发动机滑油勤务16

1、,发动机滑油勤务 XJLG-1.5.02-R0,机务培训中心.,Copyright 2009 Shenzhen Airlines,2020/6/22,2,内容介绍,一、滑油箱与滑油 二、滑油量的读取 三、加油程序、方法,2020/6/22,3,滑油箱与滑油,1.滑油箱,Component location The engine oil tank is on the fan case, at the 3:00 position. The oil tank access door is on the side of the right fan cowl. 位置：风扇框架3点钟位置,滑油箱,acce

2、ss door,2020/6/22,4,Physical Description The engine oil tank holds approximately 21 US quarts (20.2 liters). The oil tank for engine 2 can hold more oil than engine 1. This is because of the dihedral of the wings.,1加仑4夸脱 1夸脱0.95升,2020/6/22,5,The oil tank has a oil level sight gage, a gravity fill po

3、rt, and pressure servicing fill ports. 滑油箱有一个观察窗，一个重力加油口和一个压力勤务加油口。,2020/6/22,6,BP TURBO OIL 2197 符合军标MIL-PRF-23699F HTS。 为深航现使用的发动机滑油,2.滑油,2020/6/22,7,滑油量的读取,Do a Check of the Oil Quantity With the engine not in operation, examine the oil level Indication in the flight compartment.发动机不运转的时候在驾驶舱读取滑油

4、量,2020/6/22,8,2020/6/22,9,航后滑油量标准： 737300 94(100%) 737700/800/900 18夸脱(20夸脱),2020/6/22,10,加油程序、方法,参考 AMM 12-13-11-600-801 A General 1.Oil should be added not less than 5 minutes and no greater than 30 minutes after engine shutdown while the oil in the tank is still warm. This will prevent the over-s

5、ervicing of the engine. 滑油应该在发动机停车后530分钟之内加此时滑油箱还是温的。这样可以阻止加油过量。 2. Do not mix different approved brands of oil unless you refer to CFMI SB 79-001.除非参考CFMI SB 79-001，否则不能将不同的被认可混合使用。,2020/6/22,11,3. The oil tank should be serviced on a regular basis such that the oil level indication, with the engin

6、e not running, is equal to or greater than 60 percent full or 12.00 U.S.quarts (11.40 liters). 滑油箱勤务有规定的标准，即滑油量指示在发动机停车后大于或等于满油量的60%或12美加仑。 NOTE: An indicated oil level 60% minimum will prevent transient low oil level indications during takeoff phase due to gulping and airplane pitch and longitudina

7、l acceleration. 注意：滑油量指示至少60% 可以阻止飞机起飞阶段暂时的低滑油量指示 抑制飞机俯仰和纵向加速。,2020/6/22,12,B Replenish the Engine Oil (1) Open the applicable access door on the right fan cowl panel.打开右侧风扇机匣面板上的滑油箱接近门。,2020/6/22,13,(2) Do a check of the oil quantity with the sight gage 在目视观察窗进行滑油量检查。,2020/6/22,14,2020/6/22,15,WARN

8、ING: DO NOT REMOVE THE FILLER CAP OF THE OIL TANK FOR FIVE MINUTES AFTER AN ENGINE SHUTDOWN. IF THE CHECK VALVE IS DEFECTIVE, HOT OIL CAN SPRAY FROM THE OIL TANK AND CAUSE INJURY TO PERSONS.THE OIL IN THE TANK IS HOT AND PRESSURIZED DURING ENGINE OPERATION. 警告：发动机停车后五分钟内不要移除滑油箱上的油滤帽。如果单向活门不完整，热的燃油会从

9、滑油箱内喷射出来造成人员伤害。滑油箱内的燃油在发动机运转过程中是热的而且是增压的。,WARNING: YOU MUST FULLY CLEAN YOUR SKIN IF YOU TOUCH THE OIL. REMOVE OIL SOAKED CLOTHES IMMEDIATELY. IF THE OIL TOUCHES YOUR SKIN FOR A LONG TIME, IT COULD CAUSE DERMATITIS（皮炎）. 警告：如果你接触到滑油必须清洗干净皮肤。用湿透的布擦除滑油。如果滑油长时间接触你的皮肤，可能会引起皮炎。,2020/6/22,16,2020/6/22,17,C

10、AUTION: IMMEDIATELY CLEAN THE PAINTED SURFACES ON WHICH OIL FALLS. THE OIL WILL PUT STAINS ON CLOTHES AND CAN MAKE PAINT SOFT. 警告：如果滑油洒落在着色的表面应立即清除。滑油会对沾染衣服而且会使其颜色变浅。,CAUTION: DO THE REPLENISH THE ENGINE OIL PROCEDURE BEFORE THE OIL TANK BECOMES COOL (30 MINUTES AFTER THE ENGINE SHUTDOWN). IF THE TA

11、NK IS COOL, YOU CAN FILL IT TOO MUCH AND CAUSE AN INCORRECT INDICATION OF THE OIL CONSUMPTION RATE. 警示：滑油箱冷却之前做加注滑油的工作（一般发动机停车后30分钟之内做次工作）。如果滑油箱冷却了，你可能会加入过多的滑油，这样可能导致滑油消耗率错误指示。,2020/6/22,18,2020/6/22,19,(3) Do these steps to remove the filler cap to the oil tank 做以下步骤拆除滑油箱上的加油口锁帽 NOTE: Samples must

12、be taken 15 to 30 minutes after the engine shutdown and before you add oil to the oil tank 注意： 抽样检查必须在发动机停车后1530分钟，加注滑油之前进行,CAUTION: MAKE SURE THAT THE OIL TANK AND SCUPPER ARE CLEAN. IF THE OIL TANK AND SCUPPER ARE NOT CLEAN, CONTAMINATION OF THE OIL TANK AND OIL SAMPLE CAN OCCUR DURING THE SAMPLIN

13、G OPERATION. 警示：确保滑油箱和排油口是清洁的。如果滑油箱和排油口不清洁，在做油样抽样检查时会出在滑油箱和滑油污染。 (a) Use a cloth, G00034, to clean the oil scupper. 用抹布， G00034, 擦拭滑油排油口。,2020/6/22,20,2020/6/22,21,(b) Lift the filler cap handle.拿起加油口锁帽把手。,(c) Turn the filler cap handle counterclockwise to open it.逆时针旋转加油口锁帽把手使其打开。,(d) Pull the fill

14、er cap from the gravity fill port.从重力加油口上拿出加油口锁帽。,2020/6/22,22,注意：连接链条,2020/6/22,23,(4) Add oil, D00599 CP2442, to the gravity fill port of the oil tank and stop before the full mark of the sight gage. 加注D00599 CP2442滑油到滑油箱重力加油口 在到达满油位之前停止加油。,2020/6/22,24,If non-approved oils or different oil types

15、was added to the engine oil,do these steps: 如果加注了不允许的或不同类型的滑油，做以下步骤 1) If the quantity is less than 10 percent (2 quarts or less)(1.9 liters or less), no action is necessary. 如果加入量小于10，不需采取任何行动。 2) If the quantity is more than 10 percent (2 quarts or more)(1.9 liters or more), you must drain and rep

16、lenish the oil tank before the subsequent flight. 如果加入量大于10，必须放出比且重新加注滑油在下一 个航段之前。,2020/6/22,25,(5) Do these steps to install the filler cap in the oil tank 做以下步骤在滑油箱上安装加油口锁帽。 (a) Examine the packing on the filler cap. 检查加油口锁帽上的封圈。,(b) Make sure that the packing is in its position. 确保封圈在正确的位置 1) If

17、the packing is damaged or shows deterioration, replace the packing (AMM TASK 79-11-01-300 p801). 如果封圈损坏或已退化，应更换封圈参考 (AMM TASK 79-11-01-300 p801).,2020/6/22,26,2020/6/22,27,(c) Put the filler cap in its position in the gravity fill port.将加油口锁帽放在重力加油口上相应的位置。 (d) Push the filler cap in and turn the filler cap han