12种橡胶耐300种化学药品性能表

1、 表的阅读方法可用的顺序以1、2、3、4、5表示，这是通过综合考虑体积变化率及其它物理性质而决定的。也可用于动态部位，体积变化率在10%以内根据使用条件，也可用于动态部位，体积变化率在20%以内可用于静态部位，体积变化率在30%以内根据使用条件，可用于静态部位，体积变化率在100%以内不能使用。体积变化率在100%以上。此外，橡胶采用了is0的分类符号。但，Q：硅橡胶，U：聚氨酯橡胶。另外，本表的耐性排名为参考值，实际的混合橡胶，可能会因品牌、使用环境的不同而有所变化。参考文献：杜邦公司：ViT0NBulletin氟化橡胶的耐液体性杜邦公司：ElastmerReviewGoodrich公司：H

2、ycarReportPolymer公司：TechnicalReport：ChemicalEngineeringHand-book信越化学：SiliconeReviewParkerseal公司：SealCompoundmanualTheLosAngelesRubborGroupinc：TheGeneralChemicalResistanceofVariousElastomers日本华尔卡：测试数据各种弹性体橡胶的耐性一览表待续 橡胶药品温度匚SBRCFNBR.HHNRQCSMFKMEPMEPDMU丙烯酸乙酯RT5J5252552555丙烯酸丁酯和55555555555丙烯腈RT4253Z35一5

3、5沥青弗531555315222乙炔N1.21131211乙醛N54132352555乙酰胺N31i33331551乙酰醋酸酯RT335232552555乙酰苯N5551355155丙酮N235112252555苯胺N345125311553苯胺1505$55苯胺盐酸盐32215Z252亚麻子油1D014114113.1戊醇65212111115S1戊烷氯萘盯55355j155戊基萘55355!i515J亚硫酸2Z;J223212.52亚硫酸钠n2L112211151安息香酸6555$5555*15552安息香酸苄基:汀5542551Z512042氨（液体）RT11:*11Z1515556S3

4、224212一55氨（气体）灯112112151557532343325255氨水（30%）211211J1硫磺51515115151异辛烷32155531g211异癸烷ff23一5异丁醇333111211552异丙醇叩22211111552异丙醚531555155Z4斗一氧化碳6522223121112威士忌RT2Z11111551各种弹性体橡胶的耐性一览表特殊混合待续 橡胶药品温度TSBRCFNBRHRNRQCSMFKMEPMEFDMUACMNM2-乙基1-丁烯RT5415555J5514乙酰胺651LI13i乙醇申1L111111551乙醚RT54:i455454355乙苯u555555

5、5J1551乙基纤维素N222222i52255乙硫醇N5555522乙基五氯苯W555$541乙二醇701L111J1155乙二胺RT2L1111251555环氧胺丙烷7055525542555氯气（干）RT43g223i4551氯气（湿）432JI4L2552盐酸10%制1L1111Jr17022121Ip2RT2111212怦1”36%7(15115554代2氯化丙酮ET533225251555铝11211211111铵科213Z1111一锌N11i1112-氯丙烷RT555555s15552硫Z53555E1&一51iM弓11335s12一41乙基乙烯ff55545551目54钾&51

6、11J11i1111钙1LI1111i1111泵&511211111亚锡科1LI1122i11锡1LIi12ii11亚铁333铁N1L11111I111铜柑122i11111111钠1001LIi111111镍12t11121111 药品橡胶温度SBRCRNBR9IRNRQCSMFKM.E.PMEFDMU氯化钡112.1(11JJ11JRT555555515-5527055555552j553RT55S55551&5516511111111111HT444345.12a552甲烷N45暮45543455:弓二氯甲烷ASTM油703L)5512i5111100L1511117042)452415

7、111RT315331J11110(154L554一15111RT52155215121FuelAN5425s5515251FuelBW5525551.5252FuelC王水54545賞33n-辛烷52255521j552臭氧535251111121油酸515百552一5橄榄油科511z412I21一海水N22212)1高氯酸（10%）50LI1211=-过氧化氢（3%）RT2222L1111!51过氧化钠&52221252i1551果汁ET333I1果糖&51L2111i1过硼酸钠RT1?122i1过硫酸铵1411卡比醇科X22L32222552汽油53I5s5415251二甲苯科55555

8、55155.1甲酸7012i13114=甲酸甲酯柑2L5222空气N1L1111111111柠檬酸2Lt211311特殊混合待续各种弹性体橡胶的耐性一览表待续 橡胶茹品f-温度!SBRCFNCRHRNRQC5MFKMEPMEPDMUQ甲酚7G5335553J5552杂酚油655z11541.锯酸RT53525112153镀锯液N555552512552氯丁二烯D555555515-552氯仿RT5545525550-氯蔡N5545451S552氯化硝基乙烷N535545555555甘油651.1111111551KF-96（硅油）RT111115111111轻油7053155515211煤油R

9、T53L55531511硅酸乙酯221112L11硅酸钠井111111111污水污物iI11121i1551矿油ffL11141114111焦炉气55555241552柏油655z11541醋酸（25%）?r一2222235115（冰醋酸）N311231452555（蒸汽）2211151（无水）胡221212251555戊烷基tf555555551555铝6S53:i1351J555钱灯122-氯丙烷N5s5255552555乙酯515255551555钾A521113251555钙521125351555纤维素:-；r24412铅6551311S!&1555乙酸甲酯灯124255552555

10、鎳52z115551555丁酯和555245351555糖水65I11111211551待续 橡胶药品温度1SE5RCRNBRI1RNR(?CSMFKMEPMEPDMuACML|i.izv水杨酸652E11311J氧气丁1141411112155555!ijz三氧化硫（硫酸酐）RT55522212草酸653221222111草酸乙酯35114L溴55石45j1i552溴酸（40%）N42s1252115S3溴化铝65331212111.1溴化苯丈丁55555515551四氯化碳咅4斗55514双丙酮醇5:135151555双异丙基甲酮和i5:!2451:i1555二乙胺11.21135355二

11、乙醚53555555133二甘醇丼1.11111211551氧化二乙烯555155551555二氧戊烯ft5533555z555二氯苯55:i$5551$552二环己基胺秒555555555二苯基55$5555552二苯基氧化物45555547115552二苯基五氯类1005552一一二戊烯:汀552555s155二丁醚4J一553=联苄醚5i515552二甲基苯胺即555J544二甲基甲酰己烷5455251g221环己酮ff53425352555p-伞花烃55J55515552脂肪酸6531113312=酒石酸RTZ21211111中国桐油V511355.1J532

12、松根油5515515I51各种弹性体橡胶的耐性一览表 橡胶药品温度SE5RCRNBRI3RNR(?CSMFKMEPMEPDMu硝酸(10%)RT2121322申JN2321331J”(30%)(50%)N55!i353弹3硝酸铝&51i3231铵Z1L)13J15J钙N11iI2!i1111N11I1J111115J钾银N11.211111111钠N22212511铁N1111121i1111铅柑111I112111钡12J2i植物油RT:Jz12513I311次氯酸N=14一24i2次氯酸钙N222I311i钠N2I221ii=重铬酸钾NIt钠ft1111111水蒸气tflfl2222g3M

13、J55175555Z5552K1555氢氰酸222111ti252氰化钾話1L1111111111氰化钠11111111氰化铜N1L2111111111重油（A）15CI5(B)1(C)12032一11JP-4RT55l55551J222JP-5甬551555515221醋柑22121151553水银111111I氢氧化钙651LiIE11pI551钾h2L21111钠(50%)RTtL112L11钠702l2J1-特殊混合待续药品一橡胶温度r:SBRCRNBRHKNR(?CSMJiKMEPMEPDMU氢氧化钡651121211J155Jn1L211111155氢气RTzL1123111123

14、&521I32311123航空用液压油500705552555515557000N55555551555苯乙烯KT55S55552s553硬脂酸N2223Z217031硬脂酸丁酯RT牙52455i52轴润滑油柑53155331s111苯酚N52S1113i15C552552石灰水站11111一111肥皂水N221121111551明胶RT1L11111=Celgard7fl4214i一一15(555Z5352553甲基纤维素RT55525$5S2555癸二酸乙基N542$柏油5315535i&51导热姆A705.155241ERT5555551一E1505555553tert-丁醇RT2Z22

15、211)2551150151二2巧1LI115111111z1LI115!11111RT5LI152111L11G5Z1Z一Z11DOWCORNINGF-60RT1322IF-61額1111111I1一132I1122115碳酸铵RT471251213一11559钙55525钠鞣酸大豆油噻吩待续待续 各种弹性体橡胶的耐性一览表橡胶药品温度SBRCFNBRHRNRQCSMFKMEPMEFDMu粘硫化硫酸钠RT11iJ(1111挥发油*55535四氢化萘554555j1s1松节油*5425551天然气3L153115223萘烷币555555Ls1癸烷制55155231.1511谷物油52)1511

16、i311三乙酸甘油酯32z12251555三乙醇胺2L211152555三氯乙烷A)555555515552乙烯沖55545j51555254S$52甲苯RT555555525552动物油521IS22i2211石脑油705445555122.2萘N5555555i5J环烷酸55i55551J1乳酸KT1liI1ii15J&53222221胶111113i一二氯化铵RTI11i二乙烯55552乙烷G555硝基乙醚RT5115硝基丙烷N5552555251硝基苯70:i55555z45515123555硝基甲烷RT2?52252l255252222I152二氧化氯N554531i552&5I12

17、1I一1I21一2柑1L111122二硫化碳葡萄糖母液150RT705453553521511.12141415待续药品葡萄糖母液200软脂酸蓖麻油苦味酸橡胶温度匚RTti粘65RT苦味酸（20%水溶液）苯基类苯乙基醚氟化铝氟硅酸氟化苯氢氟酸65%氢氟酸65%氟里昂11氟里昂12氟里昂22氟里昂113氟里昂114RT询RT轴RTn70RT45RT45R.PI45E.T15kT1EPME叩MT21215551fi11521555待续 各种弹性体橡胶的耐性一览表橡胶药品温度匸SBRCFNRRHRNRQCSMFKMEPMEFDMu454325524丙烷RT52I555215312丙醇G51L1111

18、111551丁二烯RT534143111J丁烷n5I1555215511酞酸（无水）N12!tRT55525532547fl555252412552RT5Z41221152丁醇N1L1122113551丁醛N54斗25452丁胺N554552555555丁卡比醇N23曲15143J55丁基纤维素N1211111-丁烯N1Li正己醛N5151523515己烷Z52i5551i521J己醇7022i11321552己烯355325552i511J庚烷RT52155115211苯甲醇65535143t2552轻质汽油（石脑油）RT5?15s53izi211苯甲醛ft555155551555苯a554

19、4552&J55270555555535通风孔润滑油RT5Ji55211&21硼砂帖1I211111硼酸N1L11111151硼酸戊烷基RT5?15511=没食子酸G52221212551福尔马林RTiL111211=机油（120）755=I5h一i511机油（160）iM5I5515111顺丁烯二酸RT5555555155水1LL111!1151特殊混合待续 橡胶药品-温度SBRCFNBRHUNRQCSMFKMEPMEFDMUMIL-F-25558FRT52L5552Jfi11JMIL-F-25576A52I55521511MIL-H-560670531553315111MIL-L-7808CRT55z55251522牛奶ti1Iz1Z111151明矾S522zi1iI异丙丁酮WT5553545甲基丙烯酸W5552544IV55555555甲醇州1L)1111弹15S1甲基醚2311215代15143s35F553555丁酮曲5$5J5551555甲基纤维素2)s棉籽油55522!51i1211木醋酸RT:5113氯乙酸z3232525255丁烯炔N22112Z211高炉煤气N222331