维修电源模块

1、生效期：2009-7-总页数:12 更改 部品确认（成品、半成品、原材料132寸32寸163并2生效期：2009-7-总页数:12 更改 部品确认（成品、半成品、原材料132寸32寸163并2第 1 页，共 10第 1 页，共 10No.1 Haier Road,Haier Information Property :号第 2 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELL

2、OFAPPARATUSESORWITHOUTSpec Rev.规格书版leRev.日结构确电气确第 2 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTSpec Rev.规格书版leRev.日结构确电气确Supply Overview 1 ectrical Characteristics Overview (输入特性1.1 1.2

3、etrical Characteristics Overview (输出特性1.2.1.1 Table 2.1 Output Voltage1（to system board), Current & (负载调整率最大冲击电流超出电源可有会OCP保护，电流脉冲宽度在10ms以内，不会触发电源OCP1.2.1.2 Table 2.2 Output Voltage2(to LED light bars) & 灯条规格：单LED灯3.2V/120mA，单灯条16串3并，共2灯条61.2.2 Table 3 DC Output Ripple & Noise. (输出波纹和噪声load（调光状态Note:

4、 1)Measurements shall be made n oscilloscopewith 20MHz bandwidth 示波器设置在20MHz2）Outputshallbebypassedattheconnectorwi electrolytic simulate system loading .输出并联0.1uF的陶瓷电容和10uF0.1 uF ceramic and a 第 3 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORSuppl

5、y Overview 1 ectrical Characteristics Overview (输入特性1.1 1.2 etrical Characteristics Overview (输出特性1.2.1.1 Table 2.1 Output Voltage1（to system board), Current & (负载调整率最大冲击电流超出电源可有会OCP保护，电流脉冲宽度在10ms以内，不会触发电源OCP1.2.1.2 Table 2.2 Output Voltage2(to LED light bars) & 灯条规格：单LED灯3.2V/120mA，单灯条16串3并，共2灯条61.

6、2.2 Table 3 DC Output Ripple & Noise. (输出波纹和噪声load（调光状态Note: 1)Measurements shall be made n oscilloscopewith 20MHz bandwidth 示波器设置在20MHz2）Outputshallbebypassedattheconnectorwi electrolytic simulate system loading .输出并联0.1uF的陶瓷电容和10uF0.1 uF ceramic and a 第 3 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PRO

7、PERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTOutput Ripple (Max) and NoiseOutput Ripple MinvoltageTypevoltageMaxvoltagePerchannal Total MincurrentMaxcurrent/Input voltage 90Vac-264Vac（交流掉电后，瞬时关断Normal voltage range 100Vac-Frequenc

8、y Max input AC 100Vac/3.5A Inrushcurrent(coldstart) 浪涌电流(冷Efficiency (full Harmonic GB17625.0-1998/IEC61000-3-2 CALSS er loss 待机功耗Input 3）1.2.3 Output Transient Response.(输出动态响应Table 4 Test condition. (测试条件1.2.4 5 DC Hold-Up Time.(输出保持时间Note:All dc full 6 Turn On & Turn Off.(输出超调Table DC output volt

9、age rise time (输出上升时间The voltages shall rise from 10% to 90% their On/Off Control (ON/OFF控制er supply DC outputs (without+5.0VSB) shall be enable high-level n The+5.0 VSB is on whenever the er is 第 4 页，共 页青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDA

10、STHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTOutput /3）1.2.3 Output Transient Response.(输出动态响应Table 4 Test condition. (测试条件1.2.4 5 DC Hold-Up Time.(输出保持时间Note:All dc full 6 Turn On & Turn Off.(输出超调Table DC output voltage rise time (输出上升时间The voltages shall rise from 10% to 90% their On/Off

11、 Control (ON/OFF控制er supply DC outputs (without+5.0VSB) shall be enable high-level n The+5.0 VSB is on whenever the er is 第 4 页，共 页青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTOutput /Output 110

12、Vac input & Full 220Vac input & Full Over shoot voltage(V)Turn onTurn off12Output 120Vac 220Vac Voltage Tolerance Slew Load 100%-50%,Min-Slew Slew Load 幅度0-100%，150-200Hz，50%Table Protection:(保护功能DC Over Protection.(输出过压保护）,Table11 Output Short Circuit Protection.(输出短路保护Reset Shutdown.(保护功能复位ower su

13、pply o er 电源进入保护状态后，ACIsolation (绝缘性能(绝缘性能第 5 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTInput To Table Protection:(保护功能DC Over Protection.(输出过压保护）,Table11 Output Short Circuit Protectio

14、n.(输出短路保护Reset Shutdown.(保护功能复位ower supply o er 电源进入保护状态后，ACIsolation (绝缘性能(绝缘性能第 5 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTInput To DC500V/ 10M (room Output Shut Output Max. Over Shu

15、t Ps-on 2.5V,2.5V时输入阻抗不小于10K2.2 Table 13 (绝缘耐压2.3Table 14(Safety (安全规格er supply shall compliance with the following 3）GB8898-(电磁兼容性EMI（电磁干扰er supply shall compliance with the following 1）Conduction EmisEN55022，CLASSB GB9254,CLASS B* ART15 CLASS 2) Radiate :(辐射干扰度2.2 Table 13 (绝缘耐压2.3Table 14(Safety

16、(安全规格er supply shall compliance with the following 3）GB8898-(电磁兼容性EMI（电磁干扰er supply shall compliance with the following 1）Conduction EmisEN55022，CLASSB GB9254,CLASS B* ART15 CLASS 2) Radiate :(辐射干扰度EN55022，CLASSB GB9254，CLASS BART15 CLASS * EMS（电磁干扰er supply shall compliance with 1）ESD (静电抗扰度*GB1762

17、6.2-1998/IEC61000-4-EFT ( 脉冲群抗扰度*GB17626.4-1998/IEC61000-4-Surge ( 雷击浪涌*GB17626.5-1998/IEC61000-4-第 610青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUTInput To AC240V/ 0.7mA 50Hz 1 Input To 3.0KV/1

18、0mA 50Hz 1 4.3 Audio noise（可听噪音半载、满载、动态负载（见下表）Voltage Tolerance Slew oad 5. Environmental Requirement (工作环境5.1 Operating: (环境温度-10 to -40 to 5.2 Operating (环境温度From10% to 90% relative humidity (non-4.3 Audio noise（可听噪音半载、满载、动态负载（见下表）Voltage Tolerance Slew oad 5. Environmental Requirement (工作环境5.1 Op

19、erating: (环境温度-10 to -40 to 5.2 Operating (环境温度From10% to 90% relative humidity (non-Store: From 5 to 95% relative humidity (non-5.3 Altitude (海拔高度Operating: To10，000ft. Store: To20，000ft.5.4 Cooling Method (冷却方式Ventilation cooling (物理尺寸200X140X13.5 7.Pin (连接器脚位定义8.1 交流输入连接器（CON1），采用MOLEX生产的35979的卧式

20、规格或其他厂家兼容型号，针间距7.92mm第 7 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUT1AC 23AC 8.2 直流输出连接器（CN2）钻宝的PHDK-26AW双排插座（或其他厂家兼容型号），8.3直流输出连接器（CN3）PH-10AW插座，不带卡扣，针间距2.0mm第 8 页，共 10青岛海尔光THESE SPECIF

21、ICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHALLNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUT18.2 直流输出连接器（CN2）钻宝的PHDK-26AW双排插座（或其他厂家兼容型号），8.3直流输出连接器（CN3）PH-10AW插座，不带卡扣，针间距2.0mm第 8 页，共 10青岛海尔光THESE SPECIFICATION ARE THE PROPERTY OF QingHaier Optronics ,ANDSHAL

22、LNOTBEREPRODUCEDORUSEDASTHEBASISFORTHE MANUFACTUREORSELLOFAPPARATUSESORWITHOUT123456789123456789PW-sBL-(安装尺寸第 910DC-DC连接DC-DC连接定位凸包定位凸包AC超薄LED电源,按LG V6架构排布: 外形尺寸195.5*180,板厚不允许走线或布件; 可排布二次侧电路走线或元件；(安装尺寸第 910DC-DC连接DC-DC连接定位凸包定位凸包AC超薄LED电源,按LG V6架构排布: 外形尺寸195.5*180,板厚不允许走线或布件; 可排布二次侧电路走线或元件；非阴影区域,板上设

23、计不允许超过13.5, 板下焊脚不超过插座的位置如图示,可适当微调,含插头的总厚度也要符合13.5的高度要求上下高度上可排150.5尺寸的小板用于32,C4mm6mm3mm;未注固定孔位的尺寸公差按0.1; 其它未注外形尺寸公差按10. and Storing (包装)1、Packing(Productname,partnumber, the package case.rs logo, QC , Pb-free display and date must be ed 2、()This product can be transported through land, sea or air. Me

24、asures should be taken for water sunproof. Also, it be handled with ，3、)Keep the product he package case before using. The temperature of the stock house be n -40-+55 C the humidity should 10. and Storing (包装)1、Packing(Productname,partnumber, the package case.rs logo, QC , Pb-free display and date m

25、ust be ed 2、()This product can be transported through land, sea or air. Measures should be taken for water sunproof. Also, it be handled with ，3、)Keep the product he package case before using. The temperature of the stock house be n -40-+55 C the humidity should n 5-95%. Keep the product away from hazadous flammable or explosive substan and erosive chemical and strong magnetic field. The package cases sho