酸洗钝化报告

1、酸洗钝化报告The manuscript was revised on the evening of 2021酸洗和钝化报告Pickling & Passivation Report设备名称：图纸编号：Equipment Name:Drawing No.承包方：Contractor:预备Preparation草节 Para过程步腺Process Step实验结果Initials丨1期Date箱体，泵，软管和所有其他清洗设备Tank, pump.hoses and all other cleaning equipment 经检验认定是清洁的，无湿润表面污染手的是/否Verified as

2、 clean, fress of wetted surface contaminants.Yes/No系统组成部分是安全并通过了检査是/否System components are safe and checkedYes/No冲洗FlushingPara过程步骤Process Step实验结果InitialsII期Date开始时间：日期：Start Time:Date:结束时间：日期：End Time：Date:在冲洗至少进行30分后.Free from visible particulate or未发现肉眼可见的颗粒或变色？是/否Discoloration after flushing fo

3、r at least 30 seconds Yes/No去油脂油污Degrease苹节 Para过程步骤 Process Step实验结果Initials日期Date331所采用的水的类型： Type of water used:331a+/%的氢氧化钠溶液+/% Sodium Hydroxide+/%的乙二胺四乙酸溶液（EDTA） +/%EDTA酸洗和钝化报告苹节 Para过程步腺Process Step实验结果Initials日期 Date332在整个系统中采用溶流进行循环/冲洗（一次循环）.持续一个小时，温度在L+/.iorSolution recirculated / flushed

4、（circle one） through the system for 1 hour at ' +/-10 开始时间：开始温度：r-Time started:Start temp:结束时间：结束温度：fTime ended：End temp：335采用：样的水进行冲洗Rinsed withWater.采用的水的类型经过业主的批准：是/否Water type approved by Owner:Yes/No开始时间：结束时间：Time started:Time ended:3.3.6如果合适的话，填写PH （酸碱度值）实验数据或低磷酸盐实验数据 Complete the PH test

5、data or the low phosphate test data as applicable 如果合适的话，进行PH（酸碱度值）实验：通过/未通过PH testjf applicable:Pass/Faill实验试纸带編号#Test strip Lot#供应水的PH值读数：时间：Source water reaing:at time:排出水的PH值：时间：Effluent reading:at time:3.3.7业主要求采用经过滤保护的纯净水來过行冲洗和最终冲洗：是/否Filtered protected fresh water was used for rinsing andYes/

6、Nofinal rinse was required by Owner: 若“是”完成填写以下关于最终冲洗的信息.若是不需要填写。If'Yplete the following final rinse data.if No,do not complete. 最终冲洗采用水來完成是/否Final rinse withWater completed.Ye&/No柠檯钝化Ci(ric Passivation草节过程步骤实验结果期ParaProcess StepInitialsDate所采用的水的类型：Type of water used:开始时间：开始温度：Time st

7、arted:Start temp:°C观察到泄漏情是/否Leakage observed:Yes/No结束时间：结束温度：Time ended:End temp:°C酸洗和钝化报告IV. 匕 草卩Para过程步腺Process Step实验结果Initials日期 Da忙PH (酸碱度值)实验通过7未通过PH test:Pass/Fail用于实验的试纸带是/否 若“是”Paper test stripa used for testing: Yes/No iF'Yes" 每个输出口的颜色是否匹配：是/否Color match at each outlet:Y

8、es/No厳终冲洗Final RinsePara过程步腺Process Step实验结果Initials日期 Date3.5.1所采用的水的类型 Type of water used:3.5.2用于PH （酸喊度值）实验的试纸速PH test strips used for testing:每个输出口的颜色是匹配：是/否Color match at each out let:Yes/No353每个点都进行了冲洗和测试：是/否Each point rinsed and tested: Yes/No 通过：是/否Pass:Yes/No每个实验步骤的实验结果和曰期证明全部的工作已经完成并通过检查。Initials and dates for each process step constitute certification that the work is completed and has been checked.姓名（打字/打印）签字实验结果曰期Name(typ