S(SH)型单级双吸中开式清水泵.doc

S（Sh）型单级双吸中开式清水泵采用国内最优秀的水力模型制造，具有高效节能的特点。本系列泵扬程在9M140M；流量为126m3/h12500 m3/h，主要供输送清水及物理化学性质类似于水的温度不超过80的液体之用，适用于城镇给排水、城市供热系统、电站、中央空调、农田排灌、防洪排涝、水利工程等场合。所有泵均可用填料和机械密封,若订货不作说明，以填料出厂。从电动机方向看，泵为顺时针方向旋转。根据需要也可改为逆时针方向旋转，但在定货时应另行提出，以便特殊供应。泵的安装、起动、运转、停止1安装顺序 （1）.将底座放在地基上，在地脚螺栓处垫铁，将用调整其间的契形垫铁的方法校正水平，并适当拧紧地脚螺栓，以防走动。 （2）.在基础与泵地脚之间灌注混凝土。 （3）.待混凝土干涸后拧紧地脚螺栓并重新检查水泵的水平度。 （4）.校正电机轴与水泵的同心度。 （5）.检查电机转向与水泵转向相一致后，装上联轴器的联接柱销。 （6）.水泵进出管路应另设支架支撑，不得由泵体支撑。2水泵的起动与停止 （1）.起动前转动泵的转子，应轻滑均匀。 （2）.关闭出水闸阀，向泵内注水（如无底阀则用真空泵抽吸引水），要保证泵内充满水，无空气窝存。 （3）.如果泵上装有真空表或压力表，要关闭其与泵相连接的旋塞再起动电动机，待转速正常后再打开，然后逐渐打开出水闸阀。 （4）.均匀的拧紧填料压盖上的压紧螺母，使液体成滴状漏出，同时注意填料腔处的温升。 （5）.当停止水泵运转时要先关闭真空表及压力表的旋塞和出水管路上的闸阀，然后切断电机电源。 （6）.长期停止使用时应拆开水泵，将零件上的水檫干，在加工表面涂上防锈油保管好。3. 运转与保养（1）.水泵轴承最高温度不应超过75C。（2）.润滑轴承用的钙基黄油数量应以占轴承体空间的1/3-1/2为宜。（3）.填料磨损时可适当压紧填料压盖，若磨损过多时应予更换。（4）.运转过程中如发现噪音或其它不正常的声音时应立即停车，检查其原因。（5）.定期检查弹性联轴器部件，注意电机轴承温升。型号意义2 5 0 S 6 5 A 12 Sh - 9 A叶轮经切割 叶轮外径切割代号扬程(m) 泵的比转速的1/10取整泵型号 卧式单级双吸清水泵吸入口径() 泵进口直径为12寸 S（Sh）型水泵结构图13形谱图性能参数表型 号流量(m3/h)扬程(m)转速(rpm)轴功率（KW）电机(KW)效率(%)必需汽蚀余量(m)泵重量（Kg）150S100126160202102100932900495964757073724.5168150S50（6Sh-9）130160220525040290025.327.631.337738077.24.5147150S50A（6Sh-9A）11614418043.84035290018.520.924.5307275704.5147150S50B（6Sh-9B）108133160383642290017.218.619.4226570724.5147150S78（6Sh-6）12616019884787029004046.552.4557275.5724.5158150S78A（6Sh-6A）11214418067625529003033.838.5456872704.5158200S42（8Sh-13）216280342484235290034.938.140.2458184.2815180200S42A（8Sh-13A）198270310433631290030.533.134.4377680765180200S63（8Sh-9）216280351696350290055.159.367.8757482.7725230200S63A（8Sh-9A54637.5290041.448.350.9557075705230200S95（8Sh-6）1832803241039585290083.191.71001326279.2755.3240200S95A（8Sh-6A）198270310948780290057.873.577.61106875745.3240200S95B（8Sh-6B）2456829005075745.0240250S14（10Sh-19）36048557617.51411145021.421.722.1308085.8783.8305250S14A（10Sh-19A）32043250413.7118.6145015.415.815.818.57882753.8305250S24（10Sh-13）360485576272419145033.136.936.3458085.8823.5370250S24A（10Sh-13A）34241448222.220.317.4145025.827.628.6378083803.5367250S39（10Sh-9）36048561242.53932.9145054.862.168.6757683.6793.2400250S39A（10Sh-9A）32446857635.530.525145042.349.250.9557479773.2396250S65（10Sh-6）3604856127165561450901101291327578.6723.0516250S65A（10Sh-6A）34248654061545014507286981107477753.0512性能参数表型 号流量(m3/h)扬程(m)转速(rpm)轴功率（KW）电机(KW)效率(%)必需汽蚀余量(m)泵重量（Kg）300S12（12Sh-28）61279090014.51210145030.23233.1378084.8745.5413300S12A（12Sh-28A）52268479211.8108.7145023.323.924.7307278765.5410300S19（12Sh-19）612790935221914145047.95147.6558086.8755.2433300S19A（12Sh-19A）504720829201613145034.838.337.6457180755.2430300S32（12Sh-13）612790900363228145076.37986908086.8804.6709300S32A（12Sh-13A）551720810312624145053.956.262.9758084784.6705300S5857679097265585014501361491652007584.2804.4598300S58A529720893554942145096.6118.61311607981784.4595300S58B50468483547.24337145088.81001081327380784.4592300S905907909369390821450201.9242278.73157479.6754.0840300S90A57675691886787014501902172472807174714.0836300S90B5407209007267571450151.31802002207073704.0832350S16（14Sh-28）97212601440201613.4145068.570.569.7758385.3747.1632350S16A（14Sh-28A）864104412601613.410145054.849.248.9557478707.1630350S2697212601440322622145099.7101.4105.21328587.5826.7670350S26A864111612962621.516.5145076.578.779.8908083736.7668350S44972126014765044371450163.4173.5188.32208187.5796.31105350S44A864111613324136301450120.6130.31361608084806.31100350S75972126014408075651450271.5302.8318.63557885.2805.81200350S75A900117013327065561450220246.6257.12807884795.81195350S75B82810801224595547.51450177.4197.3205.62207582775.81190性能参数表型 号流量(m3/h)扬程(m)转速(rpm)轴功率（KW）电机(KW)效率(%)必需汽蚀余量(m)泵重量（Kg）350S125850126016601401251001450463529.5623.57107080.572.55.41580350S125A787115715381201078614503674325155607078705.41570350S125B697102713639484671450255305343400707772.55.41560500S13162020202340151310.497083.886.297.71107983806.01505500S2216202020234024.52219.4970137.5144.1142.41857784856.01720500S22A140017462020201714970103101941327480826.01710500S35162020202340403528970207.6218.8209.92808588856.01640500S35A1400174620203127219701441511382208285846.01632500S591620202023406859479703743913744507983806.02240500S59A1500187221705749399703153333204007475726.02230500S59B1400174620204640329702402572483157374716.02220500S981620202023401149879970644.8678.1680.38007879.5746.02400500S98A1500187221709683679705095395426307778.5736.02390500S98B140017462020867459970431.1451.1432.85607678756.02380600S22259332413739272318980226.8231.8232.22808688797.02200600S22A216028803240211816970152.5161.1168.11858187847.02485600S32252031703670373227970302.2314.431753000600S32A2304288032403026229702322372312508186847.53000600S32B262822970146.7220847.52520600S472520317036705347409704124564565608488837.53850600S47A230428803240443933970318361380450788886753835性能参数表型 号流量(m3/h)扬程(m)转速(rpm)轴功率（KW）电机(KW)效率(%)必需汽蚀余量(m)泵重量（Kg）600S752520317036708375659705687368219008788807.54300600S75A230428803240686256970507.7579.3649.97108287807.54280600S75B180027103060605551970367.6477.5531.35608085807.54260600S10021603170360011010092970829.61015.61073.8140078858465800600S100A1980300032401009085970691.3875.4914.6120078848265800600S100B180028303060908075970588.2751.9781.3100075828065800800S22432055006480252219730358.7370.2389.945082898674500800S22300044005040161412585163.4190.6193.825080888554500800S22A396048305500191716730246.9254.1261.231583888674480800S22A28003870450013119585123.9133.3131.318583878454500800S32432055006480353229730502.2538.5588.263083898775100800S32300044005200232018585234.9272.3299.931582888675100800S32A38104750550026242173035339843745081868575100800S32A270039604686191714585174.6210.7212.4250808784455100800S47441055006370534737730740.7792.2747900868986657300型 号流量(m3/h)扬程(m)转速(rpm)轴功率（KW）电机(KW)效率(%)必需汽蚀余量(m)泵重量（Kg）800S47300044005200353026585357.4403.9428.145080898647300800S47A381047505500403528730488515193630858885657300800S47A280040604800302522585285.9214.1334.435580888647300800S76441055006370877660730127513251254160082868367888800S76300044005500544943585551.1674.9757.780080878547888800S76A4080510059007263507309881030980125081858267815800S76A28004070500048423758546354160763079868347185800S76B38104750550059524173076580175990080848167762800S76B250037504500403530585358.3425.5459.650076848047762800S80351347905916524842585592.5711.5783.7900848887557898800S80A330045005600464237585502593658.6710828785557892900S23664082809600262318730560590554710848885757600900S23A630078609120232116730476517473630838784757600型 号外 形 与 安 装 尺 寸进口法兰尺寸出口法兰尺寸LL1L2L3L4BB1B2B3B4HH1H2H3H4dDn1Dk1D1n1-d1b1Dn2Dk2D2n2-d2b2150S100150S78（6Sh-6）70838925020013553025027022012048728025130165181502402808-32241001802158-1822150S50（6Sh-9）70838925020013545020027022012045628025130140181502252608-18201001702054-1818200S95（8Sh-6）84246235030024575035035030020060437030185200232002953358-23261252102458-1824200S63（8Sh-9）82245035030024562027035030020056335030175178232002953358-23261252102458-1824200S42（8Sh-13）76541635030023055025035030020054935030160165232002803158-18221252002358-1820250S65（10Sh-6）1121618410320210900450640480350837480302403002525035039012-23281502402808-2324250S39（10Sh-9）989529420360300890440630480350754440352002602525033537012-18242002803158-1822250S24（10Sh-13）953532410350230850400510400300730450302102102725035039012-32282002953358-2326250S14（10Sh-19）883475410350250745330510400300709450302102102725035039012-23282002953358-2326300S32（12Sh-13）10106626405203301040500800600400855520402753052530039543512-232425033537012-1824300S19（12Sh-19）10285636405204001000500800600400830520402502602530039543512-232425033537012-1824300S12（12Sh-28）10285636405204001000500800600400830520402502602530039543512-232425033537012-1824300S9011746445104503301046470620550450898510402683252730040044012-23282002953358-2326300S5811406305104503301070530620550450852510402403102730040044012-232825035039012-2328350S16（14Sh-28）11206195704003701168584740560450950600363103103435044548512-232635044548512-2324350S125143180158056036012105506806005001080620503304102730040044012-232825035039012-2328350S75124768058050036012506006806005001017620502743563435046050012-233025035039012-2328350S4412336755805003601008510680600500980620503003003435046050012-233030040044012-2328350S2611716425805003601040460680600500963620502903003435046050012-233030040044012-2328500S981640912760580400155075010208006001381800554255454250062067020-263530040044012-2328500S591638905760580400164081010208006001300800553704804250062067020-263535046050012-2330500S351374766760580400135063010208006001270800554154154250062067020-263535046050012-2330500S221376750760580400146064010208006001266800554104104250062067020-263540051556516-2632500S131311718760580400155077510208006001251800554104104250062067020-263550062067020-2634600S471695940940760550159574510208006001505950554904904260072578020-303840051556516-2632600S321610882940760550160084010208006001490950554804804260072578020-303850062067020-2635600S221472810940760550179084010208006001476950554604604260072578020-303850062067020-2635600S751694940940760550190094010208006001550950554255504260072578020-303640051556516-2632型 号外 形 与 安 装 尺 寸进口法兰尺寸出口法兰尺寸LL1L2L3L4BB1B2B3B4HH1H2H3H4dDn1Dk1D1n1-d1b1Dn2Dk2D2n1-d2b2600S10016959409407605601900940130010007001550950554255554250062067020-263535046050516-2232700S40197088511009007002020820130010007001710950555275274170084089524-304050062067020-2634700S90219712171200100080020009001300100070018121060505956884570084089524-304050065071520-3346800S2220121097120010008002200850120090060020101250607556954280092097524-304570084089524-3045800S2423651287120010008002350950120090060020851265607556954280092097524-304470084089524-3040800S322163122012001000800210075012001000600190812006066066042800950101524-334460072578020-3044800S472637145712001000800220087512001000600189512006072072042800950101524-334460072578020-3036800S76245113871300100080022651000170013501000210512507070085058800950101524-335460072578020-3054800S8023301270120010008002350115013001000700198512007057074548800950101520-335460072578016-3054安装尺寸（带共同底座）S（Sh） 型泵安装尺寸表 （带共同底座）泵型号电机型号/功率LL1L2L3L4H2H3H4bb1B1Bn-d150S50(6Sh-9)Y200L2-2/37148711701557904251301403755302004504-24150S50A(6Sh-9A)Y200L1-2/30148711701557904251301403755302004504-24150S50B(6Sh-9B)Y180M-2/22148411701557904251301403755302004504-24150S78(6Sh-6)Y250M-2/55164212901559004001301653756102505304-24150S78A(6Sh-6A)Y225M-2/45152711951558104001301653755502505304-24200S42(8Sh-13)Y225M-2/45158412722008184751601654605602505504-24200S42A(8Sh-13A)Y200L2-2/37154412722008184751601654605502505504-24200S63(8Sh-9)Y280S-2/75182614802109704751751784706602706204-24200S63A(8Sh-9A)Y250M-2/55175614202109404751751784706102706204-24200S95(8Sh-6)Y315S-2/1102036158021010255051852004707503507504-24200S95(8Sh-6A)Y280M-2/902036158021010255051852004707503507504-24泵型号电机型号/功率LL1L2L3L4H2H3H4bb1B1Bn-d250S14(10Sh-19)Y200L-4/30166213322358005752102106306303307454-24250S14A(10Sh-19A)Y180L-4/18.5159713322358005752102106306303307454-24250S24(10Sh-13)Y225M-4/45177314442359205752102106305904008504-24250S24A(10Sh-13A)Y225S-4/37174814442359205752102106305904008504-24250S65(10Sh-6)Y315M1-4/132236518552406206206152403007708004509004-24250S65(10Sh-6A)Y315S-4/110231518552406206206152403007708004509004-24250S39(10Sh-9)Y280S-4/751948161024010855652002607506804408904-24250S39A(10Sh-9A)Y250M-4/55187816102401085