03线型光束感烟探测器滤光片校准规范实验报告V2

《线型光束感烟探测器滤光片》校准规范实验报告PAGE1PAGE32《线型光束感烟探测器滤光片》校准规范（征求意见稿）实验报告2023年10月

目录TOC\o"1-3"\h\u17461.概述 32572.校准条件 4144523.校准项目的实施 4222793.1透射比和减光值的测量 4183593.2光谱曲线平直度 4324763.3均匀性与正反差别 5129253.4年变化量 5282534.校准数据与结果分析 5206504.1校准数据 5228894.2结果分析 26

概述《线型光束感烟探测器滤光片》校准规范按JJF1071-2010《国家计量校准规范编写规则》编制，为了验证本规范相关技术指标的可行性及有效性进行实验。线型光束感烟探测器滤光片（以下简称滤光片）是各级消防检测和监督机构用于检测线型光束感烟火灾探测器（以下简称探测器）的专业器具。检测过程是利用滤光片的减光作用减少红外发光器发射到红外接收器的光束量，来模拟火灾条件下烟雾遮挡探测器的情况，通过响应情况来判定探测器的性能。探测器可分为对射式感烟探测器和反射式感烟探测器，其原理如图1、图2所示，用于检测的滤光片实物图如图3、图4所示。图1对射式感烟探测器原理图图2反射式感烟探测器原理图图3线型光束感烟探测器滤光片实物图图4线型光束感烟探测器滤光片实物图生产该滤光片的厂家主要有北京朋利驰科技有限公司、北京京华兴科技有限公司、沈阳奥博斯隆兴科技有限公司、万霖华泰（北京）安全技术有限公司、新德图科技（香港）有限公司、智淼君安（江苏）消防工程技术有限公司、GUIPAI等，从市场占有率角度而言，绝大部分为国内产品。

校准条件环境条件：(20～26)℃，相对湿度：(31～65)%。校准用设备如表1所示。表1测量标准设备型号规格测量范围等级生产厂家双光束紫外可见分光光度计Lambda950波长：(175~3300)nm透射比：0.01~1.00Ⅰ级PE该设备经检定合格为Ⅰ级。近红外透射比采用近红外滤光片校准的方式，该滤光片与中国计量科学研究院进行了测量审核，近红外透射比引入的不确定对为0.0037，使用该滤光片对该分光光度计进行校准，综合评估，该设备近红外透射比的误差不超过0.006。综上，该设备符合校准规范第6.2条款规定：近红外区波长最大允许误差不超过±2.0nm；透射比最大允许误差不超过±0.006；杂散辐射水平低于0.005；光谱范围应覆盖开展工作所需的光谱范围。校准项目的实施透射比和减光值将光谱光度计开机预热，达到正常工作状态后，设置波长范围（800~1000）nm，设置光谱带宽为2nm，采样间隔为10nm，积分时间为1s，以空气作为参比，测量滤光片的透射比曲线，记录不同波长下的透射比值，按式（1）计算平均透射比值，为滤光片透射比值。（1）式中：——第i次测量波长下的透射比值；——第i次透射比平均值；n——测量波段下的采样点数量。滤光片的减光值A按式（2）计算。（2）式中：——第i次减光值，dB。滤光片的透射比和减光值共测量4次，其中正面测量3次（在滤光片中心点及中心点距边缘1/2处均匀取两点），反面测量1次，取4次测量结果的平均值作为测量结果。（3）（4）式中：——透射比总平均值，%；——减光值总平均值，%。光谱曲线平直度从7.2测量的光谱曲线中，计算极差值，以极差值的一半除以平均值为光谱曲线平直度。取4次光谱曲线平直度最大值为测量结果。光谱曲线平直度按式（3）计算。（5）式中：——极差值；QUOTE——光谱曲线平直度，%；均匀性与正反差别在滤光片中心点及中心点距边缘1/2处均匀取两点，按3.2测量其减光值，计算三处减光值的差值，取其绝对值，其中最大值为均匀性。在滤光片正面中心与从背面中心点射入时，按3.2测量其减光值，计算两个减光值的差值的绝对值即为正反面检测差值。年变化量计算同一滤光片两次校准周期的减光值，其差值的绝对值为年变化量。校准数据与结果分析校准数据以下表2至表21列举了20套滤光片校准数据。

表2生产厂家及型号沈阳高新区隆达奥博斯消防检测工具研发中心（型号：ABS-JG08）标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%100012.5212.5412.5912.5291.8091.9291.8091.7099012.4912.5012.5612.4791.8091.9291.7991.6998012.4612.4812.5312.4591.7891.9391.8091.6697012.4312.4312.4812.4091.8191.9591.8691.7096012.3912.4112.4612.3891.8291.9691.8991.7295012.3512.3712.4212.3391.7791.9291.8391.6894012.3012.3112.3612.2891.7591.8991.8291.6593012.2512.2912.3312.2591.8191.9891.8691.6992012.2312.2312.2812.2091.9092.0391.9191.7991012.2212.2312.2612.2091.8592.0291.8891.7190012.1912.1912.2412.1791.8792.0091.8891.7689012.1512.1412.1812.1291.8291.9891.8691.7388012.0712.0912.1212.0391.8291.9891.8791.7387011.9611.9812.0111.9291.9191.9991.9191.7786011.8411.8611.8911.7991.9092.0291.9691.7685011.7811.7911.8211.7391.9992.0791.9791.8484011.8911.9111.9511.8692.0092.0892.0691.8983011.9111.9311.9711.8892.0292.1192.0691.9182011.8311.8511.8811.8192.0292.1292.0691.8881011.7311.7411.7611.7092.0592.1392.1091.9380011.5611.5611.6011.5392.1292.1792.0791.98单次光谱透射比平均值/%12.1212.1312.1712.1091.8992.0191.9291.77单次减光值/dB9.169.169.159.170.370.360.370.37透射比总平均值/%12.1391.89减光值总平均值/dB9.160.37均匀性/dB0.020.01正反面差/dB0.010.01年变化量/dB0.100.02极差值/20.560.23光谱曲线平直度/%4.630.25

表3生产厂家及型号北京朋利驰科技有限公司（型号：/）标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%100010.019.689.8310.0291.3090.1290.0691.4399010.029.719.8410.0391.3390.1290.0491.4298010.049.719.8210.0291.3190.0890.0691.3997010.039.729.8110.0191.3690.1290.1291.4696010.059.769.8510.0491.3290.1190.0791.3995010.089.789.8810.0891.3590.1290.0691.3894010.119.799.9310.1291.3890.1790.1291.4893010.119.829.9310.1391.2890.0790.0491.4092010.149.839.9310.1491.3490.1190.0891.4591010.209.919.9910.1991.3790.1990.1591.4990010.239.9510.0310.2391.3690.1990.1891.4589010.289.9710.0410.2691.3690.1590.1991.4388010.279.9810.0610.3091.4090.2090.1591.4687010.279.9910.0610.2791.4490.2990.2691.5086010.249.9510.0210.2291.4190.2790.2991.5085010.3010.0010.0710.2891.5790.4890.5091.5984010.4710.2110.2610.4791.5790.4890.4991.5683010.5910.3310.3910.5991.5990.5490.5491.5882010.6210.3410.4110.6291.5490.4890.5691.6581010.6310.3510.4410.6291.5890.5390.6191.6580010.5510.2510.3310.5492.1691.1091.1592.17单次光谱透射比平均值/%10.259.9510.0410.2591.4490.2890.2791.51单次减光值/dB9.8910.029.989.890.390.440.440.39透射比总平均值/%10.1290.88减光值总平均值/dB9.950.42均匀性/dB0.130.06正反面差/dB0.000.00年变化量/dB0.010.02极差值/20.380.72光谱曲线平直度/%3.730.79

表4生产厂家及型号北京京华消防检测仪器有限公司（型号：JH-LGP）标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%10008.38.38.38.391.191.391.391.79908.58.48.58.591.191.391.391.69808.68.68.78.791.191.391.291.59708.88.88.98.991.191.391.391.59609.19.09.19.191.191.491.291.49509.39.39.49.491.191.391.291.59409.69.59.69.791.191.491.291.59309.89.89.99.991.191.391.291.492010.110.110.110.291.291.491.391.591010.510.410.510.591.391.491.291.590010.810.710.810.891.291.491.291.589011.111.011.111.191.291.491.291.488011.411.311.411.491.291.491.291.587011.711.611.711.791.391.491.391.586012.011.912.012.091.491.591.391.585012.412.412.412.591.591.691.491.784012.912.913.013.091.491.691.491.683013.413.413.513.591.591.691.491.782013.813.813.813.991.591.691.491.781014.214.214.314.391.591.791.491.780014.614.614.714.792.092.292.092.2单次光谱透射比平均值/%11.011.011.011.091.391.591.391.6单次减光值/dB9.599.609.579.570.400.390.390.38透射比总平均值/%11.0191.41减光值总平均值/dB9.580.39均匀性/dB0.030.01正反面差/dB0.020.01年变化量/dB0.160.01极差值/23.610.74光谱曲线平直度/%32.850.81

表5生产厂家及型号北京新宇胜利仪器有限责任公司（型号：WXT-10）标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%100020.8720.9220.7720.8189.9589.8689.9789.8499020.7920.8120.6820.7189.9789.8990.0189.8298020.6920.7320.5920.6289.9989.8890.0689.9097020.5520.6120.4920.5389.9689.8790.0289.8796020.4720.5220.3820.4189.9189.8289.9689.8995020.3720.4120.3220.3489.9589.8390.0089.8794020.2620.3020.2120.2389.9389.8389.9989.8393020.1520.1820.1120.1289.9489.8489.9489.8592020.0420.0819.9920.0289.9089.8089.8889.7591019.9920.0219.9219.9489.8989.8289.9489.7690019.9519.9619.8819.8889.9489.8389.9489.8189019.8619.8819.8219.7990.0889.9390.0489.8888019.7519.7819.7119.7190.1389.9690.1089.9287019.6019.6419.5719.5790.1390.0190.0789.9586019.4419.4919.4419.4090.1590.0090.1290.0385019.3719.4219.3619.3490.2490.0590.1790.0884019.4719.5219.4519.4290.2790.1590.2590.1283019.4519.5119.4519.4190.3390.1890.2790.1882019.3519.4019.3319.2990.3590.1290.2190.1781019.2219.2919.2119.1790.3590.1190.2290.1680019.0519.1319.0418.9990.3790.1890.2990.21单次光谱透射比平均值/%19.9419.9819.8919.8990.0889.9590.0789.95单次减光值/dB7.006.997.017.010.450.460.450.46透射比总平均值/%19.9290.01减光值总平均值/dB7.010.46均匀性/dB0.020.01正反面差/dB0.010.01年变化量/dB//极差值/20.940.29光谱曲线平直度/%4.690.32

表6生产厂家不详标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%100014.4514.6014.9314.4588.7688.6588.2288.7699014.3914.5414.8814.3988.7688.6288.1988.7698014.3214.4514.8014.3288.7588.5888.1488.7597014.2914.4214.7614.2988.7588.5988.1788.7596014.2414.3814.7214.2488.7388.5788.1088.7395014.1814.3514.6614.1888.7288.5688.1388.7294014.1314.3014.6014.1388.7688.5688.0888.7693014.0514.2314.5314.0588.6888.5888.0588.6892014.0114.1914.4614.0188.7088.5888.0788.7091014.0114.1714.4414.0188.7388.6388.0888.7390013.9914.1514.4013.9988.7388.6288.0888.7389013.9214.0914.3313.9288.7588.5688.0688.7588013.8214.0014.2313.8288.7888.6288.0288.7887013.7213.9214.1313.7288.8988.6788.1588.8986013.5913.7513.9813.5988.9788.7488.2088.9785013.5413.7013.9013.5489.0588.8388.3089.0584013.6513.8114.0113.6589.1188.9388.3389.1183013.6813.8214.0213.6889.1288.8988.3289.1282013.5813.7313.9213.5889.1688.9088.3889.1681013.4913.6413.8513.4989.2088.9888.4189.2080013.2713.4413.6313.2789.5589.3488.7189.55单次光谱透射比平均值/%13.9214.0814.3413.9288.8988.7188.2088.89单次减光值/dB8.568.518.438.560.510.520.550.51透射比总平均值/%14.0688.67减光值总平均值/dB8.520.52均匀性/dB0.130.03正反面差/dB0.000.00年变化量/dB0.200.07极差值/20.650.66光谱曲线平直度/%4.670.74

表7生产厂家GUIPAI标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80017.10817.26417.29917.16392.07992.34992.11792.03881017.18317.31917.30517.32091.79291.86791.91091.68582017.34917.49017.52317.39791.70191.98991.87991.66383017.46117.61917.72817.57291.77692.11191.97891.78684017.64217.80517.85417.76991.75191.92891.87991.70585017.82418.00417.99817.96491.72892.04691.98091.76986018.01618.17218.17818.15891.70191.98891.80391.70487018.15918.33618.36918.31791.79891.97191.84391.78988018.36518.49418.55818.53091.74891.89591.89691.73189018.52618.73018.75918.73891.74591.98391.88891.82990018.74518.91618.97118.93291.77191.94391.93191.82191018.94719.15019.15319.13991.81191.98891.95691.82192019.19119.36219.39719.38091.89991.99791.97291.92093019.39219.60819.64019.60491.89392.07892.02191.93194019.61419.85919.87919.86291.96992.14292.10292.02195019.83320.06120.07820.05592.00392.12392.08492.05596020.05520.29020.30920.29692.01892.16392.16092.09697020.27920.51720.54720.54192.10492.21292.17892.13698020.50620.76420.78120.75392.11692.22392.25292.16899020.69120.98520.99920.96792.14992.23992.25292.198100020.91221.18821.21421.18492.17792.28192.27992.201单次光谱透射比平均值/%18.84819.04419.07319.03191.89292.07292.01791.908单次减光值/dB7.257.207.207.210.370.360.360.37透射比总平均值/%19.0091.97减光值总平均值/dB7.210.36均匀性/dB0.050.01正反面差/dB0.040.00极差值/22.060.29光谱曲线平直度/%10.950.31

表8生产厂家沈阳奥博斯隆兴科技有限公司标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80011.90911.96412.05712.10091.78891.97991.82691.74781011.66511.80211.82711.78791.49991.62191.61791.39282011.63311.68111.76511.80791.33191.50591.50991.29383011.70811.81911.81911.97591.31391.58091.51591.32384011.71411.84111.88811.92691.30191.51391.42991.25585011.62611.76611.76011.80091.26791.44191.51991.30886011.61211.75411.76811.77491.27291.43491.37491.27587011.66111.81911.83811.87191.24691.45691.29191.23788011.66111.82611.84611.85491.14291.33591.29091.12589011.69611.90811.79811.92991.17791.41091.32091.26190011.72911.91611.87911.95591.13691.36291.29691.18691011.72811.92011.96911.93491.20991.41591.35491.21992011.75411.94311.90611.96091.18391.38991.25691.20493011.81812.03011.93312.06691.28091.52891.40891.31894011.85212.10012.10212.11791.30491.56991.43791.35695011.88712.10912.02212.13291.28991.53491.37091.34196011.92612.16712.11112.18091.33091.58491.47291.40897011.96112.22312.16212.22991.35391.62191.42791.38598012.00012.24712.13512.27591.39191.66691.52791.44399012.03812.31412.19212.34691.39991.70791.50291.448100012.05012.32212.19112.35291.46091.76291.56291.484单次光谱透射比平均值/%11.79211.97511.95112.01891.31891.54391.44391.334单次减光值/dB9.289.229.239.200.390.380.390.39透射比总平均值/%11.9391.41减光值总平均值/dB9.230.39均匀性/dB0.070.01正反面差/dB0.080.00极差值/20.260.47光谱曲线平直度/%2.190.52

表9生产厂家及型号北京朋利驰科技有限公司（AH410）标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%10009.249.229.249.3690.7691.0690.8590.729909.239.199.239.3690.7491.0790.7990.719809.199.209.219.3790.7791.1090.8590.759709.189.209.239.3690.7691.0890.8390.729609.199.199.239.3890.7791.0790.8190.719509.209.199.229.3890.7791.0890.8190.729409.249.199.239.3890.7891.0790.7890.759309.239.189.209.3690.7791.0890.7990.719209.199.179.199.3490.7491.0590.7590.699109.229.219.229.3790.7591.0990.7890.699009.229.249.259.4290.7591.0590.7490.688909.239.249.259.4290.8491.1090.7890.708809.199.199.209.3690.8491.0990.8390.758709.139.149.139.3290.8791.1290.8290.778609.059.069.069.2390.8691.1090.8090.748509.119.109.139.2991.0691.3491.0290.948409.309.319.339.4991.1291.4191.0991.038309.389.399.389.5591.2191.4691.1491.108209.339.339.359.5191.2191.4891.2091.148109.289.289.309.4791.2991.5491.2891.198009.249.239.259.4191.2291.5091.3891.33单次光谱透射比平均值/%9.229.219.239.3990.9091.1990.9190.84单次减光值/dB10.3510.3610.3510.270.410.400.410.42透射比总平均值/%9.2690.96减光值总平均值/dB10.330.41均匀性/dB0.010.01正反面差/dB0.080.00年变化量/dB0.530.03极差值/20.170.39光谱曲线平直度/%1.850.43

表10生产厂家万霖华泰（北京）安全技术有限公司标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80012.08812.24412.14312.35890.83190.88790.77691.02281012.23012.36612.36712.30590.75890.82190.62190.88082012.15812.29912.20612.44690.77590.83790.72790.94983012.25612.41412.36712.59190.65490.71290.54390.92184012.30212.46512.42912.47990.69190.74690.56490.90385012.35812.53812.49812.67690.75990.80790.61990.93386012.44212.59812.58412.72990.67890.71590.53690.84087012.52712.70412.68512.70090.71490.76690.55690.92488012.53512.66412.70012.68290.75690.82090.59190.94989012.62512.82912.83712.86390.73590.79190.52390.96890012.69112.86212.87812.86390.69590.74990.50890.92191012.78112.98412.97312.95890.72190.76490.52990.92792012.88113.05213.07012.97990.70790.75290.51890.91393012.95513.17113.16713.14090.72090.80590.50890.96894013.09113.33613.33913.26490.78790.84190.53991.05295013.15013.37813.37213.27090.83190.88590.60991.07696013.24513.48013.48613.39090.85790.87290.61691.11197013.33013.56813.59213.43890.87790.92290.61591.14598013.40313.66113.65013.51090.86390.86890.61691.13899013.48613.78013.76213.57690.89490.93690.61891.202100013.54813.82413.82013.65290.93090.95190.65891.232单次光谱透射比平均值/%12.76612.96312.94912.94690.77390.82190.59090.999单次减光值/dB8.948.878.888.880.420.420.430.41透射比总平均值/%12.9190.80减光值总平均值/dB8.890.42均匀性/dB0.070.01正反面差/dB0.060.01极差值/20.780.16光谱曲线平直度/%6.130.17

表11生产厂家GUIPAI标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80018.01318.16917.85718.20492.17592.11992.23092.33181018.15518.29118.01918.27792.16092.09792.29792.29682018.33018.47118.18918.50492.00691.94492.05492.14783018.56418.72218.40618.83192.31392.25592.42492.47184018.70418.86718.54118.91692.17592.12092.30292.33885018.89819.07818.71819.07292.23592.18792.37592.41586019.04819.20418.89219.21092.21592.17892.35792.37187019.21819.39519.04119.42892.19592.14392.35392.37288019.45019.57919.32119.64392.24592.18192.41092.37489019.66419.86819.46019.89792.23092.17492.44292.43490019.86820.03919.69720.09492.23092.17692.41792.40191020.08720.29019.88420.29392.28792.24492.47992.49092020.31320.48420.14220.51992.31392.26892.50292.48493020.56420.78020.44920.81292.33692.25192.54892.45194020.79521.04020.54521.06092.35492.30092.60292.60495021.01621.24420.88121.26192.41292.35892.63492.54796021.25921.49421.07421.51392.41292.39792.65392.59797021.48921.72721.28821.75792.46792.42292.72992.66898021.73521.99321.60022.01092.51692.51192.76392.65199021.94722.24121.79322.25592.51392.47192.78992.667100022.16822.44422.02722.47092.55892.53792.83092.699单次光谱透射比平均值/%19.96620.16319.80120.19292.30292.25492.48592.467单次减光值/dB7.006.957.036.950.350.350.340.34透射比总平均值/%20.0392.38减光值总平均值/dB6.980.34均匀性/dB0.080.01正反面差/dB0.050.01极差值/22.200.30光谱曲线平直度/%11.030.32

表12生产厂家不详标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80017.45117.64217.69917.50692.32592.36392.28492.59581017.52617.64817.68817.66392.33192.44992.22492.40682017.83618.01018.08117.88492.15592.33392.11792.44383017.95218.21918.27318.06392.34092.54292.35092.67584018.16618.37818.44018.29392.20992.33792.16392.38685018.30418.47818.50318.44492.23592.48792.27692.55386018.51718.67918.77318.65992.18692.28892.18992.47387018.70718.91718.98418.86592.20192.24692.19292.37488018.85819.05119.04319.02392.25292.40092.23592.39989019.10719.34019.40919.31992.22492.36792.30892.46290019.30419.53019.55419.49192.27392.43392.32392.44591019.53019.73619.77119.72292.31092.45592.32092.48792019.77519.98119.92719.96492.37192.44492.39292.46993020.02320.27120.13820.23592.41592.54392.45392.60094020.26720.53220.51720.51592.41092.54392.46292.58395020.48820.73320.68320.71092.49492.57592.54692.61496020.72820.98220.91320.96992.53492.67692.61292.67997020.98121.24921.18221.24392.55792.63192.58992.66598021.21421.48921.44921.46192.61992.75592.67192.72699021.42021.72821.66421.69692.66492.76792.71392.754100021.66421.96621.95121.93692.67992.78192.70392.783单次光谱透射比平均值/%19.42019.64619.65019.60392.37192.49692.38792.551单次减光值/dB7.127.077.077.080.340.340.340.34透射比总平均值/%19.5892.45减光值总平均值/dB7.080.34均匀性/dB0.050.01正反面差/dB0.040.01极差值/22.240.31光谱曲线平直度/%11.560.33

表13生产厂家不详标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80019.79719.85219.64119.94592.32292.57092.36092.05281019.87620.01319.74020.03892.40192.56392.51992.32682020.11420.16219.97320.24692.34892.59392.52692.06083020.30220.41320.14420.41392.30092.62192.50291.96584020.47120.59820.30820.64592.38992.66392.51792.21285020.63320.77320.45320.76792.22392.42292.47591.90586020.82220.96420.66620.97892.26792.52392.36991.98087021.03921.19720.86221.21692.33192.60892.37692.15888021.26021.42521.13121.44592.25692.44192.40492.10989021.42521.63721.22121.52792.31092.61292.45392.07290021.63821.82521.46721.78892.39092.64092.55092.21891021.84022.03221.63722.08192.36992.61092.51492.19292022.09522.28421.92422.24792.46892.62092.54192.37093022.29922.51122.08322.41492.49492.60992.62292.30994022.52822.77622.28322.77892.55592.80592.68892.38295022.78323.00522.55522.91892.60392.79892.68492.48396022.96623.20722.73123.15192.64892.83392.79092.50397023.20323.46522.96523.40492.61592.81692.68992.50798023.45123.69823.19323.58692.70092.93592.83692.59399023.65323.92923.35923.80792.73892.98292.84192.648100023.85924.13123.58324.00092.75893.04592.86092.654单次光谱透射比平均值/%21.71721.90021.52021.87692.45292.68192.57792.271单次减光值/dB6.636.606.676.600.340.330.330.35透射比总平均值/%21.7592.50减光值总平均值/dB6.620.34均匀性/dB0.080.01正反面差/dB0.030.01极差值/22.140.31光谱曲线平直度/%9.860.33

表14生产厂家不详标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80017.03817.18616.84717.19492.13792.09692.09992.38581017.24217.40417.12017.37892.28892.18192.17092.45082017.46117.59317.28717.60292.25292.21492.07492.49783017.52917.64017.26217.68792.32392.33392.12192.64484017.78717.96117.57517.95092.21592.16992.08792.48985017.97218.10617.79818.15292.34092.38192.08892.53986018.14018.29617.97818.29692.21692.21992.11492.47287018.35218.52918.14218.52992.23692.22792.19192.51388018.52418.70918.33118.65392.33692.31992.18892.52189018.70018.80218.46718.90492.31092.39492.16792.61290018.93619.08618.71019.10792.40392.45392.24392.65391019.12819.36918.92219.33192.34092.35092.19592.58192019.38819.54019.18219.55992.45392.47492.38092.60593019.63019.74519.38219.84692.44192.47992.31392.55694019.87820.12819.61320.12392.48892.54092.35592.73895020.08420.21919.83920.31292.54992.60192.46892.74496020.30920.49420.05520.54492.54592.62392.40392.73097020.54720.74820.27920.78592.64892.68092.57492.84998020.79020.92520.51521.04892.67792.72992.54192.91299021.01021.16420.70221.30492.69492.74392.59192.938100021.23121.37220.92921.50792.74492.76892.64293.031单次光谱透射比平均值/%19.03219.19118.80619.22992.41192.42792.28692.641单次减光值/dB7.217.177.267.160.340.340.350.33透射比总平均值/%19.0692.44减光值总平均值/dB7.200.34均匀性/dB0.090.01正反面差/dB0.040.01极差值/22.200.33光谱曲线平直度/%11.550.36

表15生产厂家北京朋利驰科技有限公司标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%8009.8139.8519.7729.54391.19091.33891.03491.2458109.8629.9809.7559.78791.18091.34291.04491.3178209.94910.1279.9119.66191.23291.36491.09191.2808309.91210.1149.9229.57791.12491.23590.96691.2358409.8199.9479.7739.64291.17191.34591.00891.2988509.88310.1359.9249.56591.28791.42191.10791.4278609.90110.0039.9049.61491.24691.40291.09091.3888709.8689.9139.8599.69591.28391.46091.10691.4418809.90810.0569.8919.76191.22891.41391.09991.3938909.96410.10710.0489.72691.33591.43791.13191.5479009.97310.13310.0239.80191.33191.48191.16091.51891010.02010.16510.0309.84391.35491.59591.15191.54692010.04310.11610.0649.94591.38391.53591.21291.57293010.08310.21110.1219.89891.47391.58891.25791.68594010.12710.26010.1799.95491.50891.75891.26391.75695010.17210.25310.22410.05291.57491.70991.34691.79696010.20710.34910.28510.06291.60991.79491.37491.85097010.25210.32610.28410.14491.58991.79091.35191.85198010.27810.41410.33010.17191.65291.78791.39491.89999010.31610.41910.36510.22691.68191.83591.38791.957100010.35510.45710.37910.25191.71891.85991.44291.990单次光谱透射比平均值/%10.03410.15910.0509.85391.38891.54791.19191.571单次减光值/dB9.999.939.9810.060.390.380.400.38透射比总平均值/%10.0291.42减光值总平均值/dB9.990.39均匀性/dB0.050.02正反面差/dB0.080.01极差值/20.320.33光谱曲线平直度/%3.200.36

表16生产厂家北京京华兴科技有限公司标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80010.04210.00410.00110.19091.30691.36291.49791.15081010.0169.8989.90910.17891.15891.22191.28091.02282010.1159.93710.07710.24791.29391.35591.46791.15283010.1739.97110.18310.28491.26491.32291.53191.10684010.26010.13210.21410.43491.16191.21691.37390.99885010.30010.04810.34110.43491.32291.37091.49691.14286010.32910.22710.33210.48591.29991.33691.46191.14387010.35210.30710.34310.52991.22891.28091.43891.05188010.42210.27410.40510.60791.33891.40291.53191.20989010.49010.34710.57410.59291.36791.42391.60091.16390010.59710.43710.64710.74791.36791.42191.59391.19691010.62510.48010.63510.86691.40991.45291.61591.20692010.72110.64810.74210.87391.41291.45791.61891.24193010.79410.66610.83210.90991.54491.62991.79291.32894010.83710.70410.88911.08791.59591.64991.86091.35095010.92810.84710.98011.06391.57391.62791.81891.34596011.00010.85811.07811.18591.66691.68191.92091.43197011.07010.99611.10211.27191.63191.67691.89991.39398011.17411.03811.22611.30991.68991.69491.96491.43199011.25211.14911.30111.40691.72891.77092.03691.434100011.29611.19411.32011.43791.72891.74992.03091.452单次光谱透射比平均值/%10.60910.48410.62510.76891.43291.48191.65891.235单次减光值/dB9.749.799.749.680.390.390.380.40透射比总平均值/%10.6291.45减光值总平均值/dB9.740.39均匀性/dB0.060.01正反面差/dB0.060.01极差值/20.690.30光谱曲线平直度/%6.470.32

表17生产厂家不详标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80019.55919.80719.75019.50492.10892.16491.96092.06781019.66219.82419.78419.52591.87991.94291.71791.77282019.96320.20820.13719.91591.97592.03791.84391.93783020.20320.52420.47020.09291.91691.97491.80591.92684020.30320.57720.51520.17692.01092.06591.83691.96485020.52920.72820.70320.38992.17892.22692.04492.21986020.73420.99020.89620.59292.07292.10991.91692.07587020.93721.21421.14720.77992.16992.22191.99292.16088021.12421.30921.31720.95992.13192.19591.94692.11489021.34421.64621.57721.13292.25092.30692.14892.33490021.58121.83121.80721.39492.25692.31092.10692.30691021.79122.03221.99721.59992.27192.31492.03092.28192022.02322.17522.22921.83492.35492.39992.20292.37593022.27222.38722.52022.06092.44292.52792.32792.48094022.53322.78322.79822.28592.48492.53892.23492.53695022.74822.94322.99322.52692.52392.57792.38892.57596022.97123.15623.22522.73092.53792.55292.35292.61597023.19523.39623.46322.93392.57092.61592.36992.60298023.42223.65723.69723.17592.60492.60992.46992.65699023.63323.87723.94123.35792.66792.70992.51392.716100023.85424.14124.15623.58292.69492.71592.55392.718单次光谱透射比平均值/%21.63721.86721.86321.45492.29092.33892.13192.306单次减光值/dB6.656.606.606.680.350.350.360.35透射比总平均值/%21.7192.27减光值总平均值/dB6.630.35均匀性/dB0.050.01正反面差/dB0.040.00极差值/22.220.41光谱曲线平直度/%10.250.45

表18生产厂家/标称值10dB0.4dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%正面第1次/%正面第2次/%正面第3次/%反面/%80017.91118.05218.95018.88892.33292.45192.06491.58681018.03118.05418.52418.56892.21892.54492.10591.54782018.12018.09518.62418.72292.24492.34592.20491.84583018.36118.12218.12518.95492.20392.64492.18991.54784018.53518.10518.25418.52492.23592.31192.45191.57885018.78218.58318.96218.92292.24192.38192.06791.98986018.92718.67119.08319.06992.20792.34992.04592.10587019.14418.86719.32119.30292.30892.46692.09892.26388019.33019.14519.45919.49592.26492.42992.07192.11689019.56019.25819.76419.77292.29092.50292.05792.14790019.74919.49919.92019.93692.32892.51592.10292.16891019.96019.71920.16320.15292.38692.57892.18092.24192020.22220.07020.39320.41192.42992.61892.22392.35693020.44120.32620.65720.65392.45092.66292.20292.32294020.69420.44420.93920.94292.53792.78592.27292.40495020.92720.73221.15521.14992.53892.76092.29392.45796021.15820.97321.39321.39992.62292.86392.36892.48097021.38521.18421.62321.64792.66192.92392.39392.58798021.63221.39721.89021.87992.66592.91292.39092.52999021.84121.59722.13522.11792.70892.98492.40092.605100022.06421.77722.34022.33692.73893.01092.43692.636单次光谱透射比平均值/%19.84619.65120.08020.13592.41092.62192.22092.167单次减光值/dB7.027.076.976.960.340.330.350.35透射比总平均值/%19.9392.35减光值总平均值/dB7.010.35均匀性/dB0.090.02正反面差/dB0.060.01极差值/22.220.33光谱曲线平直度/%11.170.36

表19生产厂家不详标称值0.9dB波长/nm正面第1次/%正面第2次/%正面第3次/%反面/%80088.18288.33888.12788.33081088.19988.33588.06288.36182088.20688.34788.15888.33883088.36888.52688.25788.47984088.23788.40088.11088.41185088.27188.451