造纸机械专业术语简要.doc

造纸机械专业术语简要中文English计算定量Dimensioning basis weight定量范围Basis weight range纸机产量计算Paper machine Dimensioning production净纸幅宽Trim width在卷纸机上的纸幅宽度Width of sheet on reel(在卷纸机上的)工作车速Production Speed (of sheet on reel)蒸汽压力Steam pressure设计车速Design speed传动车速Drive speed平衡车速Balance speed纸张种类Paper grade流浆箱HeadBox成形部Former压榨部Press Section烘干部Dryer Section施胶机Size Press卷纸机Reel压光机Calender复卷机Winder辅机部分Auxiliary Equipment液压和润滑Hydraulic and lubrication纸机控制Machine ControlsHeadBox流浆箱气垫式流浆箱Air loading HeadBoxFormer 成型部脱水元件dewatering elements陶瓷面板Ceramic cover 胸辊Breast Roll真空伏辊Suction Roll驱网辊Wire driving roll （turning roll）校正辊Guide roll 导网辊Wire roll饰面辊Dandy roll挡水板Baffle board成型板Forming board五片脱水板箱Gravity Foil of 5 strips湿吸箱（带水腿）Wet suction box (with water legs)真空吸水箱（高、低）Suction box (High pressure and low pressure)网部机架framework刮刀Doctor白水盘Saveall pan走台Walkway网布张紧器Fabric Stretcher网布校正器Fabric Guide 胸辊、驱网辊升降装置breast roll and drive roll raising and lowering system提升加压装置Pick-up lift Assemblies摆动器Oscillator高、低压喷水High and low pressure shower引纸水针Tail Squirt切边水针（固定）Edge Squirt cutting，（stationary）专业维护工具Maintenance toolsPress Section 压榨部真空吸移辊Suction roll真空压榨辊Suction press roll沟纹下辊bottom grooved press roll沟纹上辊top grooved press roll石辊Stone roll盲孔辊Blind drilled press roll中心辊Solid center roll纸辊Board bowl（真空）吸水箱Uhle boxes毛布导辊Felt roll毛布张紧器Felt Stretcher毛布校正器Felt Guide 喷淋管Shower pipe机架和横梁Frames and beams底层机架Press basement beams消防栓和水管Hydrant and water hose reels烘干部 Dryer Section烘缸Dryer cylinders引纸辊Paper (lead) Roll导辊Lead rollUNO辊Uno roll弧形辊Spreader roll齿箱Drive gear casing轴承座Bearing housing纸尾割刀TailCutter纸尾引纸Tail threading equipment断纸报警器Sheet break detector引纸风板Foil force扰流棒Dryer bars 第一四组Drying cylinders of No.1 to No.4 group23#24#烘缸No.23, No.24 drying cylinder第五组烘缸No. 5 group drying cylinder引纸绳装置Rope System汽罩Air Hood干燥箱Dryer part干网校正器Fabric stretchers蒸汽接头Steam Joint旋转接头Rotary joint烘缸排水系统Dryer drainage system？传动侧Back side操作侧Tending side蒸汽和冷凝水系统Steam and Condensate System横幅断纸装置Cross machine sheet cutting device机架Frames施胶机size press斜列式施胶机Inclined Sizing press（or Sizer） 施胶机预安装Sizer assembling施胶上辊Top sizing roll施胶下辊Bottom sizing roll保护罩Guard导辊Leading roll张力控制辊Tension measuring roll支架Support卷纸机Reel鹅颈式换卷装置Gooseneck turn-up device断纸装置Mechanical cut-off devices?(slasher)卷纸辊Reel spool卷纸缸Reel drum带式换卷装置Tape turn-up device气动刮刀Air doctor初级臂Primary reeling device次级臂Secondary reeling device横走台Cross machine walkway卷纸机通常不会有横走台引纸绳轮装置Rope tail threading equipment卷纸辊起动装置Reel spool starter卷纸辊存储架Reel spool storage护栏Guard 纸卷存储架Parent roll storage rails压光机Calender弧形辊Spreader roll聚合辊Polymer roll热辊Thermo rollZone-controlled symZ roll置换辊和外壳Replacement roll and shells软辊盖子Soft roll cover飞辊Fly roll冷缸Cooling cylinders冷水接头Cooling water circuit复卷机Winder辅机部分Auxiliary Equipment地脚螺栓Anchor bolts基础板Base plates液压和润滑Hydraulic and lubrication液压系统Hydraulic system稀油润滑Oil lubrication systems油脂润滑Grease lubrication systems空压系统 Air system通风系统Ventilation equipment项目管理Project management安装指导Installation instruction调试开机Testing start-up Production tes