生产常用单词

1、生产常用单词井口部分Pressure at the outlet of wellhead（井口出口压力）Normal Operating Point(正常工作压力)Trip setpoint跳闸设定压力：high point（高压） Low point （低压）pig launcher 'l:nt （清管器发射器） Capacity(能力)Operating conditions（操作条件）计量站部分Pig receiver and Inlet Manifold（清管接收器和进口汇管）Pressure 'pre at Oil Pig receiver（清管接收器压力）Press

2、ure at Bypass Line of Oil Pig receiver（清管接收器旁路压力）Pressure at inlet manifold（进口汇管压力）Alarm Set point：报警压力设定 Outlet pipe（出口管线）movable'mu:vbl electrici'lektrik heater（移动电加热器） Test Separator'sepreit（计量分离器）Dimensiondi'menn, dai- (尺寸) operating Pressure（操作压力）/temprature（操作温度）/level（操作液位） Al

3、arm Set point(报警液位)oil trunk lines (输油干线) Drain pit(排污坑) Vent pipe (放空管) Pressure at inlet manifold（进口汇管压力）Pig receiver and Inlet Manifold（清管接收器和进口汇管）FPF部分Pig receiver (收球筒) 2-phrase separator（两相分离器）Design conditionskn'din (设计参数) Liquid 'likwid (液相) Booster 'bu:st Pump（增压泵）Inlet pressure

4、(入口压力) Outlet pressure(出口压力)Closed drain drum(闭排分离罐) Electric Rod(电加热棒) Close drain pump(闭排泵) Knockout Pump(分离器泵) Flare knockout 'nkaut drum(放空火炬分离器) Flare Stack SKID（火炬撬） Flare Stack（火炬） Fuel gas trap(燃料气分离器) LPG (液化石油气) Blowers(鼓风机) Water Supply and Sewage water treatment 'tri:tmnt (供水及生活污

5、水处理) Submerged sb'm:dd well pump（井下潜水泵）Septic 'septik concrete kn'kri:t pool (腐化混凝土池)Septic tank (腐化罐) Sewage water pool (污水池)Gas scrubber (气体洗涤器) GAS outlet (气出口)To Flare knockout drum(去气体分离器)To FPF GAS fuel generator 'denreit (去FPF天然气发电机)Diesel 'di:zl fuel 'fjul system(柴油燃料

6、系统)Diesel unload ,n'lud pump(柴油卸料泵) Diesel 'di:zl tank(柴油罐) Diesel feed pump (柴油供给泵) CPF 部分CSO set point (安全阀打开设定压力)Electro pneumatic nju:'mætik poison SP（Self Propelled）（气动阀定位设定压力） inlet trunkline CSO (入口干线安全阀泄压压力)inlet trunk line alarm high pressure(入口干线高压报警压力) heating system（加热系统

7、） pre-heater(预加热器) Tube tju:b pass(管程) Shell pass(壳程) Fuel 'fjul gas pressure(燃料气供气压力)production pru'dkn heater(生产加热器) chemical 'kemikl injection in'dekn system (化学药剂注入系统) anti-foam injection skid(消泡剂注入装置) anti-foam unload pump (消泡剂卸药泵) anti-foam tank(消泡剂储罐) anti-foam injection pumps

8、(消泡剂注入泵) Demulsified injection Skid(破乳装置) Demulsified unload pump (破乳剂卸药泵) Demulsified injection pumps(破乳剂注入泵) 3-phase separator三相分离器 Gas boot(脱气塔)Oil sedimentation ,sedimn'tein tank(原油沉降罐) Oil store st: tank(储油罐) feed and recycle ,ri:'saikl pumps(供油和循环泵) Electromotor temperature 'tempri

9、t (电机温度) Back flow from feed and recycle pumps pressure (循环进罐压力)天然气系统gas scrubber skid (气体洗涤装置) Open level 打开液位 Close level关闭液位Gas compressor Skid 气体压缩机撬 Rated 'reitid flow(额定排量)Suction 'skn Pressure(吸入压力)Discharge dis't:d Pressure(出口压力)/Temperature(出口温度)Inlet safety valve pressure set p

10、oint (入口安全阀泄压) Gas compressor inlet separator(气体入口分离器)1st stage compressor（一级压缩机） 1st stage compressor Suction bottle(一级压缩机入口瓶)MAWP（最高允许工作压力）1st stage compressor discharge bottle(一级压缩机出口瓶)1st stage compressor inter cooler(一级压缩机内冷器)Duty 'dju:ti (负荷) Outlet pipeline pressure（出口管线压力）1st stage Gas c

11、ompressor separator(一级压缩机气体分离器)2nd stage compressor（二级压缩机） 2nd stage Gas compressor separator(二级压缩机气体分离器)drain catch pot(排出液集液罐) Control level(控制液位)：Compressor lube oil Air Cooler (压缩机润滑油空冷器)Oil flow rate(额定流量) rated motor power（额定电机功率）heat Duty (热负荷) Gas production separator (气体分离器) Gas exchanger (

12、气体交换器) Gas pig launcher （气体发球器）produced water treatment system(含油污水处理系统)Skim tank(撇油罐) Slop oil tank(污油罐) Slop oil pump(污油泵) Electric rod(电加热棒) water Injection system(注水系统)Injection Water feed pump (喂水泵) Water injection pump(注水泵) Motor temperature(电机温度)消防及给水系统Fire water tank(消防水罐) / Pump(消防水泵) foam

13、pump(泡沫泵)Electric driven Flare water Pump(电驱动消防水泵) Diesel driven Flare water Pump(柴油驱动消防水泵) Electric driven Foam Pump(电驱动泡沫泵) Diesel driven Foam Pump(柴油驱动泡沫泵)（Standby）Foam proportioning pru'p:n unit skid(泡沫比例混合装置)Electric driven foam unload pump (电驱动泡沫卸料泵) Foam proportioning unit(泡沫比例混合装置) Water

14、 supply pump (供水泵) Pneumatic nju:'mætik tank (调节罐) UV（ultraviolet）purity device(紫外线净化装置) 放空火炬系统 HP（High Pressure）Knockout drum (高压分离器)HP Knockout pump(高压分液排液泵) LP Knockout drum (低压分离器) LP Knockout pump(低压分液排液泵) blower（鼓风机）HP&LP Flare stackage package (高压和低压放空火炬组件)The pressure from gas s

15、crubber (燃料气压力) 其他辅助系统Diesel fuel system (柴油燃料系统) Diesel unload pump(柴油卸料泵) Diesel feed pump (柴油供给泵) Nitrogen 'naitrdn generator package（氮气产生器组件）refrigerant dryer（致冷剂干燥器） Air buffer tank（空气缓冲罐）Activated 'æktiveitid Carbon 'k:bn filter (活性碳过滤器)Adsorber （吸收器） Purity 'pjuriti (纯度)N

16、itrogen buffer tank（氮气缓冲罐） Coalescer filter (聚结剂过滤器)Nitrogen tank（氮气罐） Air compressor （空气压缩机）Instrument 'instrumnt, 'instr-, -ment Air package（仪表风组件） Pre-filter (预过滤器) desiccant 'desiknt dryer (干燥剂干燥器) Dew point 干燥后气露点:-40 After filter (后过滤器)Utility ju:'tilti air receiver(公用空气接收器)Ins

17、trument air receiver(仪表风接收器)Open and Close Drain system(开闭排系统)Open Drain system （开排系统） Open Drain drum(开排罐)Open Drain drum pump(开排罐排液泵) Closed Drain system （闭排系统） Closed Drain drum(闭排罐)Closed Drain drum pump(闭排罐排液泵) Sewage water draining system（生活污水排放系统） 介质Medium 壳重volume 'vlju:m net weight 构造st

18、ructure 静压实验hydrostatic test 最大工作压力maximum 'mæksimm working pressure 设备位号:equipment i'kwipmnt tag number最低设计金属温度:min.design metal temp.筒体/封头厚度:thickness of shell and heads制造测试压力:shop test pressure腐蚀余量:corrosion k'run allowance 'launs制造商名称序列号:manufacturer serial number制造商名称:manuf

19、acturer name 设备重量:fab weight公称通径:nominal 'nminl bore 流道直径:port diameter公称压力:nominal 'nminl pressure排放压力:relieving ri'li:vi pressure 开启高度:opening height适应温度:appropriate 'pruprieit, 'pruprit temperature装置名称: skid name 处理量: capacityk'pæsti设计参数: design parameterp'ræ

20、mit操作参数: operating parameter 指标: index橇尺寸: skid dimension di'menn 气密性实验:leak test体积：volume 'vlju:m 液位计：level gauge 范围：range 编号：serial 石墨填料:graphtte 'ræfait stuffing 'stfi 金属垫片：gasket 'æskit 螺栓：bolt 螺母：nut nt密封环：sealing 'si:li ring O型圈：O shaped Seal Ring轴承：Bearing 轴套

21、: Sleeve sli:v 口环：wear ring机械密封：Machine m'i:n Seal si:l 垫 圈：Washer密封垫：Seal ring 石墨垫：pure pju graphite 'ræfait seal ring耐磨轴承：antifriction bearing 泵体口环：Wear ring stationary 'steinri叶轮口环：Impeller im'pel wear ring 缠绕垫片：Spiral 'spairl Gasket 'æskit名称：Designation ,dezi

22、9;nein 规格型号：Specification/Model备注：Remark 数量：Qty内装式防爆指示灯：pack explosion-proof indicator电流表：Ammeter 'æmit 压力表: Presasure Gauge位液计: Level Gauge内六角搬手：Hexagon 'heksn wrench指示灯：Light 调节螺钉：Adjusting 'dst screw 调压弹簧：Pressure adjusting spring气缸套：Cylinder 'silind liner 电缆：Cables电位器：Potent

23、iometer 旋钮：Knobsnb地脚螺栓: Anchor 'æk bolt 管接: Pipe joint接头: Joint dint 充电机: Charger 蓄电池: Storage battery 'bætri输油软管: Oil hose 放水阀: Water outlet valve保险丝: Fuse fju:z 波纹管: Corrugated 'krueitid pipe8字盲板: blind flange of 8 type金属缠绕垫: steel wind gasket 双头螺柱: stud燃气低压开关: Dungs 空气压力开关:

24、Krom Schroder点火电极: Spark Electrode 程序控制器: Programe controller比例调节仪: ratio 'reiiu, -u controller 球阀: Ball valveY型过滤器: Y-Strainer 液压油和润滑油: Hydraulic Oil &Lubraicating Oil金属软管: Metal Soft line 塑料软管: plastic hose扳手: spanner 扎带: ribbon尼龙管: nylon pipe 5#电池: 5# battery 控制柜钥匙: control cabinet k

25、ey 格兰: grand 法兰: flange 油漆: paint 空滤芯: Empty Filter element油滤芯: Oil Filter element 过滤器滤芯: Filter element填料: Packing Sea 2#锂基脂: 2# Grease机油滤清器: Oil Strainer 柴油滤清器: Fuel Strainer空气滤清器: Air Strainer 不锈钢丝网: S.S Wire 铜丝刷: Wire brush 叶轮密封环: Seal Ring of Impeller发动机皮带: Engine Belts 无油润滑轴承: oil-free lubrica

26、tion bearing指示器: Indicator 阀门密封: Valve Seal活性炭: Active Carbon 阀门密封头: Valve Seal ring熔断器:fuse 信号灯: signallamp 按钮: pushbutton中间继电器: intermediate relay 熔断器: Fuse电流互感器: current transformer红色指示灯: Red indicator light 吸湿器: Moisture absorber互感器: CT 控制器: Controller 加热器: Heater空气开关: Air Switch 单相电流表: Single c

27、urrent instrument控制按钮: Control button 摩擦片: Rub flat 阀座: Vale seat 玻璃管: Glass tube 弹簧: Spring 机油: machine oilabsorberb's:b吸收剂,吸收器,吸收装置 anti 反,反对的,逆arrester除尘器 atmos 大气,大气压bladder气囊,储能器胶囊 booster升压器,调压机,增压器 boot接收器，缓冲立管 buffer 缓冲,缓冲剂,缓冲器 capacity容量，流量 carbon 碳质 coagulation ku,ægju 'lein 集

28、聚,凝结作用,凝聚 coated 包着,涂有,有涂层的 concentrate 'knsentreit集中,浓缩液 diagram 简图,图,图形compressor 空气压缩机,压缩机 content 含量,容积custody 'kstdi保护,监视 demulsifier 反乳化剂,破乳剂 device过载保护装置,装置 discharge 放出,排放 diesel 柴油,柴油机 domestic d'mestik地方的,局部的 drain放液口,排水,排水沟 dryer 干燥机,干燥剂,干燥器 drum 鼓,滚筒,卷筒 DW 静重,蒸馏水,自重 export 出口

29、,输出 emergency i'm:dnsi紧急,紧急事件 equipped 预备,装备，整装 exchanger交换剂,交换器 evaporation i,væp'rein 蒸发,蒸发作用 existing现存的,现有的facility f'siliti工具，设备，设施 FDP 油田开发方案filling 充填,填充物,装满 filter 'filt 过滤器,过滤装置indication ,indi'kein显示,指示 floatation 浮选,浮动generator 'denreit 发电机,发生器 foam泡沫,泡沫状物hatc

30、h井口、门,孔、口 header 汇管,集管,联管箱 hydrant 'haidrnt 水龙头,消防栓,消火栓 hydraulic hai'dr:lik水力的，液压的 injection注入、注射 instrument 工具,仪器 internal 国内的,内部的issued流出的、流出 knockout气液分离器launcher发射器 item 题目,项,项目loop循环，回路 lube 润滑剂,润滑油manifold 管汇 medium 'mi:djm介质,煤介metering 'mi:tri 测量,计量, minor 较小的NC 常闭的,常闭合的,常关的

31、Nitrogen 'naitrdn 氮,氮气 NO常开的,正常打开,环烷油 operating 操作的,工作的pilot 'pailt 辅助的 purify 'pjurifai 净化,使纯净pneumatic nju(:)'mætik气动的,气压的 pond 池,池塘,蓄水池PRE预先的,以前的 pressurize 'preraiz 加压,密封,增压 processing 处理,工艺设计 recycle循环proportionment pr'p:nment比例,定量配制 ROG 地面设备refrigerate ri'fridr

32、eit 冷冻剂,制冷剂 scheme ski:m 草图,示意图,图表 scrubber洗涤器,洗涤塔SDV 关闭阀,应急关闭阀 sediment 'sedimnt 沉淀物separator分离器、离析器 sewage 废水,污水,污物shelter 百叶箱,掩蔽部 sight观测,观察孔skid 打滑,刹车 ,滑移 skim撇取,撇去slop废油,污油 solution s'lju:n溶液stack烟囱 standby 'stændbai备用的storage仓库,储存,储罐 straightener 'streitn矫直器,直管器submerge sb

33、'm:d 浸没,潜水 suction吸入抽水泵supply 供电,供给 suspended s'spendid 悬浮的,悬挂的temporary 'temprri临时的,暂时的 thief 取样,取样器transfer 变换、转移 trunkline 干线,管道干线unloading卸载 utility ju:'tiliti设备,工具，公用设施 vehicle 'vi:ikl媒介物,载体 vent 肛门,孔,通气孔 handwheel 操纵轮,手轮 plug塞子 pneumatically nju:'mætikli由空气作用strain

34、er 'strein 粗滤器,滤网,筛 regulated 调准,稳定阀门类Adjustable 'dstb()l valve调节阀 angle 'ægl valve 角阀basket strainer 'strein 篮式过滤器,笼式滤器butterfly valve 蝶阀 check valve单流阀,止回阀choke valve节流阀,阻流阀 cone valve 锥形阀cylinder 'silind罐,筒,圆筒 diaphragm 'daifræm valve 薄膜阀double acting 双冲程的,双动的 gl

35、oble 球状flame arrestor火焰阻止器,阻火器 motor valve电动阀 needle valve针型阀 solenoid 'sulinid valven.电磁阀Position职位Production Supervisor 'sju:pvaiz 生产监督Production Engineer 采油工程师CPF and FPF Supervisor CPF和FPF监督Instrument 'instrumnt Engineer 仪表工程师Power Plant Supervisor 电站监督Power Plant Engineer 电站工程师Oilfi

36、eld Circuit 's:kit Supervisor油矿线路监督Production Coordinator ku':dineit 采油协调（调度）Maintenance 'meintinns Supervisor 维修监督SCADA Maintenance SupervisorSCADA维护监督LAB and Dehydration ,di:hai'drein Supervisor化验监督Central Processing facilities中心处理设备（CPF）Process flow Diagram工艺流程图AGAA-P-DW-01550 Oil

37、 gathering System 原油储集系统1. V-01510/01520/01530/01540/01550 oil pig receive清管接收器2. M-01590 Inlet manifold 进口汇管3. H-01910 Pre-Heatrs 预先加热炉(器)4. V-01710/01720/01730/01740 Production Separators 生产分离器5. H-01920/01930/01940 Production Heaters 生产加热炉6. F-01750 Gas boot 脱气塔7. T-02010 Oil Sedimentation tank 原

38、油沉降罐8. T-02110/02120 Oil Storage Tank 原油储存罐9. P-02210/02220/02230 Feed&Recycle Pump 输油/循环泵10. Sk-02240 Custody transfer Metering Skid 计量壳11 To closed drain system 去闭排系统12. anti-foam Injection system 消泡剂系统13To gas processing System 去气体处理系统14Pump stating 泵站15To LP Flare System 去低压火炬系统16To water tr

39、eatment system 去水处理系统17From HP&LP Knockout Pump从高低压分离鼓泵18. From slop oil system 来自污油系统19LC-液面控制20PC-脉冲控制（可编程序控制）21TE-感温元件AGAA-P-DW-01551 Gas Processing System 天然气体工艺系统1. SK-02610 Gas scrubber 气体洗涤器2. Sk-02710/02720 Gas production separator（skids）3V-02710/02720 Gas production separator 天然气生产分离器4.

40、 V-SK-03210/03310 Gas Compressor (skid) 天然气压缩机6. SK-02920 Gas Exchanger skid 气体换热器7. V-03910 Gas pig launcher 气体清管发射器8Gas To CPF HP Hnockout Drum天然气去CPF火炬高压分离鼓9Pilot Gas To Flare 尾气去火炬点火10Gas to CPF Production Heater 天然气去CPF生产加热炉11Gas to CPF Power station 天然气去CPF(solar)发电站12Gas To FPF 天然气去FPF13Lube

41、Oil System 润滑油系统AGAA-P-DW-01572 Instrument & Netrogen System仪表与治氮系统1. SK05300 Air Compressors Package 空气压缩机包2K-05210/05220 Air Compressors 空气压缩机3.SK-05310 Utiliy air receiver公用空气储气罐4. F-05420/05430 Pre-Filters （前置）过滤器5. A-05410/05440 Desiccant dryers 干燥器6. F-05450/05460 Air Filters 空气过滤器7Instrum

42、ent(仪器) Air Receiver 仪表风储罐(仪表风)8To Utiliy air user 去公用空气端9To Instrument Air User 去仪表用气端10. SK-06110 Nitrogen Production skid 制氮撬11.V-06120 Nitrogen Tank 氮气罐12. V-06130 Air buffer tank 空气缓冲罐13.A-06140/A-06150 Adsorbers 吸附器14.V-06160 Nitrogen Buffer Tank 氮气缓冲罐15.D-06170 Refrigerant Dryer 制冷干燥剂16.F-061

43、80 Activated Carbon Filter 活性炭过滤器17. F-06190 Coalescer Filter聚结器过滤器18. To Nitrogen Distribution System去氮气分布系统AGAA-P-DW-01574 Flare System 火炬系统1. SK-03810 HP Knockout Drum高压分离鼓2. P-03820/03850 HP/LP Knockout Pump 高/低压分离泵3.V-03840 LP Knockout Drum低压分离鼓4PK-03830 HP /LP Flare/Vent Stack Package高/低压火炬/点火

44、盘5.F-03860 LP Flare/Vent Stack 低压火炬/通风竖管6K-03870/80 Blower鼓风机7Pilot GAS From CPF GAS Scrubber从气体洗涤器的来气8GAS From HP /LP Flare System气体来至高/低压火炬系统9Oil To CPF GAS BOOT油去CPF脱气塔AGAA-P-DW-01700 Produced Water Treatment System 水处理系统1、T-04310/04320 Skim tank 撇油罐2.T-06510 Slop oil tank(Internally coated)污油罐3.

45、T-06510/06520 Slop oil pump污油泵4.T-05910 Evaporation pond 蒸发池5.Produced water from export pumps station从泵站出口来水6Produced water from Production separator skid生产分离器来水7Produced water from oil sedimentation tank原油沉降罐来水8Slop oil to oil sedimentation tank污油去原油沉降罐9Treated water to water injection system处理水去注

46、水系统10To IGF floatation unit in future 去浮选装置预留AGAA-P-DW-01701Fire fighting & water supply system消防水供水系统1、P-04110/04120/04130/04140 Submerged well pump潜水泵2.T-04150 Pneumatic tank储水罐(缓冲罐)4P-04150/04160 Equipped water supply pumps供水泵5CL-04150 Uv purify device紫外线净化装置6.T-07010/07020 Fire water tank (Internally coated)消防水罐4.P-07030/07040 Electrical driven firewater pump 电驱动消防泵5.P-07050 Diesel driven firewater pump柴油机驱动消防泵6P-07110/07120 Electrical driven foam pump 电驱动泡沫泵7.P-07130 Diesel