醇酸铝粉石墨面漆.doc

醇酸铝粉石墨面漆Intended Uses用途适用于铁路、桥梁及其它大气环境下钢结构的防腐涂装用面漆。Suited for painting the railway, bridge or other various steel structures in atmosphere environmentas finish.ProductDescription产品简介灰色，含惰性及鳞片状防锈颜料，漆膜具有优异的耐水性、耐大气老化性及耐盐雾性。符合铁道桥梁涂装用面漆规范要求。Gray, Contain inert anti-rust pigments. The coat is possessed of excellent resistance to water, weathering and salt fog. Meet the demands of finish standard of railway and bridge.ProductInformation产品数据Volume Solids 固体份42 %Dry Film Thickness 干膜厚度40-60 mTheoretical Coverage 理论涂布率7.5 m2 /Kg 7.5平方米/公斤Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Application Details施工详述Mix Radio 混合比One package 单罐装Method of Application 施工方法 Airless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conventional Spray 传统喷涂 Recommended 推荐采用Thinner 稀释剂 C000Cleaner 油漆设备清洗剂 C000Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Drying time 干燥时间SubstrateTemperature底材温度,Touch Dry表干,hHard Dry硬干,hOver coating Interval覆涂间隔Mix最短Max最长35200.5116244 h6 hNot limit不限Storage andHandling贮存与管理Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 20 Kg in 20 liter container 20公斤装于20公升容器中Flash Point 闪点 35Specific Gravity 比重 1.12Kg/L 1.22公斤/公升Specification andSurface preparation技术要求及表面处理Steel structure the surface painting over right primer must keep clean, dry and no oil or dirty.钢结构：用于已涂底漆的表面，需保持清洁干燥，无油污。 Limitations限制Not recommended to be applied over zinc-rich primer.不推荐直接涂装在富锌底漆表面上。Safety Precautions 安全措施The product must be used in painting area by professionals. When painting , please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will not be responsible for any accident. 本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)。 施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的10 %,通常每千克溶剂需要200立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限10 %的工作环境。 采取有效措施，防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩及涂防护油等)。