钢铁常用专用英语词汇.doc

热轧生产常用专用英语词汇2008-12-29 09:53Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额定扭矩Voltage 电压Process computer 过程计算机Program 程序，编程PLC： programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动模式Semi-auto model 半自动模式Manual model 手动模式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O： input/output 输入/输出端口Step control 卷取机助卷辊的“踏步”控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 泄漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理性能Mechanical performance 机械性能Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板（卷）SPHD 深冲级热轧钢板（卷）SPCC 普通级冷轧钢板（卷）SPCD 深冲级冷轧钢板（卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处理Aging 时效处理Annealing 退火Quenching 淬火Other Alarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月Day 日Shift 班Safety 安全Radioactive hazard 放射性伤害Caution 注意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hesss law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoults law亨利定律Henrys law纯物质标准态pure substance standard质量溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Ficks 1st law of diffusion菲克第一扩散定律Ficks 2nd law of diffusion扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygenfurnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS住友复合吹炼法Sumitomo top and bottom blowing process,STBLBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping铸铁cast iron熟铁wrought iron电解铁electrolytic iron白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron半可锻铸铁semi-malleable cast iron奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel易切削钢free-machining steel耐磨钢abrasion-resistant steel工具钢tool steel高速钢high-speed steel冷作模具钢cold-work die steel热作模具钢hot-work die steel钢筋钢reinforced bar steel钢轨钢rail steel轮箍钢type steel管线钢pipe line steel锅炉钢boiler steel电工钢electrical steel-shaped segregation倒V形偏析-shaped segregation V形偏析1 mass% solution standard质量溶液标准(态)abrasion resistance耐磨损性abrasion-resistant steel耐磨钢absorption吸附absorption吸收accelerated melting by coal-oxygen burner氧煤助熔acid open-hearth furnace酸性平炉acid oxide酸性氧化物acid refractory material 酸性耐火材料acid slag酸性渣activation energy活化能activity coefficient活度系数activity活度addition reagent添加剂adiabatic process绝热过程adjustable mold调宽结晶器after blow后吹agglomeration团聚aim carbon目标碳air bottom-blown acid converter酸性空气底吹转炉air bottom-blown basic converter碱性空气底吹转炉air gap空气隙air mist spray cooling气水喷雾冷却akermanite镁黄长石Al2O3-SiC-C brick氧化铝-碳化硅-炭砖alumina carbon brick 铝炭砖alumina chrome brick铝铬砖alumina magnesia brick铝镁炭转alumina氧化铝aluminium bullet shooting, ABS 铝弹脱氧法aluminosillicate refractory硅酸铝质耐火材料aluminothermic process, thermit process铝热法amorphous carbon无定形碳amphoteric两性氧化物andalusite红柱石andradite钙铁榴石anion阴离子annual mine output矿山年产量anode阳极anorthite钙长石apparent activation energy表现活化能arc bias 偏弧argon-oxygen decarburization process, AOD氩氧脱碳法Arrhenius equation阿伦尼乌斯方程arrival at mine full capacity矿山达产Arved lance carbon injection process, ALCI顶枪喷煤粉炼钢法asbestos石棉ASEA-SKF process电弧加热电磁搅拌钢包精炼法austenitic cast iron奥氏体铸铁austenitic stainless steel奥氏体不锈钢back pour, back feeding补浇bainitic cast iron贝氏体铸铁baling of scrap废钢打包ball growth by assimilation生球长大同化机理ball growth by coalescence生球长大聚合机理ball growth by layering生球长大成层机理ball mill球磨机balling disc圆盘造球机balling drum圆筒造球机balling index for iron ore concentrates精矿成球指数banking for coke oven焦炉焖炉barite重晶石basic open-hearth furnace碱性平炉bas