pos机项目h2结构料规格书baolong-vibrator10.35x4.4xh3.5smt blt4311rev2

1、Baolong Electronic Group .TBaolong Electronic Group .TREFNo.PRODUCTPRODUCTBLT-CUSTOMERAPPROVEL/Item/名称: 3.2mmVibration M/型号Date/日期Item/名称: 3.2mmVibration M/型号Date/日期.中国宝龙电子地址：中国浙江省乐清东路宝龙工业园PRODUCT SPECIFICATIONS/产品规PRODUCT PRODUCT SPECIFICATIONS/产品规PRODUCT CoList、Register For Storage al crc 5 8、11.

2、Lot no. indication/标12.Reflowspecification/回流老化曲 REASONFORCONTENTFOR/CustomerAdd“Vibrationswing”Validity of ie confirm according as the best newest ie of the register， except for speexplain./ 版本有效性以更改Date/福CHINA BAOLONG ELECTRONIC GROUP 中国宝龙电子PRODUCT SPECIFICATIONS/产品规格PRODUCT Applications/用途This sp

3、ecification is app s to BLT-4311vibration motor to be used for cellular phone and other handy communication tools. Manufactured by CHINA BAOLONG ELECTRONIC GROUP CO., . /本规格书适用于 BLT-4311 型振动电机，该电机由宝龙电子制造，主要用于移动 PRODUCT SPECIFICATIONS/产品规格PRODUCT Applications/用途This specification is app s to BLT-4311

4、vibration motor to be used for cellular phone and other handy communication tools. Manufactured by CHINA BAOLONG ELECTRONIC GROUP CO., . /本规格书适用于 BLT-4311 型振动电机，该电机由宝龙电子制造，主要用于移动 及其它便 Measure at normal temperature and humidity, Should any doubt arise in judgment, test shall be conducted at the follo

5、wing conditions /如无特殊说明测试一般在常温、常湿下进行，为了保证 的一性，测试应在下表Storage Environment/ No./Items/项 Specification/Storage-40 5% No./Items/项 Specification/ Shafthorizontal/使电机轴向处于水平No./Items/项 Contents/说 3.2DCcored Numberofmagnetpoles/2-poles(Innermagnet(外置磁极型式 PreciousbrushandPRODUCT SPECIFICATIONS/产品规PAGE/页码5 /PR

6、ODUCT No./Items/项 Ratednominal operating/工作电压 Operatingvoltage(m2.7 V DC 2.33.2VDCRatedMeasureatratedvoltageandratedload/在额定电压和75mAPRODUCT SPECIFICATIONS/产品规PAGE/页码5 /PRODUCT No./Items/项 Ratednominal operating/工作电压 Operatingvoltage(m2.7 V DC 2.33.2VDCRatedMeasureatratedvoltageandratedload/在额定电压和75mA

7、RatedMeasureatratedvoltageandratedload/在额定电压和 At rated load( counterweight) anyition of rotor(counter weight to be turned slowly at 360). /在2.3V Measure currenlocked counter weight ( R1.72.8) in rated voltage(2/3R R:1 extreme resisting rate,Notition when the brushes contact the commu or at the two c

8、ontact po s)/在90mA Measure(336) Supply wiC 110V betn a lead wire and motor caseduring1minute/在电机的机壳和接触脚间施加交流电 110V，历时 1 分钟。1mAMax /绝缘电AtDC100Vntheleadwiresand 10MWeight（Underratedvoltageand35ms50%strength,65ms100strength/35ms No./Items/项 Specification/Appearance/Visual/Noscarruststainanddent/无s/Usev

9、erniercaliperandmicrometerMass/ ShaftpullPullshallbedalongwith5kgf(49N)ShaftendDistanceofaxialplayonshaft/轴沿着轴向移MechanicalMeasured at rated voltage and rated （counterweight ）,the distance along with shaft directer is 10cm bet n microphone and motor./额轮 PRODUCT SPECIFICATIONS/产品规PRODUCT According to

10、demand in following table test alone in every item,then measuring itemable 6 , changing rateofmeasureddatemustbewithin 35ofinitialPRODUCT SPECIFICATIONS/产品规PRODUCT According to demand in following table test alone in every item,then measuring itemable 6 , changing rateofmeasureddatemustbewithin 35of

11、initialvalue./按下列项目分组进行试验后，按6.2、6.3项性No./Items/项 High temperature storage 96hrs at 80,then recovery 4hr at normal temperature./80964 小test 48hrs at 40 ,90%HR,then recovery 4hr atnormal temperature ./温度40，湿度 90%的环境下放置 48 小时，然后常4Low temperature storage 96hrs at -40,then recovery 4hr at temperature温度-4

12、0964小HeatcycleConfirmed to operating of motor during 1 cycles as following test condition (without presence of water droplets on the motor), then return to normal temperature and humidity for 4 cyc efore test/确保电机在室温下恢复 4 小时后，进 试。 Motor shall be app d with following method at standard packing condit

13、ion. /电机在标准的包装条件下，按以下要求进行试验： 1.Vibration frequency range/振频范围: 1055Hzp ratio/振频变化: 105510 Hz approximate 1min/约1 分钟 4.Method of changing the sp vibration frequency/变频方法: Logarithmic or linear/对数或线形变化Direction of vibration/振动方向: Three pendicular directions including actuator/包括动作机构在内的三个垂直方向 DropSet t

14、hemotor on the heavy block about 60g weight（include the motor） 重的物体上 落下到水泥地板上。Times/次数：Threedropsp laneforatotalof18drops/318SaltsprayEx ure the motor to an environment with 35,5%NaCl resolution spray for 24 hours.Visual examination identify no signs of corro ./将电机放置于盐雾试验箱，试验箱内温度 35，盐溶液浓度 51%；PH值为 6

15、.57.2；盐雾沉降量12ml/80cm2.h；浓度5%的中性盐溶24 小时。持续期满， 试验样品表面，用干净的棉布擦拭后LowtemperatureureLifetest/低温性Toain(A)cycleunderhightemperatureforLowtemperatureureLifetest/低温性Toain(A)cycleunderhightemperatureforPRODUCT SPECIFICATIONS/产品规PRODUCT 8.Life HightemperatureureLifetest/高温性（C）Toain(A)cycleunderhightemperaturefo

16、r （B）Toain(A)cycleforhesoftemperature Life test conditions: Test voltage/DC2.7V shall bed reciprocally repeating on: 2.5sec ，off:2.5secwithratedloadatnormaltemperatureandhumidity/在常温常湿下按2.5秒开、 1On/Off/ ure ure- /、Againstinitialratewhenstandardno.ofionisn+30%/-20%、Againstinitialratewhenstandardcurren

17、trateisn+20%/-PRODUCT SPECIFICATIONS/产品规PAGE/页码8/PRODUCT Remarks/注意事 No./Items/项 Whatever item not shisspecificationwillnotbeguaranteed.未在本规格中Current terminals should not be twisted or bent moren twice./接电端子弯次数不可多于 2 次。The portion when lead wire and terminal are soldered should not be under Donotsub

18、jectthemotorunderlockedconditionforlonghours在马达通电时，不Do not exert prerebypushingthePRODUCT SPECIFICATIONS/产品规PAGE/页码8/PRODUCT Remarks/注意事 No./Items/项 Whatever item not shisspecificationwillnotbeguaranteed.未在本规格中Current terminals should not be twisted or bent moren twice./接电端子弯次数不可多于 2 次。The portion w

19、hen lead wire and terminal are soldered should not be under Donotsubjectthemotorunderlockedconditionforlonghours在马达通电时，不Do not exert prerebypushingthecurrentterminalstowardsthedirectionofthe ernal motor. /不可向马达一侧强行挤压接电端子。Out-goingtestdataandCpkdatawillbeattached(n-35)for Loaded roion r.p.m.Loadedcur

20、rent Lockcurrent(Startingcurrent)StartingvoltageV(withouttheconsiderationofCpkvalue)负载电流：m PRODUCT SPECIFICATIONS/产品规 1reelpacking uble wall corrugated carboard(ernaldimen1000pcs/1 reel 6 reel =6000pcs11.Lotno.indication/The lot no. is indicated by prasbelow:/机身喷码所表含义 :AZ/ :1V/ )/ :2011-1/ Baolong-B/ 123456789123456789ABCDEFGHIJKLMNOPQRSTUVPRODUCT SPECIFICATIONS/产品规 1reelpacking uble wall corrugated carboard(ernaldimen1000pcs/1 reel 6 reel =6000pcs11.Lotno.indication/The lot no. is indicated by prasbelow:/机身喷码所表含义 :AZ/ :1V/ )/ :2011-1/ Baolong-B/ 123456789123456789ABCD