水性环氧防腐面漆的用途和方法.doc

Intended Uses用途水性环氧防腐面漆属于水性防腐涂料，和水性环氧底漆配合使用可用于金属结构或混凝土表面涂装，尤其适用由于健康或安全原因不允许挥发溶剂时，不推荐用于阳光直接照射部位。It is widely used for the surface of metal or concrete, especially when it is not permitted releasing solvent because of the environment or safety.No recommending using for the surface which exposed to sun ProductInformation产品简介水性环氧防腐面漆各色，有光或哑光，水性双组份环氧面漆，漆膜附着力强，耐磨性佳，具有良好的耐化学品性，可抵抗盐雾及中度的酸、碱、盐。以水为分散介质，不然不爆，可用水稀释和清洗涂装用具，施工过程无污染，具有安全环保特性。A series of colors, dark or bright, two-packages water-miscible epoxy finish, the adherence, the rub-resist, the solvent-resist is good. It resists the salt fog, and acid, alkali, salt. It is dispersed by water, resisted fire and burst, can be diluted or cleaned by water. No pollution, safety and environmental protection.Application details产品数据Volume Solids 固体份50%ccording 48%Dry Film Thickness干膜厚度50microns equivalent to 104 microns of wet film 50微米相当于104微米湿膜厚Theoretical Coverage 理论涂布率8.0 m2 /Kg 8.0平方米/公斤Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Storage and Handling施工详述Mix Radio 混合比A : B=5:1(by weight ) 甲:乙=5:1(重量比)Method of Application 施工方法 Airless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conventional Spray 传统喷涂 Not Recommended 不推荐采用Thinner 稀释剂 清洁淡水（Clean water）Cleaner 油漆设备清洗剂 清洁淡水（Clean water）Pot Life 使用期 20：3hStorage 贮存期 One year 一年Drying time 干燥时间SubstrateTemperature底材温度,Touch Dry表干（min）Hard Dry硬干(h）Over coating Interval覆涂间隔Mix最短Max最长2560243hours 小时Not limit不限Storage andHandling贮存与管理Storage 贮存 Store in cool and dry conditions ( 5-40),no exposing to frost 贮存在5-40之间的凉爽干燥环境之中，不得暴露于霜冻环境。Pack size 包装规格 A;17.5Kg in 20 liter container 甲:17.5公斤装于20公升容器中 B:2.5Kg in 2.5 liter container 乙:2.5公斤装于2.5公升容器中Flash Point 闪点 No 无Specific Gravity 比重 1.10-1.20Kg/L 1.10-1.20公斤/公升Specification and Surface preparation技术要求及表面处理The surface which was coated before: clean, dry, and please be sure if the coat is permitted or not。The surface of the concrete: no water, no oil etc已涂漆的表面，确保是许可的涂层，并保证表面清洁干燥混凝土表面：无可见水，无油污等污物Limitations 限制 Please mix and stir still to even before application, during the application, the temperature of the environment should be above 10, the relative humidity should be less than 80%, the Substrate temperature should be more than 3 above the dew point, enough ventilation is necessary at the application site.The front coatings: water-miscible or others paint which is permitted.The durability of the water-miscible paint is decided by the condition of the application, For example, on the edge and quarter, the application need be handled carefully, avoiding the film thickness is too thick once水性环氧防腐面漆施工及干燥期间，环境温度最好在10以上，相对湿度低于80%，底材温度应高于露点3以上，并保证良好的通风。避免在夜晚温度较低尤其是在兼有凝露或雨水的季节户外施工。前道涂层：水性环氧漆或经许可的溶剂型涂料。水性漆的耐久性在很大程度上取决于良好的施工。比如在尖锐的边角，铆钉和跳焊的部位的施工需额外细，避免每度漆的漆膜太厚。最好额外修涂一遍。Safety Precautions 安全措施This product should be used in painting area by professional operators. When painting, please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product.This product is a kind of solvent-based paint. In order to avoid danger or accident, minimal safety precautions, as follow, should be done.The paint is based on water. In general, this paint has no danger of combustion and explosion. However, enough ventilation is necessary at application site.Because the paint is harmful, product, protect skin and eyes, and avoid touching with paint(Recommended to wear working clothes, gloves, eye protection, face masks, barrier creams and so on). If paint gets in touch with skin, wash fully with a large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately.Recommended face guard with ventilation pipe for the sake of no absorption of paint fog harmful solvent gas, especially in badly ventilated conditions.Handle empty containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions (Refer to the specifications), our company will NOT be responsible for any accident.水性环氧防腐面漆专业人缘在工业场所使用,使用时请参照本说明书及健康安全手册,如客户在使用本产品前,未能仔细了解有关产品的健康安全知识,请与本公司联系。该涂料为相对无害油漆，为避免事故或危险发生，应采取最低限度的安全措施如下：该涂料为水性漆，一般情况下无燃烧和爆炸危险，但应加强通风以改善涂装环境。因漆液并非无害，所以仍应采取有效措施防止皮肤与眼睛与涂料接触（如适用工