Rigging and Slinging 吊装作业

1、Rigging and Slinging吊装作业吊装作业DOS AND DONTS该做和不该做该做和不该做Color codes - 3rd party inspection安全色安全色-第三方检测第三方检测 Use of color codes 安全色使用安全色使用 Display the current correct color code at various locations. 察看各作业点有效安察看各作业点有效安全准确安全色。全准确安全色。Make sure color is clearly visible确保颜色清晰可辨确保颜色清晰可辨What are we doing safe

2、？我们是否安全作业？我们是否安全作业？ Use safety pins 使用安全销。使用安全销。SWL Safe Working Load安全作业载荷安全作业载荷 Choose correct rated equipment 选择准确标定的设备。选择准确标定的设备。 Remember to check SWL (safe working limit) 。 务必检查安全作业载务必检查安全作业载荷。荷。Tag Lines尾绳尾绳 Use tag lines使用尾使用尾绳绳 Tip Hooks at end of tag lines makes it easy to take off / put o

3、n and helps to guide the load better. 使用尾绳安全钩，易拆使用尾绳安全钩，易拆装，协助装卸。装，协助装卸。Tag line hooks尾绳钩尾绳钩 Use hooks to grab the tag lines when it is hard to reach. 当尾绳难以触及到，当尾绳难以触及到，可使用尾绳钩。可使用尾绳钩。 Never go under suspended load. 切勿置身于悬吊货物切勿置身于悬吊货物之下。之下。Cranes 吊机吊机 Ensure crane hooks have a safety feature to preve

4、nt accidental release. 确保吊钩有安全所定确保吊钩有安全所定装置，以防吊物脱落。装置，以防吊物脱落。Containers集装箱集装箱 Ensure the weight limit is displayed prominently on the basket or container. 确保吊笼或集装箱确保吊笼或集装箱标定载荷清晰可见。标定载荷清晰可见。Last Inspection date and rated capacity上次检验日期和核定载荷上次检验日期和核定载荷Chain hoists 链式提升钩链式提升钩 Inspect chain hoists to en

5、sure they are in good condition. 检测确保处于安全状检测确保处于安全状态态 Make sure the safety latch is in place and works correctly.确保确保安全销且工作正常安全销且工作正常Pre-slung tubulars管件提前捆扎管件提前捆扎 Ensure Tubulars are pre-slung coming onboard and for back load.装卸前，确保管装卸前，确保管材提前捆装好。材提前捆装好。 Ensure 2 tag lines for large lifts. 确保使用两确保使

6、用两根尾绳。根尾绳。Crane Signal man- Deck Leader吊机指挥员吊机指挥员-甲板领班甲板领班 Dedicated person to signal the crane operator.全职负责指全职负责指挥吊机司机。挥吊机司机。 Use a hi-vis vest to help identify this person. 着装高清晰着装高清晰度背衫，清晰可辨。度背衫，清晰可辨。Good housekeeping 保存良好保存良好Nylon Slings尼龙绳索尼龙绳索 Use good rigging practices with Nylon slings使用良使用

7、良好的作业规范。好的作业规范。 Store them properly 正确存放。正确存放。Stop Work Authority停止作业权利停止作业权利 Anyone can call a time out for safety, if they think something is unsafe. 若发现不安全现象，任何若发现不安全现象，任何人有权叫停作业。人有权叫停作业。 DO not hesitate. Call Crane Operator if you are not sure something is safe 若不敢肯定是否若不敢肯定是否安全，应立刻呼叫吊车司安全，应立刻呼叫吊

8、车司机。机。Operating an air winch操作气动绞车操作气动绞车 Many accidents have occurred using air winches. 曾发生过许多事故。曾发生过许多事故。 Always use proper procedure. 始终按规定程序做。始终按规定程序做。Now it is correct!Make sure you know emergency stop or air supply cut off.好，准确无误，确保知晓应急停车或切断气源好，准确无误，确保知晓应急停车或切断气源Consider Environmental conditio

9、ns考虑环境 Call time out if the environment conditions prevent safe work. 若环境条件阻碍安全若环境条件阻碍安全作业，请叫停。作业，请叫停。 e.g. high winds, rough seas (for handling boats), poor visibility 大风大风 恶劣海况恶劣海况（操作船）（操作船） -低能见度低能见度Safety pinsMake sure there is adequate stock ready for use安全销，确保足够库存安全销，确保足够库存The R pin small item

10、, BIG on safety “R” 型销型销小工具，大安全小工具，大安全Can you tell if anything is not safe?你能告知不安全点？你能告知不安全点？Hint!Address abnormal conditions注意异常现象注意异常现象Shackle pin in bad condition卸扣销已坏卸扣销已坏Dont try short cuts!不能图方便不能图方便Welding rods for the welder, not for rigging!电焊条是为焊工，不是为吊装电焊条是为焊工，不是为吊装Tape ends of Tag Lines -

11、 NO KNOTS尾绳尾端散开尾绳尾端散开-没打结没打结Rigging disaster!吊装灾难吊装灾难Would you try this?能这样试吗？能这样试吗？Wood planks used as a base to support tool box木板支撑工具箱木板支撑工具箱Safe or unsafe? 安全或不安全安全或不安全Posts need to be inspected too.管柱也需检测管柱也需检测Dont overload either.不能超载不能超载Safe rigging is not a balancing act.安全装运不是只图平衡安全装运不是只图平衡It is about using correct equipment that is fit for use.似乎选择了正确的设备，似乎选择了正确的设备，为我所用。为我所用。Use lifting equipment for the proper task使用提使用提升设备，为我所用。升设备，为我所用。Safety at all times! At work and at home安全？在工作和在家。安全？在工作和在家。Never go under suspended loads切勿置切勿置身于悬重之下身于悬重之下Safe rigging get it right every time!