氯化橡胶云铁防锈漆.doc

氯化橡胶云铁防锈漆Intended Uses用途适用于船舶、煤气罐、海港码头、海上钢结构飞溅区、石油化工设备外壁，管架及其他钢结构防蚀、也可涂在混凝土物件作为保护层，由于云母氧化铁为鳞片状颜料，具有独特的屏蔽性能，颜料能定向平行重叠排列，形似“鱼鳞”一般的搭接结构，因此涂膜具有优良的防锈、防潮、耐化学腐蚀性能。Suited for anticossive protection of vessel, gas tank dock, spatter part of marine steel structure, exterior petroleum and chemical equipment. Also can be painted on cement structures for protection. Due to micaceous iron oxide, a scale-like pigment which may overlap and arrange parallel and form an orientation in similitude of fish scale after film formation, it is possessed of excellent property of anti-corrosive and resistance to chemicals.ProductDescription产品简介灰黑色，底漆或中涂漆Grey black, primer or intermediate coating ProductInformation产品数据Volume Solids 固体份40%Dry Film Thickness干膜厚度70microns equivalent to 175 micrions of wet film 70微米相当于175微米湿膜厚Theoretical Coverage 理论涂布率4.1 m2 /Kg 4.1平方米/公斤Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Application Details施工详述Mix Radio 混合比One pack 单罐装Method of Application 施工方法 Airless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conventional Spray 传统喷涂 Not Recommended 不推荐使用 Thinner 稀释剂 C001Cleaner 油漆设备清洗剂 C001Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Drying time 干燥时间SubstrateTemperature底材温度Touch Dry表干（H）Hard Dry硬干(H）Over coating Interval覆涂间隔Mix最短Max最长250.580 24 hour 小时24 8 hour 小时30 6 hour 小时 Not limit 不限Storage andHandling贮存与管理Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处Pack size 包装规格 25Kg in 20 liter container 25公斤装于20公升容器中Flash Point 闪点 31 高于23Specific Gravity 比重 Approx1.4 Kg/L 大约1.4公斤/公升Specification and Surface preparation技术要求及表面处理Steel surface to be painted should be shot or grit blasted to Swedish Standard Sa2.5 surfaceOver shop primer should be rust-removed again to reach Swedish Standard St3施工钢材表面需经抛丸或喷砂处理除锈达瑞典标准 Sa2.5级，涂有车间底漆钢材表面则需要经再次除锈，达到瑞典的手工除锈标准 St3Limitations限制Preceding coat: Workshop suitable zinc-rich epoxy primer, epoxy zinc primer workshop, iron oxide red epoxy primer workshop, inorganic silicate shop primers, chlorinated rubber Antirust Paint aluminum chloride rubber iron red thick slurry-type anti - such as rust paint.Subsequent coat: Thick slurry chlorinated rubber-based paint, acrylic pulp Antirust Paint thick long-lasting, thick rubber chloride-based paste, such as long-term Antirust Paint. 前道配套涂料：环氧富锌车间底漆，环氧锌粉车间底漆、环氧铁红车间底漆、无机硅酸车间底漆、氯化橡胶铝粉防锈漆、氯化橡胶铁红厚浆型防锈漆等。后道配套涂料：氯化橡胶厚浆型面漆、丙烯酸长效厚浆防锈漆、氯化橡胶厚浆型长效防锈漆等。SafetyPrecautions 安全措施The product must be used in painting area by professionals. When painting , please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident. 本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)。施工场所应尽量保持良好通风