珠海市环境影响评价报告书

videoconference, Secretary of the provincial Committee of Xia Baolong stressed: this year is the five water treatment 357 timetables for three years to resolve outstanding issues, obviously worked, victory of the year. The Countys departments at all levels must firmly establish the guanghui is gold and silver green development concept, convinced that Castle is not relaxed, always maintaining strategic ability and strong determination to improve the environment, consistently playing well five water treatment of winning the war, ever-higher levels of comprehensive well-off society was built. (A) lay the sewage uphill battle. This year we will river water quality improved at the county level, up to five this basic objective grasp of pollution control that focus, with the focus on three things: a good job, clear rivers reaching the County created. Organization look back special inspection, the County garbage River, black and odorous River is Dragnet investigation, timely rectification of problems found in place firmly to prevent river pollution rebound. In accordance with the one-stop strategy, improving the inferior five water quality monitoring stations work this year to ensure the Elimination of 1 provincial control, five water quality section 3 municipalities controlled deterioration, ensure the creation this year of clear rivers standards. Second, pay special attention to pollution-cutting construction of nanotubes. Intercepting nanotubes are the basis of pollution of water source engineering, engineering, matter of success or failure of water management. Urban sewage treatment, to improve effluent from sewage treatment rate, running accuracy, compliance requirement, speed up the towns support network construction, is focusing on nanotubes home last meters question. Domestic sewage treatment in rural areas, this year is the final year of the three-year action, determination to fight and the momentum around, ending the battle on which fully to ensure the realization of all County 648 formed village coverage. Also, be sure to attach importance to focus on rural domestic wastewater treatment facility operation and management, ensure that wastewater treatment facility up and running, role play, avoid the Sun problem. Third, pay special attention to the River Lake pond desilting operation. Provinces now have focused on pollution control of water go to dig up mud, as the deepening water of this years plays. Next, to jump-start an investigation line touches work, implementation plan according to the priorities and the programme of work, in accordance with the one river one policy requires detailed cleaning, dredging plan, planning ahead of time cleaning out mud way out, according to local conditions to do sludge, promote scientific resource utilization of silt and mud. (B) the heavy regulation of heavily polluting industries. Pollution of water must grab the source, wastewater is primarily the source of backward production capacity, increase the intensity of广州华凯车辆装备有限公司年产600辆专用车项目环境影响报告书简本1.项目概况1.1基本情况（1）项目名称：广州华凯车辆装备有限公司年产600辆专用车项目。（2）建设地点：建设项目拟建址位于广州市花都区炭步镇南街工业区，东面和西面为市政路，南面与易恒精密仪器科技有限公司和兆华牧业加工有限公司，项目北面为空地。（3）建设规模：年产军警用专用车600辆（4）投资：本项目总投资8000万元，环保投资300万元，占总投资的3.75%。（5）建设性质：属新建项目。1.2主要建设内容本项目总用地面积为35164.6m2，全部利用广州维亚通用实业有限公司现有的场地、建构筑物、公用动力设施及部分设备，补充少量设备和工艺工装，不新增用地。广州维亚通用实业有限公司现已撤销，空置了一间钢结构厂房。本项目利用现有厂房进行建设，将厂房划分为钣金车间、焊装车间、总装车间和底盘改制区以及整车调试检测区，并新增喷漆房、空压站及污水处理站等配套设施。1.3生产纲领及产品方案本项目建成后，公司具备年改装各类警用车600辆的生产能力。改装用车全部购买自其它汽车生产企业。表1 生产纲领表序号产品名称单位数量生产任务1水罐防暴车辆100上装制造及整车装配2反恐突击车辆100上装制造及整车装配3防弹运兵车辆200上装制造及整车装配4警用装备车辆200上装制造及整车装配合 计辆6001.4主要原辅材料、外协部件华凯车辆装备有限公司使用的主要原辅材料包括钢材、焊丝、各类涂料等，并外购主要配件，主要原辅材料及能源用量见表2，主要外协配件见表3，设备见表4。表2 本项目主要原辅材料及燃料年耗用量序号名 称年需求量单位数量一、钢材类t1215二、油漆类t1中涂漆t9.3底漆2清漆t0.53面漆t10.64稀释剂t18.5三、胶类Kg600四、燃料类1汽油t7.52柴油t4.5五、焊接材料1焊条Kg6000六、打磨类1砂纸Kg70七、能源类1电Mwh1112八、整车1载重货车辆1002依维柯辆1003E-350警用车辆2004货车辆200表3 本项目主要外协部件一览表序号外协件名称主要供应单位备注1水罐防暴车底盘中国重型汽车集团公司2厢式运输车底盘庆铃汽车公司3防弹运兵车底盘美国福特汽车公司4防弹玻璃广州兴华玻璃工业有限公司5防弹钢板北京国稷信业贸易有限公司6监控系统广州三水市好帮手电子科技有限公司7警灯/报警器温州奥乐安全器材有限公司8比例混合器广州花都通用集团有限公司9专用气动球阀广州花都通用集团有限公司10水炮管广州花都通用集团有限公司含加工与焊接11水炮旋转体广州花都通用集团有限公司含加工12防弹炮塔广州花都通用集团有限公司含加工13脉冲水炮以色列HATEHOF GROUP14水泵陕西航天动力高科技股份有限公司2.污染源分析本项目污染物主要包括废水、废气、固废和噪声。（1）废水本项目生产废水主要为涂装过程中产生的打磨废水。中涂漆及面漆的喷涂过程中，需要将喷涂后的车身晾干、湿打磨及烘干，手工湿打磨过程中会产生湿打磨废水，其产生量约为1.0m3/d。这部分废水净化后循环使用，不外排。水炮试射水属清净下水，产生量为0.4m3/d，进入雨水管网后排放。炭步镇60000西北1300环境空气大坳村4600东南3100环境空气红峰村1500东北2100环境空气社岗村2000东2400环境空气新太村6500西1300环境空气郎溪村100东南1200环境空气石湖村1200东北1600环境空气石南村1000东1200环境空气江村、石门、西村水厂饮用水源保护区陆域及水域饮用水源准保护区、二级保护区4.环境影响预测与评价4.1水环境影响分析水环境影响分析表明，本项目建成后工艺废水全部处理后回用，生活废水经由新华污水处理站处理后达标排放。水污染物的负荷较小，不会对本地区附近地表水体水质产生明显的影响。同时由于新华污水厂的建成已经后续扩建工程的启动，本地区水污染物符合将进一步减小，也将为本地区经济发展腾出必要的水容量环境，为本项目的建设创造良好的环境。4.2环境空气影响预测与评价本项目所在地区受亚热带季风气候影响，冬季盛行偏北风，夏季盛行偏南风。全年平均风速较大，静小风频率相对较小，厂址周围地势平坦开阔，有利于大气污染物的稀释扩散。本项目不设锅炉，废气主要来自于涂装车间喷漆产生的有机废气。根据大气影响预测结果，本项目有机废气经吸附后达标排放，二甲苯最大落地浓度能满足工业企业设计卫生标准(TJ36-79)限值要求，各敏感点二甲苯浓度也可以满足评价标准的要求，本项目排放有机废气对区域环境空气质量影响很小。4.3声环境影响预测与评价项目昼间和夜间噪声值均能够达到城市区域环境噪声(GB3096-93)2类标准限值。项目建成后，其昼间和夜间噪声增值较小，其边界噪声值能够达到（GB3096-93）2类标准。4.4固体废物影响预测与评价建设项目将针对生产过程中所产生的各类固体废物，依其种类、特性拟订相关的管理办法及处置措施，对于无毒无害可再利用物质皆加以分类回收、再利用，增加资源利用。属危险废物类将分类收集，集中堆放，定期交给有资质的废物回收处理中心或合格废弃物处理厂商有效且妥善处理，以符合相关规定。生活垃圾应按指定地点进行堆放，并要做好垃圾堆放点的消毒工作，防止蚊蝇滋生，定期交环卫部门清运、填埋处理。则本项目产生的危险废物、一般性固体废物及生活垃圾将不会对周围环境产生明显的影响。5.环境保护措施5.1水环境保护措施本项目生产废水循环使用，不外排。生活污水委托新华污水处理厂定期处理。5.2废气本项目喷漆和烘干工序都在成套喷漆房内进行，喷漆房工作时，送风机将新鲜空气从进风口吸入，先经过第一道滤尘网把空气中的大颗粒灰尘滤去，然后进入喷/烤漆房顶部气室，空气流经过顶部过滤棉被过滤干净从顶部均匀地向下流动，在工件周围形成风幕。先经过地棉初滤喷漆过程中的过喷漆雾、烘干废气和杂质，后从排风环保柜，通过过滤棉和活性碳再滤去剩余漆雾、有机废气，净化率可达90。经处理后的废气直接从排气口排出房外，二甲苯的排放浓度小于大气污染物排放限值（DB44/27-2001）中的二级标准（第二时段）。对于本项目焊装车间32台焊机，建议采用焊烟净化机组，即每个焊位安装一个自动定位的烟气捕集吸口，焊烟收集后进入净化机组进行处理，除尘效率可达95以上，如焊位的焊接烟尘浓度为21mg/m3，则经处理后的焊接烟尘浓度降为5mg/m3。逸散在室内的烟气由屋顶风机抽排。5.3噪声控制声源，采用符合国家规定的噪声标准的设备，优先考虑低噪设备；对允许密闭的设备加以密闭，并装设通风排风消声器，在送风机入口处安装消声器，对风机加装隔声罩。控制其传播途径，厂区内建筑物合理布置，高噪声设备尽量加以密闭，修建厂界围墙，设置隔声屏障，并种植高大树木绿化隔声，植树宽度达到10米，以衰减降低噪声，使厂界噪声达到规定的标准范围之内。5.4固废生活垃圾由环卫部门清运，一般工业固废回收利用，危险废物由有资质单位进行安全处置。6.环境影响评价主要结论（1）本项目的建设符合国家产业政策、花都区炭步镇总体规划以及区域环境保护规划的要求。（2）环境空气影响本项目建成后，大气污染物不会造成环境空气质量恶化。本项目的烟气治理措施是可行的。（3）水环境影响本项目生产废水不外排，生活污水委托新华净水厂处理后达标排放，不会对区域水环境质量造成不良影响。（4）声环境影响本项目建成后对周边的声环境将产生一定的影响。昼间各边界噪声值将增加0.393.44 dB(A)，夜间各边界噪声值将增加6.287.64 dB(A)。其中东边界、南边界、北边界受影响较大，西边界受到的影响并不明显，这是由于生产车间和空压站等集中在厂界的东南、东北部。总体来看，项目建成后厂区边界的噪声级仍然都能满足2类声环境质量标准（昼间60dB(A)，夜间50dB(A)）。（5）综合结论建设单位必须严格遵守“三同时”的管理制度，完成各项报建手续，本着以人为本的宗旨，切实保证本报告提出的各项环保措施的落实，并尽一切可能确保本项目建成后所在区域的环境质量不因本项目的建设而受到不良影响，真正实现环境保护与经济建设的可持续协调发展。拟建项目毕勋认真落实本评价提出的环境保护各项指标和污染治理措施，同时保证治理措施的稳定安全运行。项目建成后，须经环境保护主管部门进行竣工验收。生产过程中应加强对设备的维修保养，确保环保设施的正常运转。对危险废物实行严格管理处、不随意排放。综上所述，广州华凯车辆装备有限公司年产600辆专用车项目，符合国家产业政策，环保措施可行，厂址的选择符合地区发展规划。在达到本报告所提出的各项要求后，该项目的建设对周围环境质量不会产生明显的影响，从环境保护的角度而言，该项目在拟选址进行建设是可行的。为了促进本公司各项经营活动由事后管理向事前管理方式的转变，强化生产经营全过程控制，提高资金使用的计划性，特制定本管理办法，以增加公司资金运行的透明度，降低各项成本，使有限的资金发挥最大的效能。treatment of heavily polluting industries. According to municipal, and municipal government deployment of seven big heavy pollution industry regulation three years action plans, requirements to December 2016 end of Qian, all included shut stopped eliminated of enterprise all shut stopped eliminated in place; June 30, 2017 Qian, all included place regulation upgrade and agglomeration restructuring of enterprise by unified standard regulation in place, late not standard of enterprise are implementation discontinued; June 30, 2018 Qian, all intends Park production of enterprise relocation Park in place, late not Park of are discontinued. In the process of renovation, will focus on four aspects: to firmly close the high energy consumption and heavy pollution, hopeless enterprise governance and production lines, eliminated a number of yearly emission intensity, low value-added products of backward production capacity. Second, we must strictly enforce the space, total project Trinity environment access system, promoting industry access and environmental conditions of access of enterprises to the Park, industrial park, in principle, no longer the class on the new project. Thirdly, promoting replacement and reconstruction of heavily polluting industries, mergers and reorganizations, guide enterprises to energy conservation, recycling and low-carbon and clean production, and improve the level of green development. Four to establish a long-term supervision mechanism, increase the intensity of special inspections, investigate and punish the rectification is not in place, normal business of running anti-pollution installations do not. (Iii) linkage to promote flood control water, drainage, water supply, improving water saving. Speed up cross Yang support river dike reinforcement, and along Pu seawall except insurance reinforcement, and Lake Qian sluice, and BA Cao sluice, and cloud cover reservoir, focus flood control drainage engineering construction, vigorously implementation strong library solid di spread row engineering,