架Fairing support1付3045012标志牌固定螺栓Studboltoffairing support3个10.15013标志牌固定螺母Studnutoffairing support3个10.15014方向杆Steering shaft1个160245015方向杆卡簧seegher1个10.1转 向 系 统STEERING SYSTEM编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD5016方向杆轴承Bearingofsteering shaft1个101.55017方向杆垫圈Washer ring of steering shaft1个10.15018方向杆垫片Washer sheet of steering shaft1个10.15019方向杆螺母Nut of steering shaft 1个10.15020拉杆内螺栓 M8*45Inside bolt of track rod M8*452个20.35021拉杆衬套（大）Track rod washer (large)2个10.15022拉杆衬套（小）Track rod washer(small)2个10.15023拉杆内螺母 M8Inside nut of track rod M84个10.15024转向球头Uniball 4个4065025拉杆紧固螺母Stub nut for trock rod4个50.75026拉杆（内丝）Track rod(inside screw)2根507.45027拉杆外螺栓M8*35Track rod bolt M82个20.35028拉杆外垫圈Outside washer ring for track rod2个10.15029拉杆外弹簧垫圈Spring outside washer ring for trace rod 2个10.15030拉杆外螺母Outside nut of track rod2个10.15031拉杆定位螺丝Track rod stud screw2个20.35032拉杆定位螺母Track rod stud nut4个30.45033自锁螺母Lock nut2个10.1转 向 系 统STEERING SYSTEM编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD5034羊角螺栓M10King pin bolt2个50.75035羊角平垫（小）Stud axle spacer 8个10.15036羊角轴承Stud axle bearing4个101.55037羊角自锁螺母Stud axle locknut2个10.15038羊角（左）Stub axle (left)1个160245039羊角（右）Stub axle (right)1个160245040羊角螺母Stud axle nut2个10.15041羊角垫圈（塑料）Washer(plastic)of stud axle4个81刹 车 系 统BRAKE SYSTEM编 号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SHCEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD6000刹车总成Brake assembly1套580856001前刹车泵Front brake Pump 1个220336002前刹车泵螺栓M6Front brake pump bolt M82个10.16003后刹车泵Rear brake pump1个280416004后刹车泵螺栓M8Rear brake pump bolt M82个30.46005刹车片Brake shoe2个3046006刹车泵油线Brake oil line1个2036007油线固定螺栓M8Stud bolt of brake oil line2个20.36008刹车线Brake cable1根2036009刹车泵回位簧Back spring brake pump1个50.76010刹车线卡4#Brake clip1个101.5离 合 器 系 统编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD7000离合器总成The clutch assembly1个550817001离合器外轮盘Clutch disk1个220327002离合器离心块组合Clutchcentrifugalblock1个90137003离合器从动轮组合Clutch disc block1个180277004离合器螺栓Stud bolt of clutch1个1527005离合器轴承Clutch shaft bearing1个101.57006离合器轴承Clutch shaft bearing 2个2037007离合器平键Key axle of clutch1个101.57008离合器垫圈（中）Washer of clutch (middle)1个817009离合器垫圈（小）Washer of clutch (small)1个50.7CLUTCH SYSTEM护 栏 总 成PROTECTING COLUMN ASSEMBLY编号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD8000护栏总成Protection column assembly1套36005308001前护栏The front protection column1护栏The rear protection column1栏螺栓M8Protection column stud bolt M827个20.38004护栏垫片Protection column washer 27个10.18005护栏螺母M8Protection column nut M827个10.18006缓冲带Rubber buffer 2根180278007前护栏固定螺丝M10The front protection column bolt M10 2个50.78008前护栏平垫The front protection column washer2个10.18009后护栏固定螺母M10The rear protection column nut M102个10.1发 动 机ENGINE编 号NO配 件 名 称CHINESE英 文 名 称ENGLISH配 套SCHEME单件价格PRICE单车用量NUM单位UNIT单价RMB美元USD9001发动机（国产6.5）Engine（6.5HP）1动机螺栓M8Engine boll4个50.79003发动机垫片Engine washer4个10.19004发动机螺母M8Engine nut4个10.19005启动总成Starting assembly1个120189006化油器Carburetor 1只132199007空滤器Air cleaner1个6099008汽油箱Fuel tank1个120189009活塞环Piston ring1付3049010活塞Piston1个4579011连杆Connecting ro