锅炉房真空负压燃气锅炉2×3.5MW机组锅炉运行报告.doc

蚌埠xx a5区锅炉房 真空负压燃气锅炉23.5mw机组锅炉运行报告编制： 审核： 批准： 商业物业工程部2011-3-30目录1、 锅炉概况2、 运行前的检查和确认3、 运行依据4、 运行步骤5、 运行记录6、 运行结论和建议锅炉运行报告1、 锅炉概况蚌埠xx a5区锅炉机组为真空负压燃气锅炉机组，本区机组为安阳方快锅炉有限公司生产的型号为zwnsl 3.5-1.0/n-y.q真空负压强制通风燃气锅炉。1.1锅炉基本参数额定热功率 3.5mw额定工作压力 -0.02mpa有效水容积 3.797m3额定出水温度 60额定进水温度 501.2锅炉转动机械设备规范强制通风电机型号：lafert额定电压： 380415v功率： 20.0hp(15.0kw) 功率因数： 0.82额定电流： 29.529.0a额定转速： 2920min-1ip防护等级: 55生产地：意大利燃烧器型号：利雅路（威龙）riello 功率: 17kw 额定电压: 400v ip防护等级: 40生产地：意大利配用燃气阀组： 型号：dungs生产地：德国2、 运行前的检查和确认2.1检查确认照明、通讯设施及消防设施是否齐全；2.2清洁环境，畅通道路；2.2检查地脚固定，不得有松动的现象；2.3检查风机、风道及锅体内部无杂物；2.4检查转动部分的保护罩；2.5检查媒水计位，应高于观察孔中位标志；2.6检查循环水压力及流量；2.7调节阀操作灵活、指示正确；2.8盘车检查强制通风电动机，转动灵活，无碰撞、轴承声音正常；2.9检查燃气气压及无泄漏。3、 运行依据3.1设备出厂技术文件3.2锅炉运行规章制度4、 运行步骤4.1确定转动机械、电气设备及热水循环检查完毕后，运行锅炉。 4.2锅炉启动后，确认燃气压力、火苗状态、锅炉压力、煤水温度、排烟温度、出回水温度等。 4.3锅炉运行每半小时检查一次有无异常情况。4.4运行过程中做好时间与锅炉压力、煤水温度、排烟温度、出回水温度等数据的详细记录，并进行整理。5、 运行记录2010年12月17日正式运行a区锅炉，至2011年3月24日停炉，共运行98天，中间无停炉,总共用气122504立方，热水泵耗电28900度。b区数码港供暖从2010年12月25日开始，至2011年3月24日停炉，中间锅炉两次故障共停炉15天，累计运行75天总共用气62323立方，热水泵耗电19600度。5.1 锅炉运行记录：（a区锅炉每天10：00时参数）时间燃气流量m3/h锅炉压力kpa出水压力mpa回水压力mpa出水温度回水温度媒水温度排烟温度2010-12-23141-97.20.40.525.624.234.539.52010-12-24118-97.50.40.551.146.259.658.62010-12-25140-85.80.40.545.64056.356.62010-12-26138-80.20.40.548.342.858.758.12010-12-27110-91.10.40.53939.344.1422010-12-28139-82.40.40.54742.358.557.52010-12-29139-82.60.40.547.242.158.457.32010-12-30138-83.40.40.546.842.158.456.92010-12-31141-84.80.40.545.439.957.656.62011-1-1151-80.80.40.549.844.162.2602011-1-2141-81.10.40.5494461.158.62011-1-3175-77.20.40.551.745.565.162.42011-1-4139-850.40.543.438.157.154.82011-1-5148-860.40.540.134.555.154.3时间燃气流量m3/h锅炉压力kpa出水压力mpa回水压力mpa出水温度回水温度媒水温度排烟温度2011-1-6140-89.40.40.535.930.152.752.42011-1-7189-81.60.40.544.637.560.9602011-1-8175-760.40.55145.166.563.42011-1-9165-790.40.550.745.663.959.92011-1-10142-78.60.40.550.645.764.259.72011-1-11141-740.40.553.248.266.5622011-1-12174-700.40.5544966632011-1-13143-80.20.40.550.545.361.661.12011-1-14140-810.40.550.946.261.159.72011-1-15141-84.80.40.54843.358.9582011-1-16140-87.80.40.542.938.151.9552011-1-17141-82.40.40.549.34460.5602011-1-18142-83.60.40.546.942.159.157.62011-1-19140-85.60.40.541.835.856.957.52011-1-20143-820.40.548.543.561.459.32011-1-21142-83.60.40.546.641.959.857.52011-1-22190-800.40.547.240.66362.12011-1-23178-85.40.40.542.237.257.155.42011-1-24170-780.40.546.739.664.463.12011-1-25180-81.80.40.545.940.66158.42011-1-26177-76.80.40.5504465.762.42011-1-27168-820.40.545.9416157.52011-1-28141-83.60.40.543.538.659.556.22011-1-29141-84.60.40.540.735.558.255.32011-1-30154-77.20.40.549.244.464.860.42011-1-31159-79.60.40.547.542.66358.12011-2-1140-75.20.40.550.44565.760.62011-2-2140-790.40.546.441.562.857.5时间燃气流量m3/h锅炉压力kpa出水压力mpa回水压力mpa出水温度回水温度媒水温度排烟温度2011-2-3164-74.40.40.549.243.366.761.92011-2-4139-79.80.40.544.239.361.756.62011-2-5172-750.40.548.24266.261.62011-2-6170-760.40.548.743.765592011-2-7140-77.40.40.545.139.763582011-2-8139-78.60.40.543.538.561.956.32011-2-9139-77.20.40.546.341.363.9582011-2-10142-78.80.40.544.339.362.956.92011-2-11155-74.40.40.548.743.166.860.52011-2-12141-79.40.40.543.838.663.156.62011-2-13160-74.20.40.547.94267.160.62011-2-14190-79.20.40.543.538.363.456.42011-2-15172-75.20.40.546.540.666.7602011-2-16142-79.60.40.546.540.861.7602011-2-17159-740.40.548.543.26663.22011-2-18140-83.60.40.54338.258.5562011-2-19168-79.20.40.546.941.462.659.82011-2-20191-80.40.40.545.840.66259.32011-2-21140-79.60.40.549.346.161.757.62011-2-22140-81.80.40.5443960.256.52011-2-23200-74.40.40.548.241.366.763.52011-2-24183-77.20.40.545.639.663.460.42011-2-25140-75.80.40.547.14165.361.62011-2-26138-79.80.40.544.439.561.5572011-2-27140-77.90.40.54640.663.559.22011-2-28140-77.20.40.547.442.56458.72011-3-1140-760.40.54740.965.661.32011-3-2136-81.20.40.542.137.168.855.8时间燃气流量m3/h锅炉压力kpa出水压力mpa回水压力mpa出水温度回水温度媒水温度排烟温度2011-3-3146-77.40.40.550.545.164.260.52011-3-4130-810.40.545.640.961.140.92011-3-5154-77.60.40.547.342.16359.72011-3-6141-79.80.40.545.640.861.457.72011-3-7153-790.40.54640.762.659.22011-3-8133-81.60.40.542.637.659.756.32011-3-9131-81.40.40.544.239.36157.12011-3-10132-80.80.40.544.339.361.357.12011-3-11139-81.60.40.542.237.26053.82011-3-12120-850.40.541.140.254.349.92011-3-13130-83.80.40.539.637.155.651.12011-3-14141-79.40.40.544.439.561.757.22011-3-15138-78.40.40.547.242.563.958.72011-3-16139-80.60.40.543.738.761.656.62011-3-17142-77.80.40.54742.763.957.42011-3-18146-75.50.40.544.337.664.8612011-3-19100-89.20.40.536.736.650.442.12011-3-20133-79.40.40.543.238.261.456.62011-3-2198-89.80.40.536.937.248.240.92011-3-22144-78.80.40.5464163.7582011-3-2388-91.60.40.534.134.544.636.72011-3-24112-80.20.40.542.637.561.6565.2 空调能耗记录：日期燃气能耗（m3）热水泵能耗（kwh）a区锅炉b区锅炉a区 plja2b区 pljb22010-12-2376902502502010-12-24116303002502010-12-25787637250300日期燃气能耗（m3）热水泵能耗（kwh）a区锅炉b区锅炉a区 plja2b区 pljb22010-12-267291216293.53502010-12-274519622293002010-12-28773761447.53902010-12-298071303653152010-12-3083810503102902010-12-3110946623002652011-1-1175415612352402011-1-2143913451951752011-1-318012754951902011-1-41435030502011-1-51690028002011-1-61843032002011-1-72048032502011-1-81884031002011-1-91729029002011-1-101721028002011-1-111636032002011-1-12698025002011-1-131809030002011-1-14141119922502352011-1-15144412043002102011-1-16171016703002602011-1-17168914893002702011-1-18206116233052852011-1-19181914263952252011-1-20178012433003002011-1-21169611843002502011-1-22185413423002502011-1-23170910762502502011-1-24192111863002002011-1-25201511563003002011-1-26202910302502502011-1-27179110693003002011-1-2817091092250200日期燃气能耗（m3）热水泵能耗（kwh）a区锅炉b区锅炉a区 plja2b区 pljb22011-1-29187811823002502011-1-30189510472502502011-1-31173610653502502011-2-116187482002502011-2-21171030002011-2-31327030002011-2-41176030002011-2-51465030002011-2-61450030002011-2-78529203502502011-2-812769602502002011-2-9158811253002502011-2-10161810905502502011-2-11174012055003002011-2-1216489864003002011-2-13174011504503502011-2-14171111102503002011-2-15192410002502002011-2-16175210974002002011-2-1716527402002002011-2-18153212353502502011-2-1914169384002502011-2-2018349152502002011-2-2112518023003002011-2-2211786953502502011-2-239772953002502011-2-2410673323002502011-2-2513454533502502011-2-2612254623002502011-2-2718377553502502011-2-28138010123002502011-3-114968973502502011-3-212689393002502011-3-31548785300250日期燃气能耗（m3）热水泵能耗（kwh）a区锅炉b区锅炉a区 plja2b区 pljb22011-3-413008553502502011-3-514426613002502011-3-613627753002502011-3-79164763502502011-3-812814653502502011-3-913354253002502011-3-1010673983002502011-3-116725083502502011-3-126302873002502011-3-134221933502502011-3-146803633002002011-3-155132983002502011-3-166422373502502011-3-173631873502502011-3-185593423502502011-3-194892413002502011-3-205742653502502011-3-217121063502502011-3-224614303502502011-3-23274983002502011-3-247033923002505.3 a区现场环境温度记录：（每日11：00数据）位置时 间户外一层二层三层a2区外环a2区内环a4区内环a4区外环a2区外环a4区外环a2区外环a2区内环a4区内环a4区外环a2区外环2011-1-3169998111122172124182011-2-1691299131324192526192011-2-279999141423202426202011-2-379999131424192526202011-2-4710101010151525212526202011-2-5811111011151625212626202011-2-6101212121116162522252621位置时 间户外一层二层三层a2区外环a2区内环a4区内环a4区外环a2区外环a4区外环a2区外环a2区内环a4区内环a4区外环a2区外环2011-2-71013131313161623222526202011-2-8912121312161522182225192011-2-91113141413171722212227202011-2-10911121211161627222627252011-2-11810121010151523202830202011-2-127912118131420182022172011-2-13910121110151424212727202011-2-143810108131316151821172011-2-159810109131425202519192011-2-16491098121223192123182011-2-174911109131324192024182011-2-18610111010141420182023182011-2-191410141010141325202525202011-2-201310131010141422202223172011-2-211512151311141426212722222011-2-221311131111151523182223182011-2-231111131111131323182124192011-2-241813161314161725212326192011-2-251014141414171724202929202011-2-26712131312151522192125192011-2-27812131313161624202526202011-2-28511121111151426202526202011-3-171112129131321192124192011-3-21010121110131422192123182011-3-3910151210141418182025152011-3-41211131211151523202324172011-3-5814141211151520242217192011-3-61013131312151620232322172011-3-71313141313161617191921222011-3-81412151312151620182122182011-3-91215151515151517182322202011-3-101414141414161626262726252011-3-11211520151516161819202020位置时 间户外一层二层三层a2区外环a2区内环a4区内环a4区外环a2区外环a4区外环