燃油燃气锅炉介绍.docx

燃油燃气锅炉介绍The Introduction of Oil (Gas)-fired Boiler卧式内燃油气锅炉 Horizontal Internal-combustion Oil (Gas)-fired Boiler 双锅筒纵置式燃油燃气锅炉 Double Drum Longitudinal Oil (Gas)-fired Boiler高炉煤气炉 Blast Furnace Gas Fired Boiler湿蒸汽发生器(注汽炉) Wet Steam Generator (Injecting Steam Boiler)卧式内燃油气锅炉系列The Series of Horizontal Internal-CombustionOil(Gas)-fired BoilerWNS0.5-1.0-Y.QWNS1-1.0-Y.QWNS2-1.25-Y.QWNS3-1.25-Y.QWNS4-1.25-Y.QWNS6-1.25-Y.QWNS8-1.25-Y.QWNS10-1.25-Y.QWNS15-1.25-Y.QWNS20-1.25-Y.Q卧式内燃油气锅炉结构特点Structure Characteristics of Horizontal Internal-Combustion Oil(Gas)-fired Boiler卧式湿背式三回程结构Horizontal wet-back and three-pass form structure燃烧室采用全波纹炉胆 Wholly corrugated furnace is used in combustion chamber管板、炉胆与锅壳采用板边对接结构 Butt joint structure of plate edge is used in Tubesheet, furnace and shell较大的炉胆直径，气体燃料燃烬好 Complete combustion of gas fuel because of large diameter采用高效传热元件螺纹烟管，烟速合理，传热好、阻力小Use efficient heat transfer element-threaded flue to achieve reasonable flue gas velocity, efficient heat transfer and small resistance烟管与管板采用先预胀再焊接的先进工艺Advanced process, that is welding after pre-bulging, is used in flue gas tube and tubesheet 锅炉控制安全与保护Safety Control and Protection燃烧机头位置保护 Head Position Protection of Burner 燃烧机阀门漏气保护 Valve Leakage Protection of Burner燃气压力异常保护 Abnormal Gas Pressure Protection 燃烧机熄火保护 Flameout Protection of Burning Machine排烟超温保护 Overheating Protection of Smoke Exhaust风压异常保护 Abnormal Wind Pressure Protection 点火程序吹扫保护 Purge Protection of Ignition Program风门限位保护 Protection of Position Stoppage with Air Door 锅筒蒸汽压力超高保护 Protection of Ultra-high Steam Pressure in Drum锅筒极低水位保护 Protection of Extreme Low Water Level in Drum锅筒低水位报警 Alarm Protection of Low water level in Drum锅筒高水位报警保护 Alarm Protection of High water level in Drum给水泵电机过载、短路保护 Feed Pump Motor Overloading and Short Circuit Protection送风电机过载、短路保护 Fan Motor Overloading and Short Circuit Protection双锅筒纵置式燃油燃气锅炉Double Drum Longitudinal Oil(Gas)-fired Boiler本系列双锅筒纵置式燃油燃气水管锅炉本体结构为D型布置,前墙配置机械压力雾化燃油（气）燃烧器，燃料在炉内燃烧，烟气经炉膛、过热器、对流管束和热管省煤器排至大气。锅炉运行热效率高，安全可靠，自动化程度高，具有高低水位声光报警，极低水位，汽压超高和中途熄火停炉等保护装置。 The boiler proper structure of this series of double drum longitudinal Oil(Gas)-fired Boiler is D-type layout. Mechanical pressure fuel oil (gas) atomization burner sets on the front wall. Fuel is burned in furnace, and fuel gas passing through furnace hearth, superheater, convection bank, and hot tube economizer, is finally rejected to atmosphere.The boiler runs at a high efficiency of heat,and a high degree of automation.It has sound and light alarms for high/ low water level, and protection assets such as ultra-low water level, super-high steam pressure, and furnace shutdown when flameout in midway.Thus, its safe and reliable. 双锅筒纵置式燃油燃气锅炉产品目录Products Contents of Double Drum Longitudinal Oil (Gas)-fired BoilerSZS10-1.27-Y.QSZS10-1.27/350-Y.QSZS20-1.27-Y.QSZS20-1.27/350-Y.QSZS35-1.27-Y.QSZS35-1.27/350-Y.QSZS40-1.27-Y.QSZS40-1.25/350-YSZS50-1.27-Y.QSZS50-1.27/350-Y.Q出口印尼20t/h启动锅炉20t/h Start-up Boiler that is exported to Indonesia锅炉型号 SZS20-1.27/350-Y Type of Boiler 额定蒸发量 20 t/h Nominal Capacity 额定工作压力 1.27 MPa Nominal Operating Pressure 额定蒸汽温度 194 Nominal Steam Temperature 给水温度 20 Feed-water Temperature 冷空气温度 30 Temperature of Cool Air 排污率 3 % Blowdown Rate 锅炉热效率 91 % Boiler Thermal Efficiency 燃料消耗量 1557 kg/h Fuel Consumption 出口印尼20t/h启动锅炉配套的热管省煤器Hot Tube Economizer that is supported to 20t/h Start-up Boiler that is exported to Indonesia产品特点： Products features：采用镍基钎焊翅片管技术，较同类产品寿命提高35倍，表面光滑，可减缓积灰。 Use Ni-Based Brazing Finned-pipe Technology to prolong product life three to five times; smooth surface to reduce ash deposition.热管单支点焊接，热管的热胀冷缩变形不受约束，避免了应力破坏。 Use heat pipe single branch spot Welding to avoid stress damage, because the heat pipe deformation that caused by hot or cold temperature is unconstrained.热管单管作业，单支或部分热管失效不影响设备的正常运行。 The invalidation of single branch or some parts of heat pipe dont effect the normal operation of equipments.换热两流体均走管外，可以翅片化。 Two heat transfer fluid runs outside pipes, and can be finned. 设备流体阻力小，换热效率高，结构紧凑。 Small resistance in fluid in equipment; high heat transfer efficiency; compact structure 安徽宣城电厂40t/h启动锅炉及锅炉房40t/h Start-up Boiler and Boiler Room for Xuancheng Power Plant in Anhui锅炉型号 SZS40-1.25/350-Y Type of Boiler 额定蒸发量 40 t/h Nominal Capacity 额定工作压力 1.25 MPa Nominal Operating Pressure 额定蒸汽温度 194 Nominal Steam Temperature 给水温度 20 Feed-water Temperature 冷空气温度 30 Temperature of Cool Air 排污率 3 % Blowdown Rate 锅炉热效率 91 % Boiler Thermal Efficiency 燃料消耗量 3280 kg/h Fuel Consumption 燃高炉煤气锅炉产品目录Products Content of Blast Furnace Gas Fired BoilerSHS10-1.27-QSHS10-2.45/400-QSHS20-1.27-QSHS20-2.45/400-QSHS35-1.27-QSHS35-2.45/400-QCSG35-2.45/450-QCSG40-3.82/450-QCSG75-3.82/450-QCSG75-5.3/485-Q75t/h高炉煤气炉75t/h Blast Furnace Gas Fired Boiler锅炉型号 CSG-75-5.3/485-Q Type of Boiler 额定蒸发量 75 t/h Nominal Capacity 额定蒸汽压力 5.3 MPa Nominal Operating Pressure 额定蒸汽温度 485 Nominal Steam Temperature 给水温度 150 Feed-water Temperature 冷空气温度 30 Temperature of Cool Air 排污率 2 % Blowdown Rate 锅炉热效率 87 % Boiler Thermal Efficiency 燃料种类 高炉煤气 Fuel Type Blast Furnace Gas 广东粤裕钢铁有限公司40t/h高炉煤气炉40t/h Blast Furnace Gas Fired Boiler of Yueyu Steel Ltd in Guangdong锅炉型号 CSG40-3.82/450-Q Type of Boiler 额定蒸发量 40 t/h Nominal Capacity 额定蒸汽压力 3. 82 MPa Nominal Operating Pressure 额定蒸汽温度 450 Nominal Steam Temperature 给水温度 105 Feed-water Temperature 冷空气温度 30 Temperature of Cool Air 排污率 2 % Blowdown Rate 锅炉热效率 87 % Boiler Thermal Efficiency 燃料种类 高炉煤气 Fuel Type Blast Furnace Gas低位发热值 780KCal/Nm3 Low Heating Value 燃料消耗量 40765Nm3/h Fuel Consumption 锅筒中心线标高 18480mm Center Line Elevation of Drum 锅炉深(钢架中心线) 10100mm Depth of Boiler(Center Line of Steel Frame) 锅炉宽(钢架中心线) 5300m Width of Boiler(Center Line of Steel Frame) 湿蒸汽发生器产品目录Products Content of Wet Steam GeneratorCSG-9.2/17.2-YCSG-9.2/17.2-Y.QCSG-23/17.2-YCSG-23/17.2-Y.QCSG-50/14-YCSG-50/14-Y.Q 湿蒸汽发生器(注气锅炉)结构特点Structural Features of Wet Steam Generator (Injecting Steam Boiler)运行采用自动控制用直流强制循环方式。 Automatic Control by D-C compulsory circulation. 50吨采用卧式结构，辐射段采用膜式壁方形结构，密封性好，吸热能力强，系国内外首创。 50t Boiler uses horizontal structure,and radiation section uses membrane wall square structure to achieve good sealing and strong endothermic capability; its first used both home and abroad . 9.2吨、23吨采用卧式结构，辐射管呈蛇形水平布置，易于检修和更换。 9.2t and 23t boiler horizontal structure, radiant tube sets snake-like layout for easily repairing and exchanging . 蒸汽干度为80%，辐射管不易积盐，水处理装置较为简单。 Steam Quality is 80%; reduce salification of radiant tube; simple water treatment devices. 锅炉整体及辅机设备安装在撬座或拖车上，运行方便，适用于野外作业。 Boiler and auxiliary equipments are set on bottom plates or trailers,the boiler suits for field work because of its easy operation. 燃烧方式为油（轻油、重油、渣油)气两用，燃料适用性广。 Oil (including light oil, heavy oil and residue )and gas can