垃圾焚烧工艺流程图.doc

供应生活垃圾焚烧发电设备(图) 放大图片 所在地： 安徽 桐城市 此产品没有价格信息，您可以联系卖家，询价留言，或与卖家在线洽谈。 点此询价 窗体顶端窗体底端1 2 2 按键盘键可翻页 共有2条“其他公共环卫设施”供应信息 详细信息 批发说明| 运费说明 品牌盛运用途生活垃圾焚烧发电系统以处理城市生活垃圾和工业垃圾为主，通过先进、可靠、成熟的生产工艺和技术设备来处理垃圾、项目全面实施后可以实现城市生活垃圾处理“无害化、减量化、资源化”的目的。利用垃圾焚烧产生的热能可以供暖和发电。在设计阶段可根据垃圾的组成进行了热平衡、化学平衡和气体的流体解析，并进行了精确的设备选定和温度设定。本系统从垃圾投入开始到最后的出灰，整个系统全部自动程序控制。这不仅减少了操作人员，而且保障了系统安全稳定运行，达到最好的垃圾处理效果。The system is mainly about the disposal of urban household garbage and non-toxic&harmless industrial trashthrough the advanced, reliable, mature production technology and technical equipment. After the comprehensive implementation, we can realize the purpose of changing the reduced garbage into resources in a harmless way. Also,the heat energy generated out of garbage incineration can be used in heating and power supply.The chemical equilibrium and fludic analysis of gas as well as the precise equipment selection and temperature enaction shall be executed according to garbage contents at the design stage.From primary garbage input to final ash output , the whole system is controlled by automatic program, which not only cuts the workforce, but also ensures the system safety and steady operation, thus achieving the best garbage disposal effect.垃圾焚烧工艺流程图 Process Flow Of Grbage Incineration城市生活垃圾剔除不可燃烧及有毒有害的废弃物后，由专用垃圾运输车辆送进厂区，驶上地磅进行称重，然后按指定路线驶向垃圾卸料平台，将垃圾卸入垃圾贮存池可贮存57天的处理量，贮存池上方设有垃圾吊，对池内垃圾进行搬运、搅拌和倒垛，以确保入炉垃圾组分均匀。Having eliminated incombustible and noxious waste, the urban household garbage is sent to the factory by special garbage carrier. After weighed on weigh bridge, special garbage carrier is drived to garbage discharging platform, where garbage shall be unloaded into storage pool whch has the storing capacity for 5-7 days. There are two garbage cranes above storage pool for hauling ,stirring up and shifting to ensure the evenly distribution of the incinerated garbage.垃圾焚烧系统包括从垃圾吊车接到垃圾后送至二次燃烧室进行燃烧以及垃圾焚烧炉出渣。焚烧炉的种类很多，焚烧工艺也因焚烧炉的不同而各有差别，本项目将采用国际先进的往复式机械炉排炉，它分为干燥段、燃烧段、燃烬段。根据各段供应的空气量和调节推进的速度，适时掌控炉膛温度，提高垃圾燃烬率。The incineration system covers the process of collecting garbage from carrier ,sending it to re-combustion space and then discharging the slag out of incinerator.there are many kinds of incinerators, Incineration technology differs by incinerators. Using the most advanced international reciprocating mechanical grate, the system is devided into drying section, combustion section and burning section. According to the air amount provided by each stage and by adjusting the velocity of clockwise pushing, furnace temperature can be controlled ,thus increasing the garbage combustion efficiency. 在整个焚烧系统中，我们将配置国内最先进、最可靠、最成熟的设备，垃圾焚烧炉的配套余热锅炉和气轮发电机组。将垃圾焚烧产生的热能通过余热锅炉产生蒸汽，然后用蒸汽供气轮机组发电、上网。In the whole system, we will employ nationally the most advanced, most reliable and most mature equipment to produce steam by the heat generated from garbage incineration through residual heat boiler. Then the steam can be used to generate electricity through the steam electric generating set , then the electricity can be used on internet. 生活垃圾焚烧过程中产生的烟气中会有烟尘、酸性气体、重金属及二恶英等污染物。为了防止垃圾焚烧过程中对环境产生二次污染，我们将严格控制垃圾焚烧温度在850以上且停留2秒以上，以确保二恶英分解。采用投入反应助剂和消石灰的干法烟气净化处理工艺，烟气排放达到国际先进指标。 Fume produced by garbage incineration contains some contamination such as smoke dust, acidic gas , dioxin , heavy metal and so on.In order to prevent the quadric environmental pollution, the garbage incineration temperature should be strictly controlled above 850for more than 2 seconds, which hereby ensures the decomposition of dioxin.With the drying fume purification process through adding reaction auxiliary agent and lime hydrate, fume discharge thus can meet with the internationally progressive indicator.&nbps;&nbps;&nbps;&nbps;垃圾渗滤液主要产生于垃圾贮存池,是垃圾在贮存池中发酵腐烂后,由垃圾内的水分排出而造成的.它的特点是臭味重,有机污染浓度高,氨氮含量高.其含量约占垃圾量的10%左右.我们将在厂区内建设污水处理站,通过UAUB厌氧反应器、膜生化反应器，污泥处理系统处理后，达标排放，用专用管道送至城区污水处理厂。Water inside garbage in the storage pool gives off leachate with heavy odious smell and high viscosity of organic pollution together with rich content of ammonia nitrogen,which accounting for around 10 percent of total garbage volume. Before been discharged and sent to sewage treatment plant by special duct , garbage leachate is processed by UAUB anaerobic reactor, membrane biochemical reactor and sludge disposal system at sewage treatment station which will be built in the factory. 垃圾焚烧后产生的炉渣占垃圾量的10%15%左右，它属于一般废弃物，它从炉中落入输送机，经过降温后送至炉渣堆放处，然后外运到指定地点，再经过加工处理后，可作铺路、制砖的辅料，进行再利用。经布袋回收下来的飞灰，占垃圾总量的3%左右，它属于危险废弃物。我们将对产生的飞灰进行无害化处理，再送填埋场进行填埋。As a common waste, cinder is about 15 percent of garbage. After being dropped onto the conveyer from furnace, the cinder is sent to piling place after being cooled, later on transported to the designated location for the secondary machining. after which, cinder can be turned into an auxiliary material for pavage and brickmaking.The flying ash, as a hazardous waste, collected by bag filter accounting for 3 percent of garbage, then be delivered to landfill site after being treated in a harmless way.垃圾焚烧厂的恶臭味主要来源于垃圾贮存池，我们将采用的控制与防治工艺是加强密封。一是对可能发生臭气外泄的部位都采用密封材料进行封堵；二是在卸料平台进门处设有风幕，防止垃圾车进厂时带来的臭味外泄；三是将垃圾池的臭味抽到燃烧炉膛，用燃烧的办法把臭味成分烧掉，达到脱臭效果。Mainly from garbage storage pool, effluvium shall be controlled by reinforced seal. On one hand,caulk the pote-ntial leaking position with sealant. Secondly, set up air curtain at door of discharging platform to prevent efflluv-ium leakage when a trash truck enters. Thirdly,draw out effluvium to hearth, and realize deodorization by conflagra-ting its effluvium ingredients.实现了垃圾处理的无害化、减量化、资源化。实际烟气排放值严于国家标准，达到国际先进指标，成为名副其实的国际先进的环保项目。Turning the reduced garbage into resources in healthyway.Actual fume discharge value is strict to the national standard, reaching the internationally pr-ogressive indicator.经过焚烧处理，垃圾可减量 85%，而且炉渣还可以再利用，比用填埋方式处理，每年节约用地80亩左右。With incineration processing, garbage can be decreased by 85% and slag can be recycled, compared with landfill disposal, 80 acres can be saved annually.经过焚烧处理，每吨垃圾可发电300度左右，按日处理垃圾1000吨计算，每年可发电1亿度左右，每年节省标煤约48000吨。With incineration processing, electricity around 300kwh can be generated by per ton garbage. Shall 1000 ton of garbage be disposed each day, almost 100 million kwh can be generated each year, thereby, around 48,000 ton of par coal will be saved. 安徽盛运机械股份有限公司 汤松 先生 (销售部网络营销工程师) 在线洽谈 查看联系方式 电话： 86 0556 6206966 移动电话：传真： 86 0556 6205280 地址： 中国 安徽 桐城市 安徽省桐城市同安路265号 邮编： 231400 公司网站： 垃圾焚烧发电是指使用特殊的垃圾焚烧设备,以城市工业和生活垃圾为燃烧介质,在对垃圾进行焚烧处理的同时,利用其产生的能量发电的一种新型发电方式。由于这种处理方式具有环境与经济双重效益,已被发达国家广泛采用。随着国家社会对环境问题的日益关注，垃圾发电设备也必将得到较大程度的发展。由于垃圾发电在垃圾处理的方式中具有无比的优越性。垃圾发电厂不但能够缓解垃圾带来的城市污染,具有良好的社会和经济效益。因此其未来发展前景十分看好。垃圾发电产业已成为一块正在不断做大的“蛋糕”，任何资本都不会无视其中隐藏的巨大商机。 电力设备行业中，最受惠于上述政策的企业，可以分为两大类。一类是用新能源替代煤炭、石油等传统能源的发