版权说明:本文档由用户提供并上传,收益归属内容提供方,若内容存在侵权,请进行举报或认领
文档简介
1、KYEF 苏州科跃环保设备有限公司苏州科跃环保设备有限公司 因为环保 所以自然 创新 拼搏 求实 奋进TO(蓄热式废气焚烧炉)RTO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l蓄热式燃烧技术蓄热式燃烧技术RTORTO:l 用于有机废气的治理,适应于同一生产线上,因产品不同,废气成分经常发生变化或废气浓度波动较大的场合。应用行业包括汽摩、造船、自行车、家电、集装箱等厂的涂装线、石油化工、橡胶、涂料、粘胶、印刷、漆包线等生产线的废气处理。尤其适用于需要热能回收的企业或烘干线废气处理,可将能源回收用于烘干线,
2、从而达到节约能源的目的。l技术原理技术原理l 其原理是可燃有机废气在摄氏7601000度发生热氧化反应,生成二氧化碳和水等。废气首先通过蓄热体加热到接近热氧化温度,而后进入燃烧室进行热氧化,氧化后的气体温度升高,有机物基本转化成二氧化碳和水。净化后的气体,经过另一蓄热体,温度下降,达到排放标准后进行排放。lRTO装置中的蓄热式陶瓷填充床换热器可最大限度回收热能,热回收率大于95%,处理VOCs时不用或使用很少的燃料。若处理低浓度废气,可选装浓缩装置,以降低燃料消耗。l根据客户需求,可设计两室、三室、多室或单室旋转式RTO装置。KYEF 科跃环保科跃环保TO(Reg
3、enerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉lStorage technology of RTO combustion:lFor the treatment of organic waste gas, suitable for one production line, for different products, the composition of the exhaust gas often change or exhaust gas concentration fluctuations. Application of industrie
4、s including automobile, shipbuilding, home appliances, bicycles, container factory coating line, petroleum chemical industry, rubber, coating, adhesive, printing, enameled wire production line of exhaust gas treatment. Especially applicable to enterprises or drying line treatment of waste gas heat r
5、ecovery, energy recycling can be used for drying line, so as to achieve the purpose of saving energy.lTechnical principle:lIts principle is combustible organic waste gas in 760 1000 degrees Celsius heat oxidation, carbon dioxide and water. The exhaust gas through the regenerator is first heated to n
6、ear the thermal oxidation temperature, and then enter the combustion chamber of the gas temperature thermal oxidation, oxidation of organic matter increased, converted into carbon dioxide and water. The purified gas, through a regenerator, temperature drops, reach the discharge standard after discha
7、rge.lThe RTO device in the regenerative ceramic packed bed can maximize the recovery of heat exchanger, heat recovery rate is greater than 95%, VOCs without or with few fuel. If the treatment of low concentration gas, optional concentration device, in order to reduce the fuel consumption.lAccording
8、to customer needs, design two room, rooms, multi room or single room RTO rotating device.KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l原理简介:原理简介: 蓄热式热氧化器(Regenerative Thermal Oxidizer,简称RTO)是一种用于处理中低浓度挥发性有机废气的节能型环保装置。 它的基本原理是在高温下使废气中的有机成分氧化生成CO2和H2O,从而予以去除。该装置的特点
9、是在设备中增加了蓄热式热交换器,由于其热回收率高(大于95%),从而起到了节能氧化的效果。 l Regenerative thermal oxidizer (Regenerative Thermal Oxidizer, referred to as RTO) is a kind of energy-saving environmental protection device for the treatment of low concentration of volatile organic waste gas. Its basic principle is at high temperatur
10、e the organic components are oxidized to H2O and CO2 in waste gas, thereby removing them. The device is characterized in that the device increases the regenerative heat exchanger, due to its high heat recovery rate (more than 95%), so that the energy saving effect of oxidation.KYEF 科跃环保科跃环保 0512-675
11、99636RTO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l装置优点:装置优点: 1. 对工况要求低,废气中可以含有多种有机成分,处理风量范围大: 1,000300,000Nm/h; 2. 净化率高,两床式RTO净化率在95%以上,三床式RTO净化率在 98%以上; 3. 全自动控制,操作简单;操作费用低; 4. 运行费用低,当VOC浓度达到400ppm时,不需要额外的燃料消耗。l1 low on the working conditions, the exhaust gas can contain a variety of org
12、anic ingredients, a wide range of air volume: 1,000 300,000 Nm / h;2 purification rate, two-bed RTO purification rate of over 95%, three-bed RTO purification rate of more than 98%; 3 automatic control, easy to operate; low operating costs; 4 low running cost, when a VOC concentration of 400ppm, no a
13、dditional fuel consumption. KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l应用范围:应用范围: 有机废气的浓度较低; 较大的有机废气处理量; 有机废气需要较高的氧化温度; 废气含有对催化剂有毒性的物质; 不需要大量回收有机溶剂lThe low concentration organic waste gas;lA large amount of organic waste gas treatment;lOrganic waste gas needs
14、high temperature oxidation;lWaste gas containing toxic substances on the catalyst;lDoes not require a large amount of organic solvent recoveryKYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l两室两室RTO流程:流程:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )
15、蓄热式热力废气焚化炉蓄热式热力废气焚化炉l三室三室RTO流程:流程:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l案例介绍:案例介绍:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l案例介绍:案例介绍:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l案例介绍:案例介绍:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l案例介绍:案例介绍:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉蓄热式热力废气焚化炉l案例介绍:案例介绍:KYEF 科跃环保科跃环保TO(Regenerative Thermal Oxid
温馨提示
- 1. 本站所有资源如无特殊说明,都需要本地电脑安装OFFICE2007和PDF阅读器。图纸软件为CAD,CAXA,PROE,UG,SolidWorks等.压缩文件请下载最新的WinRAR软件解压。
- 2. 本站的文档不包含任何第三方提供的附件图纸等,如果需要附件,请联系上传者。文件的所有权益归上传用户所有。
- 3. 本站RAR压缩包中若带图纸,网页内容里面会有图纸预览,若没有图纸预览就没有图纸。
- 4. 未经权益所有人同意不得将文件中的内容挪作商业或盈利用途。
- 5. 人人文库网仅提供信息存储空间,仅对用户上传内容的表现方式做保护处理,对用户上传分享的文档内容本身不做任何修改或编辑,并不能对任何下载内容负责。
- 6. 下载文件中如有侵权或不适当内容,请与我们联系,我们立即纠正。
- 7. 本站不保证下载资源的准确性、安全性和完整性, 同时也不承担用户因使用这些下载资源对自己和他人造成任何形式的伤害或损失。
最新文档
- GB 7919-1987e化妆品安全性评价程序和方法
- 教师个人工作总结集锦10篇
- 教师个人自我评价(12篇)
- 2024年《陋室铭》教案篇
- 竞选班干部的讲话稿
- 牛肉加工项目可行性报告
- 劳动竞赛实施方案(2篇)
- 幼儿园冬季火灾防控方案(2篇)
- 汽车运输服务方案(2篇)
- 沥青路面施工安全教育培训
- 《化工和危险化学品生产经营单位重大生产安全事故隐患判定标准(试行)》解读课件
- 材料力学第4版单辉祖习题答案
- 衍纸艺术在装饰设计中的运用表现
- 铝合金锭——成分性能对比
- 2020年广东省广州市中考生物试卷
- 道路工程档案管理办法
- 孔繁森精神PPT课件
- 2020无症状高尿酸血症的管理共识要点(完整版)
- 某冶金机械修造厂总降压变电所及配电系统设计(doc 48页).doc
- 健身基础理论知识
- 实习生实习合同书
评论
0/150
提交评论