涂装专业词汇中英文

1、Alkali degreasing碱液脱脂法Alkali degreasing碱液脱脂法碱液脱脂剂离子交换法 槽液管理 乳化脱 脂法 （剂 ） 化学除锈剂 化 学脱脂法 化学成膜 黄锈（磷 化处理中） 铬酸处理（钝 化） 铬酸盐处理 硅酸钠 打 锈 除锈 （同酸洗、酸蚀） 酸洗（同除锈） 酸性阻蚀剂 喷砂纯水（洗） 喷丸 新鲜水洗 蒸气磷化处理 喷射式前处 理 总酸度 促进剂 脱脂 脱 脂剂脱脂，除锈二个合一灰蓝色 三氯乙烯脱脂（蒸 气） 三氯乙烯 四氯乙烯 半浸式前处理P比磷化处理剂 皮膜处理 膜重 表面预处理 表面调整表面调整剂 溢流喷射 式前处理 全浸式前处理 前处 理 前处理剂 烘干水

2、份alkali cleaner ion exchange solution control, both control emulsion edgreasing(cleaner) chemical decaling ;chemical derusting chemical degreasing chemical conversion coating rust cause on phosphate coating chromate coaring, chronating chromate coating chromating sodium silicate descaling descaling,

3、derusting acid pickling,pickling acid pickling in hibitor sankblasting ,blast cleaning deionized water (rinsing) shot blasting fresh water rinsing steam phosphating spray pretreatment system total acid accelerator degreasing cleaner phosphoric acid cleaning 处理剂 blue color vapor degreasing trichloroe

4、thylene parchlorlerhylene,carbontetrachlchlcride half dip pretreatment system P ratio phosphating chemicals chemical conversion coating coating weight surface treatment surface conditioning surface conditioner flood spray pretreatment system full dip pretreatment system pretreatment pretreament chem

5、icals drying off游离酸度 溶剂脱脂 预洗净 预 热水洗 锌盐磷化处理 锌盐磷 化膜 铁盐磷化膜 阳极电泳 阳 极接地法 气喘、喷流间断 湿 碰湿 涂面漆 空气喷涂 吹风 无空气喷涂 过喷涂 隔膜（电 极）电泳涂装 重叠涂装 汽油 打磨 阴极电泳涂装 干打磨喷枪距离 喷枪移动速度 机械 打磨 表面准备 （同底材面调 整）空气雾化式静电涂装 黑皮 （黑色氧化皮）修饰性打磨 底材（基底） 涂 底漆浸涂 喷涂 喷涂影 局部修补 涂三次烘三次 拖式浸涂 静电 涂装 静电粉末涂装 静电雾化 式静电涂装法 统刮腻子 试涂 装 更新期揩涂调制调色泳透力电泳free acid solvent d

6、egreasing precleaning hot water prerinsing ziue phosphating phosphatetreatment zinc phosphating coating iron phosphating coating anodic electro deposition anode earth method spitting spray ,fluttering wet on wet top coat air spraying air blow airless spraying over spray membrane system electro depos

7、ition over coating wet sanding with gasoline cathodic electro deposition dry sanding gun distance spray gun velocity mechanical sanding surface preparation electrostatic air atomixing spray metode mill scale finish sanding substrate primer coating dipping,dip coating spraying ,spray coating (atomizi

8、ng) fan pattern spot repair three coat three bake slipper dipping electrostatic coating electrostatic powder coating electrostatic rotary atomizing spray method all pattying application trial turn-over pad application,padding (paint) mixing color matching throwing power electro phoresis电渗 电泳涂装打磨涂装涂装

9、间隔涂装体系涂装工艺 涂装技术要求涂着效率 同色封底涂层涂中涂层重新涂装 涂布面积比 刷涂被涂物雾化局部打磨淋涂 粉末电泳涂装法 刮涂修补涂装热喷涂抛光 金属闪光漆涂装 超滤 流化床涂装 辊涂 （暗）红外干燥 湿涂 膜 表干 加热干燥 干 燥 强制干燥 完全干 燥，完全electro osmosis electrodeposition,electrocoating (ED) sanding,grinding painting,coating ,finishing interval between coats,coat interval paint system ,coating system

10、paint process painting sepctification transfer efficiency color sealer surface coating ,sealer coating repainting spreading rate brush application ,brushing,brush coating work atomizing detail sanding ,defect sanding flow coating electrophorectic powder coating knifing ,knife application touch up ho

11、t spraying ,hot spray coating masking polishing mettalic coating utra filtration(UF) flridized powder bed coating application by roller,roller coating (dark)infrared drying ,infrarde drying,infrarde baking wet film sand dry ,surface dry baking,thermosetting drying forced drying dry-hard,dry-through,

12、hard dry,dry through,baking 固化 ultra violer curing set to touch ,dust free,dry to touch air drying cold curing 燥 ) curing by polymerization drying by evaporation 干燥 ) setting ,flash off electoro beem curing ,radiation curing 干燥) hot air drying couvection drying紫外线固化干燥触指干燥 自然干燥（常温干聚合干燥蒸发干燥（同挥发晾干 电子束固

13、化（辐射热风干燥，对流oil surfacer ash content cathodic electrod eoposition flexibility nonvolatile content(matter),solids content,heating residue skinning bake schedule pigment volume,pigment volume concentration pigment contentdilution stability redueed paint caking coulomb efficiency clear clear lacquer syn

14、thetic resin paint guide coat anticorrosive coating ,rust inhibiting paint ,corrosion resistant coating,antirust paint防锈涂 料 primer chassis black paint zinc rich primer water borne paint料 )干燥tack free ,tack dry 燥) baking stoving acrylic resin paint acryl lacquer application solid amine content alkyd

15、resin paint cobwebbing etching grimer 底 漆 ) enamel non aqueous dispersion paint半固化干燥 （指触干烘干 丙烯酸树脂涂料 热塑性丙 烯酸涂料 施工固体份 胺浓度 醇酸树脂涂料 拉丝现象 腐蚀底 漆（同磷化底漆，活性磁漆 非水分散型 涂料 油性二道浆 灰分 阴 极电泳涂料 弹性，可弯曲 性 不挥发分 结皮性 干燥 时间 颜料体积比率 颜料 分（ P、W、稀释稳定性 稀C）释好的涂料 凝 结性库仑效率清漆硝基清漆 合成 树脂涂料 二道 浆water soluble resin paint ,water soluble r

16、esin coating stomeguard coating底漆涂料底盘黑涂料 富锌底漆 水性粉笔料（水系涂compatiblity ,compotible spray mist compatibiliity touch up primer thixotropic ,thixotropy antichippimg paint,chip resistant paint水溶性树脂涂料 抗石 击性涂料 相溶性 抗 漆雾污染性 局部修补 底漆 触变性 抗崩裂 性丙烯酸改性的醇shelf life ,storage stability,ca nstability grainnin g,bitty,se

17、ed flat pain t ,flat oikl pain t ,mat paint electrocoati ng ,coat ing for electrodepositi onfilm formi ng age nt ,film formi ng in gredie nt ,film former,film forming materialcolor surfacer coati ng ,pa int virgin pain t ,UN-cut paint two comp onent paint n itrocellulose lacquer, nitrocellulose coat

18、i ng thermosetting (themoplastic ) acrylic paint 脂涂料贮藏稳定性细度、粒度无光涂料电泳涂料涂膜主要成分同色 涂料涂料原漆双组 份涂料硝基漆热固（塑）性丙烯酸树con siste ncy viscosity high solid lacquer high solid paint binder putty light curing coating vehicle phenolic coati ng ,phe nolic resin paint un saturated polyester paint稠度粘度高固体份硝基漆高固体分型涂料基料腻子光固化

19、涂料漆料酚醛树脂涂料不饱和聚脂涂料primer surfacer blocki ng powder paint an ti-corrosi onwax ,an ti-rust wax pot life ,pot stability寿命polyester puttywater dispersible paintmillbase ,milli ng base solve ntless coati ng ,solve nt free paint料metallic en amel,metallic pain t ,metallic pigme nted paint 磁漆底漆二道浆粘结、结块粉末涂料防锈

20、蜡活化期、活化聚酯腻子水分 散型涂料研磨 色浆无溶剂型涂金属闪光色thermosett ing paint oil paint oil le ngth lacquer lacquer en amel bitu minous paint leveli ng varnish acrylate resins acrylic acid烘烤型涂料油 性涂料油度硝 基清漆硝基磁 漆沥青涂料流 平性清漆丙烯 酸系树脂丙烯 酸acryl modified slkyd res in酸树脂asphalt (bitume n) ami no resi n alkyd resi n epoxy res in oil

21、free alkyd resin 脂沥青氨基树脂醇酸树脂环氧树脂无油醇酸树外部增塑化 干性油天然硬沥青 甘油胶化时间皂化 价红花油脂肪酸 硝化棉有机硅树脂 多元酸多元醇天然 树脂（油）内部塑 化热固性热泪盈眶 可塑性蓖麻油酚醛 树脂不干性油氧化 沥青聚醋聚丁二烯 甲基丙烯酸碘值石 棉粉铝粉铝粉膏 色光、色头红丹碳 黑颜料吸油量白 土、陶土防锈颜料 填料、体质颜exter nal plastici zati on dryi ng oil hils on ite glyceri n gel time ,time for gelati on sap on ificati on value ,sap

22、on ificati on nu mber safflower oil carbooxyl acid n itrocellulose silic one resin polybasic acid polyhydric alcohol polyol n atural res in (oil ) internal plasticizatio n thermisettig property thermoplastic ,thermoplasticity,thermal plasticity castor oil phe nol resin nondrying oil blow n asphalt p

23、loyester polybutadie nee methacrylic acid iodi ne value ,iodi ne nu mber asbesti n alumi nium flake powder,alumi nium pigme nt powder alu minium flake paste,alu minium pigme nt paste tin t(i ng) shade,reduce shade red lead carb on black pigme nt oil absorpti on value clay rust preve nti ng pigme nt,

24、 rust in hibit ing pigme nt exte nder filler ,exte nder pigme nt料滑石粉钛白着色颜料（力）talcwhite tiianium pigment color pigment (strength)lead pigment titanum dioxide permanent red fast yellow dispersion red iron oxide inorganic pigment organic (color) pigment leafing sellosolves (solvent) alcohols(solvent) i

25、sopropyl alcohol ethers(solvent ) esters (solvent) ethyl alochol diluent xylene ketones (solvent) high boiling point solvent, high boiler ,slow solvent ethyl acetate aliphatic hydrocarbons (solvent)合铅系颜料 二氧 化钛 永固红 耐晒黄 分散 铁红 无机颜料 有同颜料 漂浮醇醚溶剂 醇系溶剂 异丙醇 醚系熔剂 酯 系溶剂 乙醇 稀释剂 二甲苯酮系溶剂 高沸点溶 剂 乙酸乙酯 脂肪族 系碳氢化助溶剂溶

26、纤剂 乙酸溶纤剂 煤焦油溶剂 煤油 甲苯 丁醇 白醇 甲乙酮 胺 表面活性剂 增塑剂 稀 释剂 金属皂 固化剂 防 止氧化剂 紫外线吸收剂 苯甲酸二丁酯 稀料 静 电防止剂 流挂防止剂 沉淀防止剂 消光剂 涂 料用稀料 硝基漆用稀料物溶剂 cosolvent cellosolve cellosolve acetate solvent naphtha kerosene ,kerosine toluene butyl alcohol ,butanol mineral spirit,petroleum spirit methyl ethyl ketone amine surface active a

27、gent surfactant plasticizer reducidility metallic soap ,metal soap harder ,curing abent antioxdant ,oxidant inhibitor ultrviolet absorber dibutyl phthalate thinner antistatic agent antisag agent antisetlle agent flatting agent paint thinner lacquer thinner防潮剂 流变性控性 粘性纸胶带 干打磨 用砂纸 纸质遮盖用 胶带 打磨砂纸 打 磨砂布

28、清洗用溶剂 耐水性砂纸 耐热遮 盖用胶带 粘性纱布 粘灰清漆 脱漆剂 抛光剂 打磨网 遮 盖用胶带 遮盖力 面漆层 涂面漆的适 应重复涂装的适玻璃化点 镜面光 泽度 打磨性 浸透 性 鲜映性 耐碱性 耐过烘性 耐盐水性 耐挥发油性 耐久性 耐弯曲性 耐候性 耐酸性 耐冲击性 耐蚀性 耐水性 耐 洗净性 耐崩裂性 耐热性 耐沸水性 耐摩耗性 耐药品性 耐油性 耐溶剂性 光泽retarder ,retarder solvent rheology control paper tack stick dry sandpaper crape masking abrasive paper sandpaper

29、 abrasive colth ,sanding cloth washing solvent (flame retarding solvent ) water proof abrasion sandpaper heat stabe maskingtape tack rag tackrag varnish paint remover polishing compound poly net masking tape hiding power,obiterating power ,covering power ,opacity top coat,finish coat ,finishing coat

30、 overcoatability 性 recoatability 应性 glass transition point specular gloss,specular reflection grindability pentrability distinctness of image alkaliproof ,alkali resistance overbake resistance salt water resistance gasoline resistance durability flexibility ,elasticity weather resistance, weathering

31、 property,weatherproof acidproof ,acid resistance impact resisrance corrosion resistance water resistance,waterproof washability chiping resistance heat resistance boiling water resistance abrasion resistance chemical resistance oil resistance ,oilproof solvent resistance gloss无光泽 涂膜污染性 涂膜的外观 涂面 半 光

32、泽附着力溶出 裂解 老化 油 缩孔 雨水痕迹 气泡 （电泳气泡） 电泳 湿漆膜脱落 电泳缩 孔 电泳针孔 掉色 色差 色不均 色分离 湿污染 啄伤 气体裂 纹白化 颜料沉降 打磨器纹 涂密封 胶不良 底层污染flat stain resistance appearance of paint film,paint film appearance surface of paint film semigloss abhesion elusion ,bleeding degradation ageing oildeaetting,oil cratering water slaining (marke)

33、 bubble ,bubbling (bubble trace on ED film) peeling off wet Ed film ED cratering pinpole on ED film discollration off color mottling flooding wet contamination pecking gas checking,gas crazing blushing pigment sedimentation sanding scratch sealing failure bleeding stain,spot,spotting crinkling,shriv

34、elling,wrinkling,rivelling suction ,absorption water bubbling hiding failure scrack low distinctness of image intercoat adhesion failure fading dripping sagging run curtaining sag wrinkle chipping chalking thin Edcoating ,no ED coating dulling,loss of gloss,matting flashing sand scratch too much fil

35、m thickness粘污 起皱 吸收 水泡 遮盖不良 划伤 鲜映性低 层间剥落 退色流痕 下沉 流挂皱纹起皱 碎落 粉化 泳透性差 失光 光泽不匀 打磨划伤 涂膜过peel ingdry con tam in ati on dirt ,seed crateri ng,fish eye 眼sagg in g,r uning bleed ing thin paint skips peeli ng crawli ng,fish eye,crateri ng ding and dent solderi ng pin hole pin hole blisteri ng bunp,cluster blu

36、shing blistering mar hair cracking sanding scratch cratering discorloration swelling shading comet star pineple break line failure metallic seeding after tack under bak ing grinding scratch orange peel solve nt popp ing ,pin holes cracki ng,hair crach in g,check ing ,crag in g,alligatey ing crocodil

37、 ing涂膜剥落干污染涂料颗粒涂料缩孔，鱼流淌渗色涂得 太薄漏涂剥离 缩孔鱼眼钣金凹 凸焊药针孔针孔膨泡颗粒发白起泡触伤痕鬓状裂纹砂纸纹凹坑变色膨润 模糊（阴影）星 状不平保护不良 金属颗粒返粘未 烘干透锂刀纹桔 皮气泡孔裂纹鬓状裂纹浅裂纹龟裂鳄鱼皮裂纹丝状腐蚀性试验 遮盖力试验纸filiform corrosi on test hidi ng chart wet film thick ness gauge湿漆膜厚度量远规杯突试验机永久Erichsen film distensibility meter Elcometersalt spray test ing ,salt spray test

38、 pen cil hard ness test carb on arc appearance inspection dilution stability test dilytion test,reducibility test磁性测厚仪盐水喷 雾试验铅硬度试验 碳弧灯外观检查稀释稳定性试验稀释试验氙气灯 库仑效率 试验 弯曲试验 石 击崩裂试验法 遮 盖力测验法 斯端 马粘度计 交叉横 割 恒温恒湿箱 光 泽计 色差计 试验 板 试验样板 自然 曝晒试验 冲击试 验 冲击试验仪 取 样器 斯惠特硬度 计 疤形腐蚀试验人工耐候性试耐过烘性耐温水试耐候性试耐湿试耐湿试验耐药品性金刚石冲泳透性试细度

39、刮板杜邦式冲热循环试曝晒试验B 型粘度xenone lamp coulomb efficiency test bending test gravelometer cryptoneterKrebs -Stomer viscometer,Stomer viscometer cross cut constant temperature and humidity cabinet gloss meter color difference meter test paneltest piece,coupon,specimen outdoor wethering test ,outdoor exposure

40、test imact test,impact testing ,chip test impact tester samplerSward hardness rocker scab corrosion test accelerated weathering test,accelerated weathering ,artificial weathering 人 工耐 候性试验accelerated weathering tester 验机 over bake resistance test 试验 hot water resistance test 验 weathering test ,weath

41、ering 验 humidity resistance test 验 humidity box 盒 chemical resistance test 试验 diamond shot test 击试验法 throwing power 验 grind gauge ,fineness gauge Du-pot impact tester 击试验 heat cycle test 验 exposure rackBroodfield viscometer 计 portable distinctness of image glossmeter鲜映测计(PGD )specific gravity cup sp

42、ecified achromatic light film applicator器Ford cup ,Ford viscosity cup compo und corrosi on test(CCT)tack free test ,pri nt test比重杯标准光源涂膜涂布福特杯复合腐蚀试验不粘性试验漆膜厚度计压送式喷枪油漆增压箱 橡胶磨块木质磨块换 色装置水幕空气帽空 气静化器空气压缩机 气动打磨机气动除尘器 空气压力调整无气喷枪无气喷涂装置自动滚筒式过film thick ness gauge pressure feed type spray gun pressurw tank ,pre

43、ssure feed paint container rubber patten 子 patten colors changer water curtain air cap air clea ner air compressor air san der air duster air transformer 器 airless spray gun airless apraying equipment auto roll filter滤器auto absorber orbital san derpressure cup rotary air san der磨机reverser clea nstir

44、ring equipmentrotary atomiz ing electrostatic spray ing equipme nt喷涂装置steel spatrlaheati ng oil separater 离装置自动吸水器眼眶 形打磨机 加压杯转动型气动打转动式清洁器搅拌装置旋杯式静电钢刮刀加热油水分dryspray booth wood spatula supply duct suppl ying fan air supply house high voltage regulatoras.器干式喷漆室木刮勺供气风管供气风机空调装置高压发生surge chamber缓冲容器side ro

45、om robot by C.Pteaching method 手 automatic air duster 侧调漆间 装置 automatic solution machine 理装置 automatic sanding CP 式机械 machine 装置 automatic washing machine 置 automatic apraymachine 机 automatic electrostatic spray machine 涂装装置 自动吹风 automatic dust off machine 置 automatic spray 置 bravity spraygun 枪 deio

46、nized water generator pad dipping tank water 自动溶液管washing spray booth 室 scraper spray gun spray system pretreatment equipment 置 spray booth electrostatic coating equipment 装置 electrostatic powder coating equipment 涂装装置 semifolw sealing 密封胶 side reciprocator duct touching tracer 装 置 double action san

47、der 机DC power equipment disc sander 机自动静电hand electrostatic spray gun自动除尘装 自动涂装装重力式喷纯水装置 托盘（板） 浸槽 水洗式喷漆刀喷枪 喷射式前处理装喷漆室静电涂装静电粉末半浮动涂侧喷机 风筒（管） 修整 追踪双动打磨直流电源盘式打磨手提式静电喷枪 hand electrostatic spray equipment ceiling filter器 electrocoating equipment装置 painting robot 手 cup of spray gun paint手提式静电喷涂装置circulating system 统 mixing room spray gum tip 嘴 needle exhaust air washing system 净装置 brush 式机 械手 full dip pretreatment system equipment 理装置 top reciprocator 机 knife,spatula ultra