HFG-3超薄型钢结构防火涂料.doc

超薄型钢结构膨胀防火涂料产品组成 合成阻燃树脂、阻燃剂、发泡剂、催化剂等。推荐用途 可广泛用于展览馆、候机楼、大型商场、工业厂房、隧道地铁工程等的塑钢结构、普通钢结构、混凝土、木材表面的防火施工。主要特性 涂层薄、装饰性强，不含石棉等有害物质、对人体无毒无害。物理参数 颜色外观 根据客户要求订制理论用量 根据耐火等级不同使用量也不同（性能表）耐火时限 0.5h 涂层厚度0.45mm 1.0h 涂层厚度0.90mm 1.5h 涂层厚度1.30mm 2.1h 涂层厚度2.04mm配 比 单组份包装熟化时间 开桶搅拌后即可涂刷涂装方法 高压无气喷涂、空气喷涂，刷涂均可。稀 释 剂 专用稀释剂，稀释比：5左右干燥时间 25：表干4小时，实干24小时。涂装间隔 10：最短6小时，最长48小时；25：最短6小时，最长24小时；施工条件 0-35,湿度小于80%前道配套 防火专用底漆注：有关涂装配套方案（工艺）请向本公司查询，以进一步获得资料。注意事项 温度低于5，湿度大于85%，风速过大时不宜施工表面处理 表面如已经有其他油漆，需要测试相容性。贮 存 期 6个月包装规格 见桶贴 (或协商)贮存运输 贮存运输应在干燥、阴凉、温度高于0，通风条件良好并避开热源包装容器必须保持密闭，小心装卸，产品运输时，应防止雨淋、日光暴晒，并符合运输部门有关规定。Thin intumescent fire retardant coating for steel structure Composed of synthetic resin products, flame retardant, flame retardants, blowing agents, catalyst and so on. Recommended use can be widely used in exhibition hall, terminals, shopping malls, industrial plants, tunnels and underground engineering of steel structures, ordinary steel, concrete, construction of fire wood surface. Main features of thin coatings, decorative and strong, does not contain asbestos and other harmful substances, non-toxic to humans. Physical parameters Color appearance of the customized according to customer requirements Theoretical amount based on a different level of use of fire is different (performance table) Refractory coating thickness 0.45mm time 0.5h 1.0h coating thickness 0.90mm 1.5h coating thickness 1.30mm 2.1h coating thickness 2.04mm With more than one-component packaging Curing time can be painted after mixing drum opening High pressure airless spray coating method, air spray, brush can be. Thinner thinner, dilution ratio: 5% Drying time 25 : Table dry 4 hours, hard work for 24 hours. Painting interval 10 : minimum of 6 hours, up to 48 hours; 25 : minimum of 6 hours, up to 24 hours; Construction conditions 0-35 , humidity below 80% Supporting the fire-specific primer before the Road Note: For complete painting program (process), please contact our query to obtain further information. Note the temperature below 5 , humidity is greater than 85%, wind speed is too large, not construction Of surface If you already have other paint, need to test compatibility. Storage period of 6 months See Packing drum stick (or consultations) Transport storage and transportation should be stored in dry, cool, temperature is higher than 0 , and well-ventilated containers away from heat sources must be kept closed, careful handling, product