方孚化工减震器烤漆施工工艺.doc

减震器烤漆施工工艺1、 标准工艺条件：环境温度10-36相对湿度80%要求具有良好地通风条件.2、 底材处理：底材必须通过磷化,除油,除尘等工序处理,保证干燥清洁无油污.3、 开油注意事项：FF-83001油用S-014稀释剂稀释,必须严格按照配比进行施工（FF-83001N-50S-014=313.充分搅拌均匀稀释后静置10分钟以上、粘度控制在涂-4杯25、12左右,用200目钢丝或绢丝网过滤方可施工.（调整好地油漆必须在6小时之内用完）个人收集整理 勿做商业用途4、 喷枪及喷涂作业要求：喷枪口径为1.11.3mm,喷涂气压为0.40.6Mpa喷涂距离为2030cm,漆膜厚度控制在1520um为宜.（漆膜厚度会直接影响光泽、附着力、硬度等性能）个人收集整理 勿做商业用途5、 干燥条件：喷涂好地成品必须放置5-10分种流平,方可进行80-100烘烤.烘半个小时冷却后检测性能合格即可包装.个人收集整理 勿做商业用途备注：油漆在80-90度烘烤下可以配比3：1：3.油漆在90-100度烘烤下可配比4：1：4,固化剂比例量会适当影响油漆光亮度.个人收集整理 勿做商业用途注意事项：1、 油漆及稀释剂均应密封贮存于阴凉干燥处远离火源,贮存期为一年2、 为确保最佳地施工质量,应严格参照该施工细则.慈溪市方孚化工有限公司 销售部版权申明本文部分内容，包括文字、图片、以及设计等在网上搜集整理.版权为个人所有This article includes some parts, including text, pictures, and design. Copyright is personal ownership.个人收集整理 勿做商业用途用户可将本文地内容或服务用于个人学习、研究或欣赏，以及其他非商业性或非盈利性用途，但同时应遵守著作权法及其他相关法律地规定，不得侵犯本网站及相关权利人地合法权利.除此以外，将本文任何内容或服务用于其他用途时，须征得本人及相关权利人地书面许可，并支付报酬.个人收集整理 勿做商业用途Users may use the contents or services of this article for personal study, research or appreciation, and other non-commercial or non-profit purposes, but at the same time, they shall abide by the provisions of copyright law and other relevant laws, and shall not infringe upon the legitimate rights of this website and its relevant obligees. In addition, when any content or service of this article is used for other purposes, written permission and remuneration shall be obtained from the person concerned and the relevant obligee.个人收集整理 勿做商业用途转载或引用本文内容必须是以新闻性或资料性公共免费信息为使用目地地合理、善意引用，不得对本文内容原意进行曲解、修改，并自负版权等法律责任.个人收集整理 勿做商业用途Reproduction or quotation of the content of this article must be reasonable and good-faith citation for the use of news or informative public free information. It shall not misinterpret or modify the original intention of the content of this article, and shall bear legal liability such as copyright.个人收集整理 勿做商业用途版权申明本文部分内容，包括文字、图片、以及设计等在网上搜集整理.版权为个人所有This article includes some parts, including text, pictures, and design. Copyright is personal ownership.个人收集整理 勿做商业用途用户可将本文地内容或服务用于个人学习、研究或欣赏，以及其他非商业性或非盈利性用途，但同时应遵守著作权法及其他相关法律地规定，不得侵犯本网站及相关权利人地合法权利.除此以外，将本文任何内容或服务用于其他用途时，须征得本人及相关权利人地书面许可，并支付报酬.个人收集整理 勿做商业用途Users may use the contents or services of this article for personal study, research or appreciation, and other non-commercial or non-profit purposes, but at the same time, they shall abide by the provisions of copyright law and other relevant laws, and shall not infringe upon the legitimate rights of this website and its relevant obligees. In addition, when any content or service of this article is used for other purposes, written permission and remuneration shall be obtained from the person concerned and the relevant obligee.个人收集整理 勿做商业用途转载或引用本文内容必须是以新闻性或资料性公共免费信息为使用目地地合理、善意引用，不得对本文内容原意进行曲解、修改，并自负版权等法律责任.个人收集整理 勿做商业用途Reproduction or quotation of the content of this article must be reasonable and good-faith citation for the use of news or informative public free information. It