鞋类产品缺陷中英对照.doc

鞋类产品品质不良英文描述一般缺点Defect Abrasion磨损 Angle on insole中底发角 back height 后跟高度 Back strap too high(low,long,short)后拉带太高 bottom dirty大底不洁 Broken thread断线 Cement on heel鞋眼沾胶 Cementing comes off脱胶 Cementing no good接着力不佳 chip碎屑 Cleanness not enough清洁度不佳 Color not matching色差 Color variation色差 Crooked back stay 后套歪斜 Crooked upper鞋面弯曲 Crooked屈曲,不平顺 Damaged upper鞋面破损 dirty 脏的 Flatten变平 gaping 缝隙 get mildew发霉 Gore too weak松紧带弹性不佳 hairy 起毛 Heel not straight后套不正 Lasting off center攀歪 Loose thread脱线 Not in pair不配双 Outsole not smooth大底不平 over cemented溢胶 Pinch in 缩进去 Rough粗糙 Shank not straight铁心不正 Shank too loose铁心太松 smeary污染 sole adhesion大底欠胶 Sole come off底脱胶 Sole laying not proper(centered)贴底不正确 Stitching not even车不平均 Stitching not on the mark不照记号齿车 Toe broken down鞋头凹陷 Tricot shows up特丽可得露出来 Trun yellow变黄 Turn dark变黑 Vamp length鞋头大小 Vamp open up鞋面掀开 Vamp split off 鞋面爆开 Vamp wrinking鞋面皱纹 Wrapping not even攀帮不均匀 Wrapping not tight攀帮不紧 Wrong colour颜色错误 Wrong cutting裁断错误 Wrong last 楦头错误 PPER DEFECT CATEGORY - UCOUNTER DEFECTS - CO 後套瑕疵1. Counter sheet not lasted under insole.港寶片未拉到中底上2. Wrinkled counter caused either by poor lasting or by wrinkled chemical sheet. 拉幫不良或港寶片皺造成起皺。3. Soft chemical sheet due to wrong material or wrong primer.港寶片品質不良或處理不良導致港寶片發軟。4. Crooked chemical sheet.港寶片位置歪斜5. Low positioned chemical sheet.港寶片位置太低6. Blisters on counter.後套有氣泡7. Back height not uniform within pair by 2.0-mm or more.後套高度不一致達2mm或更多8. Other counter defects.其它後套瑕疵CROOKED UPPER DEFECTS - CU鞋面歪斜瑕疵1. Topline crooked or wavy.鞋領口彎曲或呈波浪狀2. Back seam off center, twisted or not vertical to heel seat by 2.0-mm.後套合縫線不正，偏離中線、扭曲或美與底垂直，偏離達2mm3. Back heights not uniform within pair.左右腳後套高度不一致4. Different vamp length of left and right foot over 2.0-mm. 左右鞋面長度不同，相差超過2mm5. Crooked upper caused by mis-stitching of moccasin construction.手縫馬克線跳針造成鞋面不正6. Crooked open toe in sandal construction.涼鞋前趾不正7. Other crooked upper defects.其它鞋面歪斜瑕疵COLOR VARIATION DEFECTS - CV色差瑕疵1. Poor antique treatment.銹色處理不良2. Color variation between different pieces of upper.鞋面不同部位色差3. Color of stitching and upper material not matching(as per conformation sample.)車線顏色與鞋面材料顏色不配4. Wrong color on ornaments and lace.裝飾配件以及鞋帶顏色不對5. Variation between left and right shoe.左右腳色差6. Poor printing and embroidery.鞋面不良印刷或赤繡7. Contrast color of PU coaling and backing fabric.PU裡及布裡呈對比色8. Other color variation defects.其它色差瑕疵DAMAGED UPPER DEFECTS - DU鞋面損壞瑕疵1. Scratch mark on upper.鞋面刮痕2. Visible roughing marks more than 1.5-mm or conspicuous.看得見的磨粗超過1.5mm或顯眼3. Cut upper.鞋面破裂4. Torn upper caused either by high stitch density or poor reinforcement. 因不良補強或車線針距太密造成鞋面破裂5. Poor heat embossing.高溫壓花不良6. Toe box collapsing.鞋頭熱熔膠或港寶塌陷7. Missing or incorrect material embossment.鞋頭壓紋消失或不正確8. Loose or missing ornament parts.裝飾配件遺失或松動9. Broken strap.前帶或後帶斷裂10. Other damaged upper defects.其它鞋面損壞瑕疵EYELET AND LACE DEFECTS - EL鞋眼和鞋帶瑕疵1. Punched bigger or smaller than eyelet.鞋眼跟打洞不合2. Poor eyelet attachment.鞋眼釘合不良3. Loose eyelet.鞋眼松脫4. Paint coat peeling off.鞋眼的漆層脫落5. Rust on eyelet or other metal buckles.鞋眼或其它金屬扣生銹6. Laced wrong for easy try on.鞋帶拉力不良7. Wrong length,(need ton lace up the measure for length) 鞋帶長度不對8. Wrong color, wrong material , or wrong type of lace.鞋帶顏色、材質、型式不對9. Broken yam.斷紗10. Eyelet row not uniform by 2.4-mm.鞋眼排列不整齊，偏離2.4mm11. Dirty marks on lace.鞋帶有不潔記號12. Shoelaces tied together.左右腳鞋帶系在一起13. Other eyelet and lace defects.其它鞋眼或鞋帶瑕疵LINING DEFECTS(Includes vamp, sock, and counter lining) - LI內裡瑕疵（包括鞋面、鞋墊、後套裡等）1. Lining dirty, damaged or wrinkled.內裡贓、破損或褶皺2. Trimming damage on topline stitching, causing lining to show gap. 修鞋口裡造成破損導致開口3. Sock lining gap not deeper than 2-mm鞋墊裡位置歪斜達到2mm或超過（鞋墊貼合不良）4. Cementing off, between upper and lining.鞋面與內裡貼合不良5. Poor or unclear markings.不良或不清楚的標記6. Other lining defects.其它內裡瑕疵STITCHING DEFETS-SG 針車瑕疵1. Crooked stitching(out of stitching mark).針車歪斜（偏離港寶片）2. Stitching too close to seam edge.針車太靠近邊距3. High, low, or uneven stitch density.針車太密、太松、或不平均4. Loose or tight stitching.針車太緊或太松5. Skipped stitch on upper.跳針6. Incorrect needle type.不適用的針型7. Incorrect thread size.線的粗細不對8. Open seam.車線接合裂開9. Thread ends.線頭未修剪干淨10. Other stitching defects.其他針車瑕疵UPPER DIRTY-UD鞋面不潔瑕疵1. Glue stain.粘膠痕跡2. Dirty marks.不潔的記號3. High glue line more than 1.5-mm in any area.膠線太高，超過1.5mm或更多4. Frayed edge of PVC/PU upper material. PVC/PU鞋面材料毛邊5. Meld or Mildew.發霉 thread residue线头fading, fugitive color 褪色color shade, off shade, color deviation 色差raw edge leans out of seam毛头 washing quality is not good洗水不良 6. Other upper dirty defects其它鞋面不潔的瑕疵WRINKLED UPPER DEFECTS-WR鞋面皺褶1. Wrinkles caused by poor lasting.拉幫不良造成的皺褶2. Wrinkles caused by poor bottoming.貼底不良造成的皺褶3. Wrinkles caused by distorted upper鞋面變形造成的皺褶4. Other wrinkles upper defects.其它鞋面皺褶瑕疵X-RAY DEFECTS-XR1. X-ray lines on and part of upper showing through due to edge folding, chemical sheet, toe cap, etc.由於拗邊、港寶片、鞋頭包片等引起的任何鞋面部位的透痕2. X-ray lines of upper lasting allowance showing through on bottom due to improper buffing or filler.大底拉幫部位不平順有X-ray透痕產生，由於磨粗不平或填腹不良引起3. Other X-ray defects.其它的X-ray透痕SOLE DEFECTS CATEGOTY-SSOLE BOTTOM SIRTY DEFECTS - BD 大底不潔瑕疵1. Dirty marks.不潔記號2. Poor outsole printing or paint peels off.大底印刷不良或上漆剝落3. Rough edge of EVA outsole.EVA底邊未磨平均（粗糙）4. Impurities in sole material.大底物料不純5. Other bottom dirty defects.其它大底不潔記號SOLE BOTTOM GAPPING DEFECTS - BG大底縫隙瑕疵1. Any gap or small hole at the bottom edge, where the bottom meets the upper. 大底與鞋面開膠2. Toe or heel bumper peeling off at edges.鞋頭包出後包片剝落3. Gapping between midsole and outsole.中底與大底間縫隙4. Gapping between EVA bottom and welt.EVA大底與沿條間出現縫隙5. Gapping between any layered soles.各層底間出現縫隙6. Other sole gapping defects.Critical significant amount of gapping before pulling.嚴重：未拉幫前已有嚴重裂縫出現Major when pulled on, gaps easily.主要：拉底後裂縫立刻呈現.Minor when pulled hard, some gapping.次要：用力拉底縫隙微現SOLE BOTTOM ADHESION DEFECTS - SA大底貼合瑕疵1. Sole easily pulls away from upper during manual examination.經由手力的檢驗，可將鞋面與大底輕易的拉脫2. Sole failed to meet minimum sole-bond-peeling standard after mechanical pull test.經由機械的拉力測試，大底無法達到最低的大底拉力標准HEEL OR TOPLIFT DEFECTS HT鞋跟與天皮瑕疵1. Leaning heel(where the heal itself crooked).鞋跟傾斜（跟本身歪斜）2. Protruding or nail head on heel seat, inside of shoe. (critical)鞋身跟座上釘頭突3. Loose top lift.天皮松脫4. Protruding of nail on heel stem (sticks out of side heel).鞋跟出釘（由鞋旁突出）5. Blister, scratch mark, dirty mark or cut on heel cover.包跟皮有氣泡、刮痕、不潔或破損6. Other heel or top lift defects.其它鞋跟與天皮瑕疵SOLE PLACEMENT/SIZE DEFECTS-PS 貼底位置/貼合號頭瑕疵1. Crooked positioning of outsole more than 2-mm.貼底位置歪斜超過2mm2. Toe spring too high.鞋頭翹度太高3. Other placement/size defects.其它貼底位置或貼合號頭瑕疵PACKAGING PROBKEM TYPE-PKINFORMATION ACCURACY DEFECTS - PA (Critical unless noted)包裝准確度瑕疵1. Wrong size in case錯誤號頭裝入箱內2. Wrong lot# in case.(critical)錯誤的型體號碼裝入箱內3. Mismate不配雙4. Pair shortage. 短裝5. Other packing accuracy defects.其它包裝不正確的瑕疵PRODUCT MARKING DEFECTS - PM (Minor unless noted)產品標識瑕疵1. Product (batch) code wrong.產品批號錯誤2. Product (batch) code missing產品批碼錯誤3. Lot# wrong on product. (Critical)型體號碼錯誤4. Lot# missing on product. (Critical)型體號碼消失5. Missing or wrong bar code ticket on product. (Major)產品價格標簽消失或錯誤6. Shoe ticket in wrong location.價格標簽不正確7. Ticket upside down/sideways (incidental).價格標簽上下或內外顛倒8. Wrong price. (Critical)價格錯誤9. Price ticket curled up (incidental).價格標卷曲10. Wrong data in bar code. (Major)價格標條碼不正確11. Incorrect product labeling.產品標簽使用不當12. Other product marking defects其它產品標識瑕疵13. Missing “TM”or “R”at brand name.不見“TM”或“R”字樣 CASE LABLE MARKING DEFECTS CL外箱貼紙瑕疵1. Wrong alpha or size. (Critical)錯誤的包裝號頭組合2. Missing/illegible alpha or size. (Major)不見或模糊的包裝號頭組合3. Wrong pair quantity. (Major)錯誤的雙數4. Missing/illegible pair quantity. (Major)不見或模糊的雙數5. Wrong lot#. (Critical)錯誤的型體號碼6. Missing/illegible lot#. (Major)不見或模糊的型體號碼7. Wrong PO #. (Critical)錯誤的訂單號碼8. Missing/illegible PO #. (Major)不見或模糊的訂單號碼9. Less than 2 labels per case. (Major) 每一外箱至少2張貼紙10. Applied in wrong position. (Major)外箱貼紙粘貼錯誤11. Carton tape covering the bar code or quiet zone. (Major) 外箱貼紙條碼被透明的封箱帶蓋住12. Bad data in bar code. (Critical)外箱貼紙條碼資料有誤13. Case label bar code not ANSI Grade C or better. (Major)雷射掃描外箱貼紙其結果為非“ANSI Grade”或以上14. Other case label defects. (Minor or Major)其它的外箱貼紙瑕疵SHOE BOX MARKING DEFECTS - SB (Major unless noted) 鞋盒標識瑕疵1. Illegible or wrong lot# on shoe box. (Critical)模糊或錯誤的型號在鞋盒上2. Illegible or wrong size on shoe box.模糊或錯誤的尺碼在鞋盒上3. PCL misplaced.流程控制標貼錯誤 .Bottom edge of PCL over-hanging bottom edge of box.流程控制標凸出盒底 .Bottom edge of PCL more than 10-mm away from bottom edge of box at any point.流程控制標底緣的任一位置高於盒底邊10mm.PCL skewed 11(10-mm) or more.流程控制標歪斜超過11或更多4. Wrinkled or folded PCL.流程控制標皺褶5. Colored exterior layer of box removed, exposing white underlayer in an attempt to reposition an incorrectly applied label. (Minor) 因撕掉及重新貼價標的原因而使鞋盒表層脫落而露出白底層6. PCL missing.沒有流程控制標7. Wrong PCL. (Critical)錯誤的流程控制標8. PCL not ANSI Grade C o