VESTAS 风机系统检修服务 电气部分

1、VESTAS WIND SYSTEMS A/S KONTROLSKEMA INSPECTION RECORD FORM No.: 946619 Operation/sted: Serviceafd. Titel: V52-850kW eftersyn, elektrisk del. VMP-5000 Ref. No.: 946612 Work/place: Service dep. Item: V52-850kW Check, Electrical Part. VMP-5000 V52-850kW 检修 电气部分946616 Rev. date R Sign. Appd. 000929 1 M

2、BD IHS 010904 2 HHL IHS 031022 3REMI LERA031217 4HESV JFNUdført af / Executed by: Date: IHS 000709 Suppl. tegn./ Drawings. 050706 5 MOBKR MOSVE 6 7 8 9 Godkendt / Approved. FREA Page of1 4 Mølle nr./ WEC no.: No.: Kontrolleret af / Supervisor: Name: Dato/ Date: Date: Bemærkninger p

3、29;føres servicerapport. nr.: Remarks to be recorded in the service rep. no: History of this document: Changes in this revision: Item no: Date: Description of change: 946619.R2 2001-09-04 2.7: F32/Q16 changed to Q7 5.2: Reset counters section deleted Language revision Item no: Date: Description

4、 of change: 946619.R3 2003-10-22 4.4: Redundant tolerance interval on table deleted according to AAAN 1.1: renumbered to 1.2 Some layout corrections Language revision In point 2.7 is Q7 changed to F34A Item no: Date: Description of change: 946619.R4 2003-12-17 2.2: New point added: “Test of UPS syst

5、em”. 2.3: New point added: “AGO2 chopper test”. Item no: Date: Description of change: 946619.R5 2005-07-06 4.4 and 4.5: Text for conditions changed. 中文英文 三个月6 month 1 year 1. 保护 Preconditions 1.2 安全条件. Safety Conditions. 􀂆 􀂆 􀂆 2. 安全部件 Safety Components 2.1 风速， 图一 Wind spee

6、d. Picture 1. m/s 2.2 UPS系统试验（可选） 电池试验Test of UPS system (optional) Battery test UPS test 􀂆 􀂆 􀂆􀂆􀂆􀂆2.3 AGO 2断续试验（可选） 试验 1 频道 1 试验 试验 2 - 频道 2 试验 试验 3 - 频道1&2, 负荷试验 AGO2 chopper test (optional) Test 1 - Channel 1 test Test 2 - Channel 2 test Te

7、st 3 - Channel 1&2, High load test 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆􀂆 􀂆2.4 环境温度 图 6. 齿轮油温度 Ambient temperature. Picture 6 Gear oil temperature -°C-°C2.5 风机迎风偏航 图 1CThe turbine is yawed up-wind. Picture 1C. 􀂆 𙦧

8、0; 􀂆 2.6 跳机试验 Q8. 图 13. Test of Trip Q8. Picture 13. 􀂆 􀂆 􀂆 2.7 紧急停机按纽试验 图 12. S933 在主轴: S934 在偏航盘: S935 在顶部控制柜 S936 在地面控制柜 Test of em. stop buttons. Picture 12. S933 at the Main Shaft: S934 at the Yaw Plate: S935 at the Top Controller: S936 at the Ground Controlle

9、r: 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 2.8 制动试验 图 12 S208: 不管是备用电池否有电，手动紧急按纽启动时，可适用 Test of brake, Picture 12 S208: Applied when manual emergency stop button is activated regardless of battery back-up: &#

10、1048710; 􀂆 􀂆 2.9 备用电池试验. 关掉F34A. 检查制动是否在60-120秒后才可用. Test of battery backup. Switch off F34A. Check that the brake is not applied until after 60 -120 sec. 􀂆 􀂆 􀂆 2.10 振动感应器试验 图 12. S403Test of vibration sensor. Pict. 12. S403 􀂆 􀂆 𙦧

11、0; 2.11 地面控制柜PTS5试验 顶面控制柜PTS5试验Test of PTS5, Ground Controller Test of PTS5, Top Controller 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 2.12 加热风力感应器分线 Heating of the wind sensors branches. 􀂆 􀂆 􀂆 3. 变频Pitch 3.1 11.6试验，无风转向90° Yaw 90° out of t

12、he wind. Test 11.6. 􀂆 􀂆 􀂆 3.2 安装转子锁定系统 试验11.7. Install the rotor locking system Test 11.7. 􀂆 􀂆 􀂆 3.3 负变频中止 试验 11.8 0,040V 0,020V0,060V: Negative pitch end stop. Test 11.8 0.040V 0.020V0.060V: 􀂆 􀂆 􀂆 V 3.4 正变频中止试验 11.8 9,

13、710V 9,690V9,730V: Positive pitch end stop. Test 11.8 9.710V 9.690V9.730V: 􀂆 􀂆 􀂆 V 3.5 液压油温度至少 20°C. 才能进行11.4 试验 Hydraulic oil temperature has to be at least 20°C. Test 11.4 can be used. 􀂆 􀂆 􀂆 °C 3.6 正抵销调整试验 Test 11.9. 1,2°/se

14、k 0,7°/sek 2,1°/sek : Positive offset adjustment Test 11.9. 1.2°/sec 0.7°/sec 2.1°/sec : 􀂆 􀂆 􀂆 °/s 3.7正抵销调整试验11.10. -1,2°/sek -0,5°/sek -1,9°/sek : Negative offset adjust. Test 11.10. -1.2°/sec -0.5°/sec -1.9°/sec

15、 : 􀂆 􀂆 􀂆 °/s 3.8 正流试验. Test 11.11. 10,0°/sek 5,0°/sek 13,0°/sek : Positive flow test. Test 11.11. 10.0°/sec 5.0°/sec 13.0°/sec : 􀂆 􀂆 􀂆 °/s 3.9 负流试验 11.12. -6,5°/sek -4,0°/sek -9,0°/sek : Nega

16、tive flow test. Test 11.12. -6.5°/sec -4.0°/sec -9.0°/sec : 􀂆 􀂆 􀂆 °/s 3.10 正弦试验. Test 11.13. 物理变频 启动变频 Sine test. Test 11.13. Pitch, ActPitch, Ref: Physical pitch: 􀂆 􀂆 􀂆 􀂆 􀂆 􀂆 4. 旋转Rotation 4.1 上风向偏航

17、. 取消服务模式. Yaw up-wind. Leave the service-mode. 􀂆 􀂆 􀂆 4.2 RPM 正弦试验 11.19. 发电机RPM,Act=GenRPM,Ref: RPM sine test. Test 11.19. GenRPM,Act=GenRPM,Ref: 􀂆 􀂆 􀂆 4.3 RPM 逐步试验. Test 11.19. GenRPM,Act=GenRPM,Ref: RPM step test. Test 11.19. GenRPM,Act=GenRPM,

18、Ref: 􀂆 􀂆 􀂆 备注：4.4 、4.5试验仅适用于50米或更高的塔身，且风速大于6.5 m/s.Note: Tests 4.4 and 4.5 are only performed on turbines with 50m towers or higher, when the wind speed is above 6.5 m/s. 4.4发电机过速试验Test 11.21. 参见 “报警RPM操作”. Test of generator overspeed. Test 11.21. Note “Alarm rpm act” 风机型号容量 频率 报警RPM公差􀂆 􀂆 􀂆 V52 850 kW 50 Hz 1950 1910-1990 RPM 60 Hz 2340 2300-2380 R