第四组.塑料低温脆化温度测试PPT课件

1,塑料低温脆化温度测试,高分子091-2第四组49-53主讲50赖芬素,测试标准：GB/T5470-2008,2,主要内容,ClicktoaddTextClicktoaddTextClicktoaddText,测试原理,仪器设备,低温脆化试验仪及其主要部件和结构,制样,操作步骤,结果表示,影响因素,3,脆化温度：在规定试验条件下，试样破坏概率为50%时的温度，以Tb表示塑料脆化温度的测定：就是塑料试样在规定的受力变形的条件下，测出其显示脆化破坏时的温度。,4,测试原理：,将一组试样以悬臂的形式固定在仪器的夹具上，并置于精确控制温度的低温介质中恒温，当达到某一预定的温度后，用规定的试验速度冲击试样，使试样沿规定半径的夹具下钳口圆弧弯曲成90，而后观察记录整组的试样破坏的百分数。通常把试样破坏概率为50%时的温度定义为脆化温度，用t50表示。,5,仪器设备,试验机：主要由低温浴、搅拌器、试样架装置、试样夹具和冲锤构成，冲锤与试样和夹具之间的关系应符合以下规定。1.冲锤：由马达、电磁离合器或其他适宜形式的装置驱动。冲击刀刃与试样夹具之间的尺寸关系如图1所示。,图1冲锤刀刃和夹具装置的尺寸关系,6,2.试验机的主要技术条件冲锤刀刃半径为1.6mm0.1mm。夹具下钳口圆弧半径为4.0mm0.1mm。冲锤刀刃的外侧与夹具之间的间隙为2.0mm0.1mm。锤刀刃冲击点与夹具之间相距为3.6mm0.1mm。冲击时和冲击后5mm范围内试验速度为200cm/s20cm/s。,7,低温脆化试验仪及其主要部件和结构,8,传热介质：在试验温度下，对试样没有影响，并能保持流动性的液体都可以使用。注1：传热介质可以是乙醇、甲醇、二氯二氟甲烷等。制冷剂可以是固体二氧化碳、液氮等。注2：试验温度在203K（70）以上推荐用工业乙醇（纯度约95）与固体二氧化碳的混合物。乙醇应经常更换，若有争议时，用新乙醇进行试验。,9,制样,试样制备采用试样切割机,表面应平坦、光滑，无气泡、裂纹和其他明显的肉眼可见缺陷。试样:长20.0mm0.25mm，宽2.5mm0.05mm，厚20.0mm0.25mm。每个试验温度点取30条试样，求取脆化温度的温度点数不得少于4点（用计算法求脆化温度应包括试样全破坏和不破坏的温度，用图解法则不包括这两点的温度）,20.0mm0.25mm,20.0mm0.25mm,2.5mm0.05mm,10,测试,根据相关资料，选取合适的温度点进行测试，标准中规定要至少选取4个温度点上进行测试，并使这些温度点在10%90%的试样破环范围内都有分布。每个温度点至少要测25个试样，记下每个温度点试样破坏百分数。,11,操作步骤,1.开动试验机的搅拌器，在低温浴内加入适量制冷剂和液体传热介质，使浴温达到所需试验温度的0.5K范围内（浴内液面距离顶部约30mm）。,4.启动试验机的冲锤，冲击试样。,2.将试样固定在夹具中，然后置于试验机的试样的试样架上固定。注：切口试样，使试样侧面正中的切口位于与夹具下钳口圆弧相切的位置上。,3.将试样架装置浸没在控制到所需试验温度的液体传热介质中保温3min。,5.从低温浴中取出试样，记录破坏试样数目，以试样冲成两段记为破坏。,6.每次调节好所需试验温度，重复步骤2至步骤5的操作步骤，直至求出温度点数不少于4点的试样破坏百分率。,12,注1：计算法温度点应包括不破坏和全破坏两温度点，而图解法则不包括这两点。点间温度应间隔均等。注2：开始试验时，先在预计的脆化温度下进行试探试验，若试样破坏与不破坏同时存在，则每次分别提高或降低温度5K10K，直至出现全破坏与不破坏的温度。然后以二者的温度范围分成均等的2K或5K间隔进行试验，求取脆化温度。,13,结果表示,计算法,用每个试验温度下的试验破坏数目计算试样破坏百分率，然后按下式求取脆化温度：式中：Tb脆化温度，K；Th全部试样破坏的最高温度（应使用正确的代数符号），K；T均匀升温的增量，K；S每个试验温度点试样破坏百分数的总和（包括从不破坏的温度到全破坏的温度到全破坏温度的破坏百分数的总和）。,14,在概率坐标纸上以每个试验温度点的温度与对应的破坏百分率作图，并通过各点划一条最佳直线，取50%破坏概率与直线相交点所对应的温度作为脆化温度。,图解法,15,影响因素,1.式样模塑条件和制备方法：式样表面有微小的划伤或不光滑，都使脆化温度提高。式样厚度较厚，也使脆化温度提高。2.冲头的打击速度速度高，则脆化温度高，反之则低,16,ThankYou!,THEEND,17,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,ClicktoaddText,ClicktoaddText,ClicktoaddText,ClicktoaddText,ClicktoaddText,Contents,18,HotTip,HowdoIincorporatemylogotoaslidethatwillapplytoalltheotherslides?OntheViewmenu,pointtoMaster,andthenclickSlideMasterorNotesMaster.Changeimagestotheoneyoulike,thenitwillapplytoalltheotherslides.,ImageinformationinproductImage:www.photosclub.co.krNotetocustomers:ThisimagehasbeenlicensedtobeusedwithinthisPowerPointtemplateonly.Youmaynotextracttheimageforanyotheruse.,19,Diagram,Addyourtitleinhere,Addyourtitleinhere,Addyourtitleinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,20,Diagram,Descriptionofthecontents,Descriptionofthecontents,DescriptionofthecompanysproductsDescriptionofthecompanysbusinessDescriptionofthecompanystechnologyDescriptionofthecompanyscontents,DescriptionofthecompanysproductsDescriptionofthecompanysbusinessDescriptionofthecompanystechnologyDescriptionofthecompanyscontents,21,Diagram,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,22,Diagram,AddYourText,AddYourText,AddYourText,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,23,Diagram,Addyourtitleinhere-Yourtextinhere-Yourtextinhere,Addyourtitleinhere-Yourtextinhere-Yourtextinhere,Addyourtitleinhere-Yourtextinhere-Yourtextinhere,Addyourtitleinhere-Yourtextinhere-Yourtextinhere,24,Diagram,Textinhere,Textinhere,Textinhere,Title,Title,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,25,Diagram,Textinhere,Textinhere,Textinhere,Addyourtitleinhere,26,Diagram,AddYourText,AddYourText,AddYourText,AddYourText,27,Diagram,AddyourtextinhereYourtextinhereYourtextinhereYourtextinhereAddyourtextinhereYourtextinhereYourtextinhereYourtextinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,28,Diagram,Textinhere,01.TitleAddyourtextinhereAddyourtextinhereAddyourtextinhere,02.TitleAddyourtextinhereAddyourtextinhereAddyourtextinhere,03.TitleAddyourtextinhereAddyourtextinhereAddyourtextinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,29,Diagram,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Yourtextinhere,Yourtextinhere,Yourtextinhere,AddyourtextinhereYourtextinhereYourtextinhereYourtextinhere,AddyourtextinhereYourtextinhereYourtextinhereYourtextinhere,AddyourtextinhereYourtextinhereYourtextinhereYourtextinhere,30,Diagram,Textinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Textinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Textinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Textinhere,Textinhere,Textinhere,31,ProgressDiagram,Yourtextinhere,Yourtextinhere,Yourtextinhere,Yourtextinhere,Yourtextinhere,Yourtextinhere,Textinhere,Addyourtextinhere,Addyourtextinhere,32,BlockDiagram,Textinhere,Textinhere,Textinhere,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,33,3-DPieChart,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,34,3-DPieChart,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Title,Textinhere,Textinhere,Textinhere,Textinhere,35,Diagram,10%,5%,60%,25%,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,YourtextinhereYourtextinhereYourtextinhere,YourtextinhereYourtextinhereYourtextinhere,YourtextinhereYourtextinhereYourtextinhere,ClicktoaddText,YourtextinhereYourtextinhereYourtextinhere,36,Diagram,Text,Text,Text,Text,Text,Text,Text,Text,37,Diagram,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,38,Diagram,Title,Title,Title,ThemeGalleryisaDesignDigitalContent&ContentsmalldevelopedbyGuildDesignInc.,Addyourtextinhere,Addyourtextinhere,Addyourtextinhere,39,Diagram,Title,Title,Addyourtextinhere-Yourtextinhere-YourtextinhereAddyourtextinhere-Yourtextinhere-YourtextinhereAddyourtextinhere,Addyourtextinhere-Yourtextinhere-YourtextinhereAddyourtextinhere-Yourtextinhere-YourtextinhereAddyourtextinhere,40,Diagram,ClicktoaddTitle,ClicktoaddTitle,ClicktoaddTitle,ClicktoaddTitle,ClicktoaddTitle,Them