外墙装饰工程施工方案.doc

We will continue to improve the companys internal control system, and steady improvement in ability to manage and control, optimize business processes, to ensure smooth processes, responsibilities in place; to further strengthen internal controls, play a control post independent oversight role of evaluation complying with third-party responsibility; to actively make use of internal audit tools detect potential management, streamline, standardize related transactions, strengthening operations in accordance with law. Deepening the information management to ensure full communication zero resistance. To constantly perfect ERP, and BFS+, and PI, and MIS, and SCM, information system based construction, full integration information system, achieved information resources shared; to expand Portal system application of breadth and depth, play information system on enterprise of Assistant role; to perfect daily run maintenance operation of records, promote problem reasons analysis and system handover; to strengthening BFS+, and ERP, and SCM, technology application of training, improve employees application information system of capacity and level. Humanistic care to ensure zero. To strengthening Humanities care, continues to foster company wind clear, and gas are, and heart Shun of culture atmosphere; strengthening love helped trapped, care difficult employees; carried out style activities, rich employees life; strengthening health and labour protection, organization career health medical, control career against; continues to implementation psychological warning prevention system, training employees health of character, and stable of mood and enterprising of attitude, created friendly fraternity of Humanities environment. To strengthen risk management, ensure that the business of zero risk. To strengthened business plans management, will business business plans cover to all level, ensure the business can control in control; to close concern financial, and coal electric linkage, and energy-saving scheduling, national policy trends, strengthening track, active should; to implementation State-owned assets method, further specification business financial management; to perfect risk tube control system, achieved risk recognition, and measure, and assessment, and report, and control feedback of closed ring management, improve risk prevention capacity. To further standardize trading, and strive to achieve according to law, standardize and fair. Innovation of performance management, to ensure that potential employees zero fly. To strengthen performance management, process control, enhance employee evaluation and levels of effective communication to improve performance management. To further quantify and refine employee standards . Work, full play party, and branch, and members in five type Enterprise construction in the of core role, and fighting fortress role and pioneer model role; to continues to strengthening four good leadership construction, full play levels cadres in enterprise development in the外墙装饰施工一、高级丙烯酸弹性外墙涂料1、涂料工程使用的腻子，应坚实牢固，不得粉化、起皮和裂纹。腻子干燥后，应打磨平整、光滑，并清理干净。要按基层、底涂料和面涂料的性能配套使用。2、室外需使用涂料时，应使用具有耐水性能的腻子（由甲方确定）。3、涂料的工作粘度或稠度，必须加以控制，使其在涂料施涂时不流坠、不显刷纹。施涂过程中不得任意稀释。4、双组份或多组份涂料在施涂前，应按产品说明规定的配合比，根据使用情况分批混合，并在规定的时间内用完。所有涂料在施涂前和施涂过程中，均应充分搅拌。5、施涂溶剂型涂料时，后一遍涂料必须在前一遍涂料干燥后进行；施涂水性和乳液涂料，后遍溶剂型涂料时，后一遍涂料必须在前一遍涂料表面干后进行。每一遍涂料应施涂均匀，各层必须结合牢固。6、采用机械喷涂料时，应将不喷涂的部位遮盖，以防沾污。7、外墙涂料工程分段进行时，应以分格缝。墙的阴角处或水落管等为分界线。8、外墙涂料工程，同一墙面应用同一批号的涂料，每遍涂料不宜施涂过厚，涂层应均匀，颜色一致。9、在强烈日光直接照射下，不得进行施涂涂料。10、涂料施涂工具使用完毕后，应及时清洗或浸泡在相应的溶剂中。面砖进场后，现场组织验收选砖，并按规定抽样检查面砖的各项指标是否合格，不合格的禁止使用。二、墙面砖施工外墙镶贴面砖，应在屋面断水，周边围护结构完成，女儿墙施工完成后，从上至下分段进行。三、操作程序基层处理放纵横通线贴饼冲筋抹底层砂浆弹线分格镶贴面砖勾缝清洁表面。四、施工准备1、搭好外架，清除作业面上的施工障碍，所需材料及施工机械应齐备，以保证连续作业。2、材料：水泥用普通水泥32.5#，砂用颗粒坚硬，含泥量不大于3的细砂，需过筛，面砖进场后应开箱检查，其规格、几何尺寸、颜色符合设计要求，若有歪斜，缺棱掉角、翘曲、裂纹和颜色不同的应剔出，不得使用，同时将面砖送试验室进行强度和其它物理性能检测。107胶和矿物颜料也需按有关规定要求进行检测。3、在镶贴前应根据建筑物所贴部位的形状和尺寸进行预排，对边角墙等难点和有出入的地方尽量克服或进行适当调整并制定出作业方案，贴出样板，待建设、设计、质检、施工各方确定后再展开墙面实际镶贴。五、施工操作1、清理基层，把基层清扫干净，砼墙、柱部分应凿毛，并用钢丝刷满刷一遍，抹灰的前一天洒水润湿墙面。2、贴饼冲筋：将女儿墙用水平仪抄平，弹出中心控制线，然后在大角上用经纬仪或线锤测定垂直控制线，横线以楼层为水平基线交圈控制，竖向以四周大角和通天柱为基线控制，凡在阳台、窗等处均应弹上横向水平控制线，经确定垂直方正后按纵横12001500mm进行扎巴出柱，每层打底时以灰饼为基准点进行冲筋。3、抹底层水泥砂浆：为防止空壳，底层宜用石屑水泥砂浆，即水泥砂浆的的砂全部或部分用石屑替代。抹底层水泥砂浆应分层分遍成活，抹灰时应先刷一道水泥重10的107胶的纯水泥浆，边刷边扶第一遍水泥砂浆，第一遍水泥砂浆厚57mm，抹后用扫帚扫毛。在刷107胶水纯水泥浆后，紧接着把钢丝网嵌固在空心砖墙上，随后即抹灰。第一层灰干后抹第二层，厚78mm，随后用木杠刮平，木抹搓毛。4、弹线分格，等基层灰六、七成平时，进行分段分格弹线，用水平仪在女儿墙上测出水平分格线，对于外墙要特别注意水平控制分格横线在同一个水平面上。5、根据控制线弹出嵌贴面的分仓墨线，一般纵横向以窗的宽度和高度进行分块控制，并要求操作班组在分块控制格内弹上单块（面砖）线，以便嵌贴。在墙上及转角处每隔2000mm左右贴好面标准，（可利用面砖角料），以控制面层的平整度、垂直度和粘结层的厚度。或者先镶贴垂直控制点，然后横向拉双线控制，从左向右逐块镶贴。6、面砖镶贴前，应洗刷干净，放入清水桶内浸泡2h以上，捞出表面晾干后使用。7、镶贴时在每一分格块内应自下而上粘贴，砂浆用白水泥白灰砂浆，操作时在面砖背面满刮刀灰，砂浆厚度68mm，面砖上墙后用小木锤轻轻敲打，使其平整并与基层粘牢，同时用2m直尺检查，调整平整度和垂直度。镶贴面砖应保持面砖上口平直贴完一片将砂浆刮平。8、色缝清洁：待镶贴完一定面积后，即进行检查，合格即可勾缝，勾缝用1：2水泥砂浆分两次进行，缝一般为凹缝，凹进面砖表面23 mm应密实，每次施工完毕的面砖必须当天自上而下地清洁干净，对所有门窗洞口及突出部位均应按规定的排水坡度做滴水线。六、注意事项外墙面砖的施工应严格按照DB51/T32.10，191有关规定实施。外墙面砖每300m2面积为一组，必须进行抗拔实验，合格后方可进行大面积施工。外墙面砖镶贴应预先排版，保证每面墙上不得出现一行以上非整砖，非整砖应镶贴在次要部位或阴角处。为了更好的保证外墙面砖镶贴的内在质量，对填充墙周边与框架结构之间的砂浆嵌填密实情况进行检查，并按规范要求铺设密眼钢丝网。需要处理的应事先进行处理，确保砌体与框架的整体性完好，减少砂浆收缩。在墙面及转角处每隔2m左右埋好贴面标志（可用面砖角料），以控制面层的平整度、垂直度和粘结层的厚度，面砖铺贴应根据预定的流水分块进行，每个分块自上而下铺贴。压顶、窗台等部位的平面，镶贴面砖应做成流水坡度，窗台平面砖应低于窗框并且伸入窗框位置。面砖表面的清洁工作应在当天作好，如完成后还有不洁之处，可用草酸清洗墙面。外墙面砖工程的保证项目和基本项目，严格按照GBJ30188检验评定， 其允许偏差项目应符合下表要求。序号检测项目规范允许偏差检测方法1立面垂直3mm检测尺和楔形塞尺检查2表面平整2mm检测尺检查3阴阳角方正2mm阴阳角尺检查4接缝平直3mm接5M线尺量检查5接缝高低1mm用直尺和楔形塞尺检查6接缝高度0.5mm尺量检查仿佛顷刻间，亚运就来到了我们身边。一个普通的人，很难想象它背后隐藏着多少人的心血，藏匿着多少人的汗水，背负着多少人的梦想，寄托了多少人的祝愿，在这个激动人心的时刻，在这个万众瞩目的地方of backbone backbone role; to full strengthening members youth work, full play youth employees in company development in the of force role; to improve independent Commission against corruption work level, strengthening on enterprise business key link of effectiveness monitored. , And maintain stability. To further strengthen publicity and education, improve the overall legal system. We must strengthen safety management, establish and improve the education, supervision, and evaluation as one of the traffic safety management mechanism. To conscientiously sum up the Olympic security controls, promoting integrated management to a higher level, higher standards, a higher level of development. Employees, today is lunar calendar on December 24, the ox