芯片手册el302x中文资料

1、元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERFeatures: Peak breakdown voltage- 250V: EL301X- 400V: EL302X- 600V: EL305X High isolation voltage between input and output(Viso=5000 V rms ) Compact dual-in-line package Pb free and RoHS com

2、pliant. UL approved (No. E214129) VDE approval (pending) SEMKO approval (pending) NEMKO approval (pending) DEMKO approval (pending) FIMKO approval (pending) CSA approval (pending)DescriptionThe EL301X, EL302X and EL305X series of devices each consist of a GaAs infrared emitting diode optically coupl

3、ed to a monolithic silicon random phase photo Triac.They are designed for interfacing between electronic controls and power triacs to control resistive and inductive loads for 115 to 240 VAC operations.SchematicApplications Solenoid/valve controls Lamp ballasts Static AC power switch Interfacing mic

4、roprocessors to 115 to 240Vac peripherals Incandescent lamp dimmers Temperature controls Motor controlsPin Configuration1. Anode2. Cathode3. No Connection4. Terminal5. Substrate(do not connect)6. TerminalEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 01 February

5、 23, 2008162534元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERAbsolute Maximum Ratings (Ta=25C)Notes*1 AC for 1 minute, R.H.= 40 60% R.H. In this test, pins 1, 2 & 3 are shorted together, and pins 4, 5 & 6 are shorted together.*2 For 10

6、seconds.Everlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 02 February 23, 2008ParameterSymbolRatingUnitInputForward currentIF60mAReverse voltageVR6VPower dissipationDerating factor (above 85C)PD100mW3.8mW /COutputOff-state Output Terminal VoltageEL301XVDRM250VEL302

7、X400EL305X600Peak Repetitive Surge CurrentITSM1APower dissipationDerating factor (above 85C)PD300mW7.4mW /CIsolation voltage *1Viso5000V rmsTotal power dissipationPD330mWOperating temperatureTopr-55+100CStorage temperatureTstg-55+125CSoldering temperature *2Tsol260C元器件交易网 EL301X Series

8、 EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERElectrical Characteristics (Ta=25C unless specified otherwise)InputOutputTransfer Characteristics* Typical values at Ta = 25CEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 03 February 23

9、, 2008ParameterSymbolMin.Typ.*Max.UnitConditionLED Trigger CurrentEL3010 EL3021 EL3051IFT-15mAMain terminal Voltage=3VEL3011 EL3022 EL3052-10EL3012 EL3023 EL3053-5Holding CurrentIH-250-AParameterSymbolMin.Typ.*Max.UnitConditionPeak Blocking CurrentIDRM-100nAVDRM = Rated VDRM IF = 0mAPeak On-state Vo

10、ltageVTM-2.5VITM=100mA peak, IF=Rated IFTCritical Rate of Rise off-state VoltageEL301X EL302Xdv/dt-100-V/sVPEAK =Rated VDRM, IF=0 (Fig. 8)EL305X1000-VPEAK =400V, IF=0 (Fig. 8)ParameterSymbolMin.Typ.*Max.UnitConditionForward voltageVF-1.181.5VIF = 10mAReverse Leakage currentIR-10AVR = 6V元器件交易网www.cec

11、 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERTypical Performance CurvesEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 04 February 23, 2008元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP

12、RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERFigure 8. Static dv/dt Test Circuit & WaveformD.U.T.RTEST10 kT1AHigh Voltage Pulse SourceKCTESTVT50 T2Applied VT Waveform VPEAK0.632 x VPEAK 0tRCMeasurement MethodThe high voltage pulse is set to the required VPEAK value and applied to the D.U.T. output side thr

13、ough the RC circuit above. LED current is not applied. The waveform VT is monitored using a x100 scope probe. By varying RTEST, the dv/dt (slope) is increased, until the D.U.T. is observed to trigger (waveform collapses). The dv/dt is then decreased until the D.U.T. stops triggering. At this point,

14、tRC is recorded and the dv/dt calculated.0.632 x VPEAKdv/dt =tRCEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 05 February 23, 2008元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERFor example, VPEAK =

15、400V for EL302X series. The dv/dt value is calculated as follows:0.63 x 400tRC252tRCdv/dt =Order InformationPart NumberEL301XY(Z)-V or EL302XY(Z)-V or EL305XY(Z)-VNoteX = Part No. for EL301x (0, 1 or 2)X = Part No. for EL302x, EL305x (1, 2 or 3) Y = Lead form option (S, S1, M or none)Z = Tape and re

16、el option (TA, TB or none). V = VDE safety approved optionEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 06 February 23, 2008OptionDescriptionPacking quantityNoneStandard DIP-665 units per tubeMWide lead bend (0.4 inch spacing)65 units per tubeS (TA)Surface moun

17、t lead form + TA tape & reel option1000 units per reelS (TB)Surface mount lead form + TB tape & reel option1000 units per reelS1 (TA)Surface mount lead form (low profile) + TA tape & reel option1000 units per reelS1 (TB)Surface mount lead form (low profile) + TB tape & reel option1000 units per reel

18、元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERPackage Drawings(Dimensions in mm)Standard DIP TypeOption M TypeEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 07 February 23, 2008元器件交易网

19、EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLEROption S TypeOption S1 TypeEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 08 February 23, 2008元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-

20、PHASE TRIAC DRIVER PHOTOCOUPLERRecommended pad layout for surface mount leadformDevice MarkingNotesEL 3053 Y WW Vdenotes Everlight denotes Device Number denotes 1 digit Year codedenotes 2 digit Week code denotes VDE optionEverlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 09http:/www.ever

21、 February 23, 2008EL 3053YWWV元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERTape & Reel Packing SpecificationsOption TAOption TBDirection of feed from reelDirection of feed from reelTape dimensionsEverlight Electronics Co., Ltd.

22、 Document No：PDS-ELRP-001 Rev. 010 February 23, 2008Dimension No.PoP1P2tWKDimension (mm)4.02.00.10.350.0316.0Dimension No.ABDoD1EFDimension (mm)20.11.5+0.1/-01.5+0.1/-01.7元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN

23、 DIP RANDOM-PHASE TRIAC DRIVER PHOTOCOUPLERSolder Reflow Temperature Profile260 C (peak)255 C (30s Min)217C1-3 C/Sec Max200C60 140 Sec150C70 170 Sec1-3 C/Sec MaxTIME (S)Everlight Electronics Co., Ltd. Document No：PDS-ELRP-001 Rev. 011 February 23, 2008元器件交易网 EL301X Series EL302X Series EL305X Series6 PIN DIP RANDOM-PHASE TRI