Y系列Y2系列电动机主要全参数表

1、Y系列，Y2系列电动机主要参数表型号额定额定转速效率功率堵转转矩堵转电流最大转矩噪声振动重量Y系列电动机是一般用途的全封闭自扇冷式鼠笼型三相异步电动机。安装尺寸和功率等级符合IEC标准，外壳防护等级为IP44,冷却方法为IC411,连续工作制（S1）。适用于驱动无特殊要求的机械设备，如机床、泵、风机、压缩机、搅拌机、运输机械、农业机械、食品机械等。Y系列电动机效率高、节能、堵转转矩高、噪音低、振动小、运行安全可靠。Y80315电动机符合Y系列（IP44）三相异步电动机技术条件JB/T9616-1999。Y355电动机符合Y系列（IP44）三相异步电动机技术条件JB5274-91。Y80315电

2、动机采用B级绝缘。Y355电动机采用F级绝缘。额定电压为380V，额定频率为50Hz。功率3kW及以下为Y接法；其它功率均为接法。电动机运行地点的海拔不超过1000m；环境空气温度随季节变化，但不超过40°C；最低环境空气温度为-15C；最湿月月平均最高相对湿度为90%；同时该月月平均最低温度不高于25C。额定转矩额定电流额定转矩1级2级kWAr/min%COS倍倍倍dB(A)mm/skg同步转速3000r/min2级Y80M1-20.751.8283075.00.842.26.52.366711.817Y80M2-21.12.5283077.00.862.27.02.366711.

3、818Y90S-21.53.4284078.00.852.27.02.370751.822Y90L-22.24.8284080.50.862.27.02.370751.825Y100L-236.4288082.00.872.27.02.374791.834Y112M-248.2289085.50.872.27.02.374791.845Y132S1-25.511.1290085.50.882.07.02.378831.867Y132S2-27.515290086.20.882.07.02.378831.872Y160M1-21121.8293087.20.882.07.02.382872.81

4、15Y160M2-21529.4293088.20.882.07.02.382872.8125Y160L-218.535.5293089.00.892.07.02.282872.8145Y180M-22242.2294089.00.892.07.02.287922.8173Y200L1-23056.9295090.00.892.07.02.290952.8232Y200L2-23769.8295090.50.892.07.02.290952.8250Y225M-24584297091.50.892.07.02.290972.8312Y250M-255103297091.50.892.07.02

5、.292974.5387Y280S-275139297092.00.892.07.02.294994.5515Y280M-290166297092.50.892.07.02.294994.5566Y315S-2110203298092.50.891.86.82.2991044.5922Y315M-2132242298093.00.891.86.82.2991044.51010Y315L1-2160292298093.50.891.86.82.2991044.51085Y315L2-2200365298093.50.891.86.82.2991044.51220Y355M1-2220399298

6、094.20.891.26.92.21094.51710Y355M2-2250447298594.50.901.27.02.21114.51750Y355L1-2280499298594.70.901.27.12.21114.51900Y355L2-2315560298595.00.901.27.12.21114.52105司步转速1500r/min4级Y80M1-40.551.5139073.00.762.46.02.356671.817Y80M2-40.752139074.50.762.36.02.356671.817Y90S-41.12.7140078.00.782.36.52.3616

7、71.825Y90L-41.53.7140079.00.792.36.52.362671.826Y100L1-42.25143081.00.822.27.02.365701.834Y100L2-436.8143082.50.812.27.02.365701.835Y112M-448.8144084.50.822.27.02.368741.847Y132S-45.511.6144085.50.842.27.02.370781.868Y132M-47.515.4144087.00.852.27.02.371781.879Y160M-41122.6146088.00.842.27.02.375821

8、.8122Y160L-41530.3146088.50.852.27.02.377821.8142Y180M-418.535.9147091.00.862.07.02.277821.8174Y180L-42242.5147091.50.862.07.02.277821.8192Y225S-43770.4148091.80.871.97.02.279841.8294Y225M-44584.2148092.30.881.97.02.279841.8327Y250M-455103148092.60.882.07.02.281862.8381Y280S-475140148092.70.881.97.0

9、2.285902.8535Y280M-490164148093.50.891.97.02.285902.8634Y315S-4110201148093.50.891.86.82.293982.8912Y315M-4132240148094.00.891.86.82.2961012.81048Y315L1-4160289148094.50.891.86.82.2961012.81105Y315L2-4200361148094.50.891.86.82.2961012.81260Y355M1-4220407148894.40.871.46.82.21064.51690Y355M3-42504611

10、48894.70.871.46.82.21084.51800Y355L2-4280515148894.90.871.46.82.21084.51945Y355L3-4315578148895.20.871.46.92.21084.51985同步转速1000r/min6级Y90S-60.752.391072.50.72.05.52.256651.821Y90L-61.13.291073.50.72.05.52.256651.824Y100L-61.5494077.50.72.06.02.262671.835Y112M-62.25.694080.50.72.06.02.262671.845Y132

11、S-637.296083.00.82.06.52.266711.866Y132M1-649.496084.00.82.06.52.266711.875Y132M2-65.512.696085.30.82.06.52.266711.885Y160M-67.51797086.00.82.06.52.069751.8116Y160L-61124.697087.00.82.06.52.070751.8139Y180M-61531.497089.50.81.86.52.070781.8182Y200L1-618.537.797089.80.81.86.52.073781.8228Y200L2-62244

12、.698090.20.81.86.52.073781.8246Y225M-63059.598090.20.91.76.52.076811.8294Y250M-6377298090.80.91.86.52.076812.8395Y280S-64585.498092.00.91.86.52.079842.8505Y280M-65510498092.00.91.86.52.079842.856Y315S-67514198092.80.91.66.52.087922.8850Y315M-69016998093.20.91.66.52.087922.8965Y315L1-611020698093.50.

13、91.66.52.087922.81028Y315L2-613224698093.80.91.66.52.087922.81195Y355M1-616030099094.10.91.36.72.01024.51590Y355M2-618534799094.30.91.36.72.01024.51665Y355M4-620037599094.30.91.36.72.01024.51725Y355L1-622041199194.50.91.36.72.01024.51780Y355L3-625046699194.70.91.36.72.01054.51865同步转速750r/min8级Y132S-

14、82.25.871080.50.72.05.52.061661.866Y132M-837.771082.00.72.05.52.061661.876Y200L-43056.8147092.20.872.07.02.279841.8253Y2系列电动机是Y系列电机的更新换代产品，是一般用途的全封闭自扇冷式鼠笼型三相异步电动机。它是我国九十年代最新产品，其整体水平已达到国外同类产品九十年代初的水平。该产品应用于国民经济各个领域，如机床、水泵、风机、压缩机，也可适用于运输、搅拌、印刷、农机、食品等各类不含易燃、易爆或腐蚀性气体的场合。Y2系列电机的安装尺寸和功率等级符合IEC标准，与德国DIN426

15、73标准一致，也与Y系列电机一样，其外壳防护等级为IP54,冷却方法为IC411，连续工作制（S1）。采用F级绝缘，温升按B级考核（除315L2-2、4,355全部规格按F级考核外），并要求考核负载噪声指标。Y2系列电动机额定电压为380V,额定频率为50Hz。功率3kwt以下为Y接法，其他功率均为接法。电动机运行地点的海拔不超过1000m；环境空气温度随季节变化，但不超过40°C；最低环境空气温度为-15C；最湿月月平均最高相对湿度为90%；同时该月月平均最低温度不高于25C。Y2系列电动机有两种设计，一种是适用于一般机械配套和出口需要，在轻载时有较高效率，在实际运行中有较佳节能效

16、果，且具有较高堵转转矩，此设计称为Y2-Y系列。中心高63355mm,功率从0.12315kW。电动机符合JB/T8680.1-1998Y2系列（1P54）三相异步电动机（机座号63355）技术条件。型号含义：如Y2-200L1-2Y：“Y2”表示异步电动机第二次改型设计,“200”表示中心高，“L”表示机座长短号，T”表示铁心长度序号，“2”表示极数，“Y”表示第一种设计（可省略）。第2种设计是满载时有较高效率，更适用于长期运行和负载率较高的使用场合，如水泵、风机配套，此设计称为Y2-E系列，中心高80280mm，功率从0.5590kW。电动机符合JB/T8680.2-1998Y2系列（1P

17、54）三相异步电动机（机座号80280）技术条件。型号含义：如Y2-200L2-6E：“Y2”表示异步电动机第二次改型设计，“200”表示中心高，“L”表示机座长短号，“2”表示铁心长度序号，“6”表示极数，“E”表示第二种设计。型号额定功率额定电流转速效率功率因数最大转矩最小转矩堵转转矩堵转电流噪声振动速度额定转矩额定转矩额定转矩额定电流空载空负载之差kWAr/min%cos倍倍倍倍dB(A)mm/s2极Y2-63M1-20.180.5282065.00.802.21.62.25.56121.8Y2-63M2-20.250.728206&00.812.2.1.62.25.56121.

18、8Y2-71M1-20.371.0282070.00.812.21.62.26.16421.8Y2-71M2-20.551.4282073.00.822.31.62.26.16421.8Y2-80M1-20.751.8283075.00.832.31.52.26.16721.8Y2-80M2-21.12.6283077.00.842.31.52.27.06721.8Y2-90S-21.53.4284079.00.842.31.52.27.07221.8Y2-90L-22.24.9284081.00.852.31.42.27.07221.8Y2-100L-236.3288083.00.872.3

19、1.42.27.57621.8Y2-112M-248.1289085.00.882.31.42.27.57721.8Y2-132S1-25.511.0290086.00.882.31.22.27.58021.8Y2-132S2-27.514.9290087.00.882.31.22.27.58021.8Y2-160M1-21121.329308&00.892.31.22.27.58622.8Y2-160M2-21538.8293089.00.892.31.22.27.58622.8Y2-160L-218.534.7293090.00.902.31.12.27.58622.8Y2-180

20、M-22241.0294090.00.902.31.12.07.58922.8Y2-200L1-23055.5295091.20.902.31.12.07.59222.8Y2-200L2-23767.9295092.00.902.31.12.07.59222.8Y2-225M-24582.3296092.30.902.31.02.07.59222.8Y2-250M-255101.0297092.50.902.31.02.07.59323.5Y2-280S-275134.4297093.00.902.30.92.07.59423.5Y2-280M-290160.2297093.80.912.30

21、.92.07.59423.5Y2-315S-2110195.0298094.00.912.20.91.87.19623.5Y2-315M-2132233298094.50.912.20.91.87.19623.5Y2-315L1-2160279298094.60.922.20.91.87.19923.5Y2-315L2-2200348298094.80.922.20.81.87.19923.5Y2-355M-2250433298095.30.922.20.81.67.110323.5Y2-355L-2315544298095.60.922.20.81.67.110323.54极Y2-63M1-

22、40.120.4137057.00.722.21.72.14.45251.8Y2-63M2-40.180.6137060.00.732.21.72.14.45251.8Y2-71M1-40.250.8138065.00.742.21.72.15.25551.8Y2-71M2-40.371.0138067.00.752.21.72.15.25551.8Y2-80M1-40.551.6139071.00.752.31.72.45.25851.8Y2-80M2-40.752.0139073.00.762.31.62.36.05851.8Y2-90S-41.12.9140075.00.772.31.6

23、2.36.06051.8Y2-90L-41.53.714007&00.792.31.62.36.06051.8Y2-100L1-42.25.2143080.00.812.31.52.37.06451.8Y2-100L2-436.8143082.00.822.31.52.37.06451.8Y2-112M-448.8144084.00.822.31.52.37.06551.8Y2-132S-45.511.8144085.00.832.31.42.37.07151.8Y2-132M-47.515.6144087.00.842.31.42.37.07151.8Y2-160M-41122.31

24、4608&00.842.31.42.27.07552.8Y2-160L-41530.1146089.00.852.31.42.27.57542.8Y2-180M-418.536.5147080.50.862.31.22.27.57642.8Y2-180L-42243.2147091.00.862.31.22.27.57642.8Y2-200L-43057.6147092.00.862.31.22.27.27942.8Y2-225S-43769.9147592.50.872.31.22.27.28142.8Y2-225M-44584.7147592.80.872.31.12.27.281

25、32.8Y2-250M-455103.0148093.00.872.31.12.27.28333.5Y2-280S-475139.6148093.80.872.31.02.27.28633.5Y2-280M-490166.9148094.20.872.31.02.27.28633.5Y2-315S-4110201148094.50.882.21.02.16.99333.5Y2-315M-4132240148094.80.882.21.02.16.99333.5Y2-315L1-4160287148094.90.892.21.02.16.99733.5Y2-315L2-4200359148095

26、.00.892.20.92.16.99733.5Y2-355M-4250443148095.30.902.20.92.16.910133.5Y2-355L-4315556148095.60.902.20.82.16.910133.56极Y2-71M1-60.180.790056.00.6621.51.945271.8Y2-71M2-60.251.090059.00.6821.51.945271.8Y2-80M1-60.371.390062.00.721.51.94.75471.8Y2-80M2-60.551.890065.00.722.11.51.94.75471.8Y2-90S-60.752

27、.391069.00.722.11.525.55771.8Y2-90L-61.13.291072.00.732.11.325.55771.8Y2-100L-61.53.994076.00.752.11.325.56171.8Y2-112M-62.25.694079.00.762.11.326.56571.8Y2-132S-637.496081.00.762.11.32.16.56971.8Y2-132M1-649.896082.00.762.11.32.16.56971.8Y2-132M2-65.512.996084.00.772.11.32.16.56971.8Y2-160M-67.517.

28、097086.00.772.11.326.57372.8Y2-160L-61124.297087.50.782.11.226.57372.8Y2-180M-61531.697089.00.812.11.227.07362.8Y2-200L1-618.538.698090.00.812.11.22.17.07662.8Y2-200L2-62244.798090.00.832.11.22.17.07662.8Y2-225M-63059.398091.50.842.11.227.07662.8Y2-250M-63771.098092.00.862.11.22.17.07863.5Y2-280S-64

29、585.998092.50.862.01.12.17.08053.5Y2-280M-655104.798092.80.862.01.12.17.08053.5Y2-315S-67514198093.50.862.01.027.08553.5Y2-315M-69016998093.80.862.01.027.08553.5Y2-315L1-611020698094.00.862.01.026.78553.5Y2-315L2-613224498094.20.872.01.026.78543.5Y2-355M1-616029298094.50.882.01.01.96.79243.5Y2-355M2

30、-620036598094.70.882.00.91.96.79243.5Y2-355L-625045598094.90.882.00.91.96.79243.58极Y2-80M1-80.180.970051.00.611.91.31.83.35281.8Y2-80M2-80.251.270054.00.611.91.31.83.35281.8Y2-90S-80.371.570062.00.611.91.31.84.05681.8Y2-90L-80.552.270063.00.612.01.31.84.05681.8Y2-100L1-80.752.470071.00.672.01.31.84.05981.8Y2-100L2-81.13.470073.00.692.01.21.85.05981.8Y2-112M-81.54.571075.00.692.01.21.85.06181.8Y2-132S-82.26.07107&00.712.01.21.85.06481.8Y2-132M-837.971079.00.732.01.21.86.06481.8Y2-160M1-8410.372081.00.732.01.21.96.06882.8Y2-1