污水泵维修.doc

伽利略Galileo泵-欧洲品质污水泵维修以下几款污水泵维修资料供施工方或用户参考维修【AS型撕裂式潜水排污泵】检查与维修： 本系列泵产品性能优良，运行可靠，每台泵在出厂前都进行了严格的出厂检测，永久润滑的球轴承以及处于油室运行的优质机械密封使水泵具有最大的耐用性，然而，为了确保水泵的使用寿命，建议进行定期的检查和保养。1、定期检查电泵电动机相间及相对地间绝缘电阻，其应大于2M，否则应拆机检修（行干燥处理）同时检查接地是否牢固；2.叶轮和撕裂机构（底座盖板）之间的间隙为0.30.5，在介质中长期使用之后，此间隙可能由于磨损而增大，此时应予以调整，其方法如下：断电源，松固定螺钉，将盖板旋转一个适当的角度即可恢复原间隙；3、电泵多次使用后必须把电泵放入清水中运行数分钟，防止泵留下沉积物，以保证电泵的清洁；4、电泵在规定的介质中正常运行半年后应检查油室密封状况，更10#30#机油必要时更机械密封件，对于在恶劣工作条件下使用的电泵，应经常检修； 换油方法如下：把泵放置好，使油室螺塞（位于出水口侧）朝下，放出润滑油，然后用洗深油清洗油室，再注入适量的油（约70%80%）再一个新的型圈并将螺塞旋紧。 如油中发现有水奶状乳化液）按规定冲洗油室井重新装油，三个星期后必须重新查一次，如果油又变成乳状液，机械密封件应进行检查，必要时应予更（与我厂维修部接洽，如自己更密封件，须做气密试验（空气压力为0.5kg/cm2)5、万一发生故障，在不能确定原因，且按后面提供的排除方法仍不能解决，清不要取临时凑的办法，更不要私自乱拆乱修，而应与我厂维修部门联系。 AS型无堵塞潜水排污泵价格编号型号规格流量(m/h)扬程(m)功率(KW)转速(r/min)电压(V)配用胶管内径(mm)AS叶轮自耦装置GAK一控一全保自动控制柜配浮球一控二、一用二备全保自动控制柜配浮球1AS10-2W/CB1541.12850220761182192973104316682AS10-2CB154.51.12900380761112192973104316683AS16-2CB297.61.52900380761321192973104316684AS30-2CB421132900380761738192973111216685AS55-2CB45135.5290038012730583521251118218076AS55-4CB1007.55.5145038015233364802085118218077AS75-2CB60187.5290038012737533521251125118778AS75-4CB145107.5145038015238924802085125118779AV14-4225.81.514503807615291929731043166810AV55-230205.52900380100347535213901182208511AV75-230257.529003801004170400139013212085【GW型立式管道排污泵】检查与维修：1.泵在使用前应检查电机绕组对机壳的绝缘电阻，如低于0.5兆欧，刚必须将定子烘干，待绝缘电阻升高后方可使用。2.泵体进口处的叶轮与油封之间间隙如超过2mm时应更换耐磨油封。3.当泵密封出现漏水时，应及时更换密封件，更换时先将静密封装平装实，再将动密封装在轴上即可。4.更换叶轮时，应用拉力器拉出，不能用锤子猛打，以免破坏轴度。YW液下式、LW直立式、GW管道式系列排污泵价格编号型号规格流量(m/h)扬程(m)转速(r/min)YW液下式(单管)YW液下式(双管)YWP液下式(单管)不锈钢YWP液下式(双管)不锈钢LW直立式LWP直立式（不锈钢）GW管道式GWP管道式（不锈钢）125-8-22-1.182228001251139029193364125121967651487232-12-15-1.1121528001432152929893378127922247921529340-15-15-1.5151529001362152930723697130723497921529440-15-30-2.21530290014601557321137951362243383416120550-20-7-0.7520729001195129329193503108419747371432650-10-10-0.75101029001195129329193503108419747371432750-20-15-1.52015290013211460294736561362243383416120850-15-25-2.2152529001515162633643948159925589451682950-18-30-3.018302900165417793503408717382780111221681050-25-32-5.525322900222423634837525421553503/1150-20-40-7.520402900236325024962544921963656/1265-25-15-2.22515290015151654336439481640262794518491365-37-13-3.037132900184919884087482317102780109822801465-25-30-4.025302900205722244670496217792919152924881565-30-40-7.5304029002433257251155991/1665-35-50-11355029004448472665336950/1765-35-60-15356029004726486569507506/1880-40-7-2.24071450177919183948467017382780118222941980-43-13-3.043132900200221274531467018903211132125302080-40-15-4.04015290020852252453152541946343315329192180-65-25-7.5652529002641285055606130243343092085394822100-80-10-4801014502113230746704712257245312085394823100-110-10-5.51101014502780291958385991269745312224424024100-100-15-7.51001514502919304461307006312855742363460125100-80-20-7.5802014502919304461307006312855742363460126100-100-25-11100251450468448931036911245507488964031781227100-100-30-15100301450528254771182912413569996334587891028100-100-35-18.5100351450581059491241312788597710217521311245编号型号规格流量(m/h)扬程(m)转速(r/min)YW液下式(单管)YW液下式(双管)YWP液下式(单管)不锈钢YWP液下式(双管)不锈钢LW直立式LWP直立式（不锈钢）GW管道式GWP管道式（不锈钢）29125-100-15-11100151450357237817881817356431011947681021730125-130-20-1513020145053385546118291241362551167652821021731150-145-9-7.51459145038924170828484655310103694406817332150-180-15-1518015145054915685118571246866721313655601080033150-180-20-18.518020145058106074128441401182011605566721292734150-180-25-2218025145067427006150401605591741809877841504035150-130-30-2213030145067427006150821605591741809877841504036150-180-30-301803014507923818717514183901035620141104251971037150-200-30-37200301450123571259326271267161056424228110782165638200-300-7-11300798066037006145951576380621605562551212139200-250-11-152501198080628451180011839096191926569921342740200-250-15-18.525015145085908854192651955797301955797301679141200-400-10-22400101450886892442004420336101472000299661722242200-400-13-304001314509640990422045223371112022184116761926543200-300-15-22300151450884792442000220294112591999599661722244200-250-22-3025022145096401003622045223371237122184118151926545200-350-25-3735025145099041030021893230601251021893132052554146200-400-30-45400301450102031046723352236581435924812143172627147250-600-9-306009980171671769536488379471668029774139002627148250-600-12-37600121450198082033640866423261876533430152902919049250-600-15-45600151450211282165643785452451993333680159853094150250-600-20-55600201450231092363048164499152015535751173753371451250-600-25-75600251450250902561852542544392293540866191823283952300-800-12-45800121450215592201845245462182182338531169163308253300-500-15-45500151450222894374347872503602192038531169163308254300-800-15-5580015980239914532849623554612293540866189323516755300-600-20-5560020980237692442951083532792571543785236304582856300-800-20-7580020980264102707755461576572710548316250204860157300-950-20-90950209803001030677/33402/编号型号规格流量(m/h)扬程(m)转速(r/min)YW液下式(单管)YW液下式(双管)YWP液下式(单管)不锈钢YWP液下式(双管)不锈钢LW直立式LWP直立式（不锈钢）GW管道式GWP管道式（不锈钢）58300-1000-25-1101000259803750238156/44383/59300-1100-10-551100109802588226549/29287/60350-1500-15-901500159803499335654/41283/61350-1200-18-901200189803499335654/41283/62350-1100-28-1321100287405193052820/53279/63350-1000-36-1601000367405503055892/58755/64400-1760-75-551760755804050541825/36376/65400-1500-10-751500109802962130941/47719/66400-2000-15-1322000157405318154502/60785/67400-1700-22-1601700227405793559256/63245/68400-1500-26-1601500267405793559256/65469/69400-1700-30-2001700307406216163481/72447/70400-1800-32-2501800327407121072530/79786/71500-2500-10-110250010740/72500-2600-15-160260015740/73500-2400-22-220240022740/74500-2600-24-250260024740/【WQK/QG系列切割式潜水排污泵】维修与保养： 1. 电泵应有专人管理与使用，并定期检查电泵绕组与机壳之间的绝缘电阻是否正常最低不得低于0.5兆欧，否则必须拆下将定子烘干，绝缘电阻升高后方可使用。2. 每次使用特别是用于较稠较粘的浆液后，应放于清水中运行数分钟再存放。3. 电泵每使用300500小时后应打开腰部油孔螺钉并用纯净10号机油补充，使用机械密封保持良好的润滑状态。如发现油室大量进水则表明机械密封失效，应予更换。4. 电泵启动后如发现流量不足或扬程达不到规定值（除管路阻力大或堵塞)可能是转向反了，这时应断开电源，将电缆的三根相线中任意二根相互对换后，量新接好再启动便可。5. 电泵拆卸、维修后，密封性能必须经0.2MPa气密试验检查。6.弯头和电泵分离放在板箱内，请将弯头装在电泵上，如果电果和管道连接则不必再装弯头。 WQK高效无堵塞带切割装置型及带刀型污水污物潜水泵价格编号型号规格流量(m/h)扬程(m)出水配管口径(mm)功率(KW)转速(r/min)普通型带刀装置1 WQK8-12812320.7529001029 1529 2 WQK25-6256800.751450 1043 1557 3 WQK20-720 7 50 1 1450 1029 1543 4 WQK10-1210 12 40 07514501029 1543 5 WQK10-121012401.114501126 1626 6 WQK8-22822251.114501140 1654 7 WQK20-1520 15 50 15 1450 1237 1738 8 WQK15-3015304 2.214501321 1835 9 WQK20-202020 50 2214501334 1849 10 WQK25-15251565221450 1348 1863 11 WQK40-740 7802.214501738 2252 12 WQK30-30303080329001793 2294 13 WQK30_15301580329001793 2294 14 WQK25-302530 65429001890 2391 15 WQK40-15401580 414502113 2627 16 WQK85-108510100414502127 2641 17 WQK65-25652580 7.529002780 3433 18 WQK20-602060807.529003419 3920 19 WQK80-208020807.514502877 3461 20 WQK100-15100 151007.514502947 3531 21 WQK130-10130 10 150 7514503628 4212 22 WQK100-25100251501114504629 5199 23 WQK115-15115151251514505254 5977 24 WQK180-15180 151501514505352 6088 25 WQK100_4010040 100151450 5518 6241 【QW(WQ)系列无堵塞潜水排污泵】维护与保养： 1.电泵应有专人管理与使用，井定期检电泵绕组与机壳之间的绝缘电阻是否正常。2.每次使用特别是用于较稠较粘的浆液后，应将电泵放入清水中运转数分钟，防止泵内留下沉积物，保证电泵的清洁。3，电泵如长时间不用时应将电泵从水中取出，不要长期浸泡在水中，以减少电机定子绕组受潮的机会，增加电泵的使用寿命。4.在常规状态下泵每使用300-500小时后应加注或更换油室中机油（10-30号机油）使机械密封保持良好的润滑状态，提高机械密封的使用寿命。5，电泵拆卸、维修后，机壳组件必须经0.2MPa气密试验检，以确保电机密封可靠。6，叶轮和泵体之间的密封环具有密封功能，如密封损坏将直接影响到泵的性能，必要时应更换。 声明：由于产品一直在更新，本文中所有文字、数据、图片均只适用于参考 WQ、QW系列潜水式排污泵价格编号型号规格流量(m/h)扬程(m)转速(r/min)WQ(铸铁)WQP(普通不锈钢)WQP(304不锈钢)WQP(316不锈钢)自动耦合装置铸铁叶轮不锈钢叶轮带循环水装置125-8-22-12224 2711 4309 /64 240 /232-12-15-1.112152800904 2224 2711 4309 /64 240 /340-15-15-15151529001043 2919 3475 5560 /80 256 /440-15-30-2.2153029001251 2919 3614 5769 /80 256 /550-20-7-0.752072900765 2085 2641 4240 /96 288 /650-10-10-0.7510102900765 2085 2641 4240 /96 288 /750-20-15-1.5201529001043 2919 3475 5560 /96 480 /850-15-25-2.2152529001084 3058 3614 5769 834 96 480 /950-18-30-30183029001529 3475 4170 6672 834 96 480 /1050-25-32-5.5253229002294 4587 5560 8896 834 112 640 /1150-20-40-7.5204029002641 4726 5699 9105 834 160 768 /1265-25-15-22251529001321 3336 4031 6464 834 96 480 /1365-37-13-30371329001599 3614 4309 6881 834 112 512 /1465-25-30-4.0253029001738 4170 4587 7367 834 128 528 /1565-30-40-75304029002641 5560 6672 10703 973 240 768 /1665-35-50-11355029003962 9313 11120 17792 973 256 960 /1765-35-60-15356029004365 9730 11676 18626 973 256 960 /1880-40-7-2.240714501390 3614 4309 6881 973 128 768 /1980-43-13-3.0431329001599 4031 4865 7784 973 128 768 /2080-40-15-40401529001738 4309 5143 6950 973 144 800 /2180-65-25-7.5652529002641 5560 6672 10703 1112 208 880 /22100-80-10-4801014502294 5352 6394 10217 1390 160 880 /23100-110-10-5.51101014502502 6533 7784 12441 139 240 960 /24100-100-15-7.51001514502780 6672 7923 12649 1390 240 960 /25100-80-20-7.5802014502780 6672 7923 12649 1390 240 960 /26100-100-25-111002514503892 9730 11676 18626 1390 272 1040 /27100-100-30-151003014504490 10286 12232 19460 1390 320 1120 /28100-100-35-18.51003514505282 11120 13344 21267 1390 320 1120 /编号型号规格流量(m/h)扬程(m)转速(r/min)WQ(铸铁)WQP(普通不锈钢)WQP(304不锈钢)WQP(316不锈钢)自动耦合装置铸铁叶轮不锈钢叶轮带循环水装置29125-130-15-111301514504101 11259 1390 22240 2224 320 1120 /30125-130-20-151302014504684 11398 14317 22935 2224 320 1120 /31150-145-9-7.5145914503197 8479 9730 /2224 320 800 /32150-180-15-151801514504823 11537 13205 /2224 320 960 /33150-180-20-18.51802014505838 13344 15290 /2224 320 960 973 34150-180-25-221802514506533 14873 15985 /2224 352 1120 9841 35150-130-30-221303014506533 14873 15985 /2224 352 1120 9869 36150-180-30-301803014508062 17931 /2224 400 1280 11815 37150-200-30-3720030145010967 27522 /2224 400 1280 13205 38200-300-7-1130079805560 15290 /3058 320 1120 8062 39200-250-11-15250119805838 15568 /3058 320 1120 9035 40200-250-15-18.52501514506672 17653 /3058 400 1280 8340 41200-400-10-224001014507506 18348 /3058 400 1280 9035 42200-400-13-3040013145010008 /3058 400 1280 9035 43200-300-15-223001514507506 /3058 400 1280 9035 44200-250-22-3025022145010008 /3058 400 1280 11120 45200-350-25-3735025145011495 /3058 480 1440 13205 46200-400-30-4540030145013872 /3058 480 1440 22240 47250-600-9-30600998015290 /3892 880 2400 20850 48250-600-12-3760012145017375 /3892 880 2400 24325 49250-600-15-4560015145021545 /3892 880 2400 29190 50250-600-20-5560020145024325 /3892 880 2400 34750 51250-600-25-7560025145029190 /3892 960 2720 38920 52300-800-12-4580012145023630 /5421 960 2720 34750 53300-500-15-4550015145023630 /5421 960 2880 34750 54300-800-15-558001598024325 /5421 960 2880 37530 55300-600-20-556002098025020 /5421 1920 4000 37530 56300-800-20-758002098038920 /5421 2400 4800 43785 57300-950-20-909502098041700 /5421 2400 4800 53515 编号型号规格流量(m/h)扬程(m)转速(r/min)WQ(铸铁)WQP(普通不锈钢)WQP(304不锈钢)WQP(316不锈钢)自动耦合装置铸铁叶轮不锈钢叶轮带循环水装置58300-1000-25-11010002598043090 /5421 2400 4800 66720 59300-1100-10-5511001098025715 /5421 2400 4800 37530 60350-1500-15-9015001598048650 /6255 2560 /70890 61350-1200-18-9012001898050735 /6255 2560 /70890 62350-1100-28-13211002874062550 /6255 2560 /80620 63350-1000-36-16010003674070890 /6255 2560 /86180 64400-1760-7.5-5517607558052820 /7645 3200 /56990 65400-1500-10-7515001098050735 /7645 3200 /48650 66400-2000-15-13220001574065052 /7645 3200 /87570 67400-1700-22-16017002274075755 /7645 3200 /86180 68400-1500-26-16015002674075755 /7645 3200 /86180 69400-1700-30-20017003074085485 /7645 3200 /94520 70400-1800-32-25018003274089655 /7645 3200 /97300 71500-2500-10-11025001074090350 /13900 4000 /72500-2600-15-16026001574098690 /13900 4000 /73500-2400-22-220240022740108420 /13900 4000 /74500-2600-24-250260024740115370 /13900 4000 /【YW型液下排污泵】维护保养： 1.水泵应有专人管理与使用.并定期检水泵的电路和水泵工作是否正常。2.每次使用特别是用于较稠较粘的浆液后.应将水泵放在消水中运转数分钟.防止泵内留下沉积物.保证水泵的洁。3.在常规状态下.泵每使用300-500小时后应加注或更换油室中机油（10-30#机油）.使机械密封保持良好的润滑状态.提高机械密封的使用寿命。4.叶轮和泵体之间的密封环具有密封功能.如密封环损坏将直接影响泵的性能.必要时应更换。 YW液下式、LW直立式、GW管道式系列排污泵价格编号型号规格流量(m/h)扬程(m)转速(r/min)YW液下式(单管)YW液下式(双管)YWP液下式(单管)不锈钢YWP液下式(双管)不锈钢LW直立式LWP直立式（不锈钢）GW管道式GWP管道式（不锈钢）125-8-22-1.182228001251139029193364125121967651487232-12-15-1.1121528001432152929893378127922247921529340-15-15-1.5151529001362152930723697130723497921529440-15-30-2.21530290014601557321137951362243383416120550-20-7-0.7520729001195129329193503108419747371432650-10-10-0.75101029001195129329193503108419747371432750-20-15-1.52015290013211460294736561362243383416120850-15-25-2.2152529001515162633643948159925589451682950-18-30-3.018302900165417793503408717382780111221681050-25-32-5.525322900222423634837525421553503/1150-20-40-7.520402900236325024962544921963656/1265-25-15-2.22515290015151654336439481640262794518491365-37-13-3.037132900184919