煤矿井下单轨吊车的选型计算外文文献翻译、中英文翻译、外文翻译.doc
煤矿井下单轨吊车的选型计算外文文献翻译、中英文翻译、外文翻译
收藏
资源目录
压缩包内文档预览：
编号：145718595
类型：共享资源
大小：17.40KB
格式：ZIP
上传时间：2021-09-27
上传人：QQ14****9609
认证信息
个人认证
郭**（实名认证）
陕西
IP属地：陕西
12
积分
- 关 键 词：
-
煤矿
井下
单轨
吊车
选型
计算
外文
文献
翻译
中英文
- 资源描述：
-
煤矿井下单轨吊车的选型计算外文文献翻译、中英文翻译、外文翻译,煤矿,井下,单轨,吊车,选型,计算,外文,文献,翻译,中英文
- 内容简介：
-
Selection calculation of the monorail hoist in coal mineZHUANG YanAbstract：This paper introduces the applicable conditions and the selection calculation of the monorail hoist briefly, and pointe out its application characteristics. This provides the reasonable selection of the monorail hoist with the necessary theoretical basis. Keywords：monorail hoist; applicable condition; computing method; characteristicsMonorail crane is used in coal mine, especially in mining area up, down and down the mountain. Auxiliary equipment for transporting materials, equipment and personnel in working face drift. One of the preparations. Monorail crane can be divided into steel wire according to different traction modes. Rope traction and locomotive traction can be divided into two categories, and locomotive traction mode can be divided into two categories. There are two types of locomotive traction: explosion-proof clean diesel locomotive and battery locomotive. General information. The monorail crane trains for material, equipment and personnel transportation are composed of 3. When transporting heavy equipment, only one group consists of two groups. The load-bearing vehicle for lifting the composite beam.1 applicable conditions of monorail crane(1) Monorail crane is hanging on the roadway roof or support to transport negative load. It is not affected by floor deformation (floor heave) and material accumulation in roadway. A reliable hanging bearing device is required. Hanging on arched or trapezoidal steel support. When the support is mounted on the scaffold, it shall be reinforced with braces. When the anchor rod is used for suspension, each hanger shall be used. Two bolts with anchoring force of more than 60 kn shall be used for rail point. Roadway fault. The surface should be greater than or equal to 7 m2.(2) It can be used for horizontal and inclined roadway transportation. For inclined roadway. When transportation, the locomotive traction monorail crane, gradient 18 degrees, the best use. The slope is less than 12 degrees (the maximum is 40 degrees in foreign countries). Rope traction monorail crane gradient 25 and 45 in foreign countries. The maximum single piece transport mass is 12-15t. The minimum horizontal radius of curvature is 4 M.(3) Locomotive traction monorail crane has the characteristics of mobility and flexibility. Each locomotive can realize the transportation of materials, equipment and personnel in multiple branch roadways. Transportation, can not be reprinted, not limited by the distance. Monorail with rope traction. The crane needs to install a large number of rope pulleys on the curve, and can not enter the branch. The transportation distance is generally 1-2 km, and the maximum is not more than 3 km. Because of luck Long distance, train running resistance, traction rope resistance, track and support. The bearing capacity of the monorail, the guide wire rope and the. The tension of wire rope will tend to be complicated.(4) There is a small amount of pollution and difference in the exhaust gas of diesel monorail crane. Therefore, the use of roadway should have enough air volume to dilute harmful gas. Body, so as to achieve the degree of non-destructive health.(5) The biggest advantage of battery monorail crane is no air pollution. However, limited by the storage capacity of the battery, the battery monorail crane is difficult to operate. It is suitable for low traction and ventilation. Poor tunnelling for transporting materials and personnel.2 selection calculation of monorail craneThe main content of monorail crane selection calculation includes the selection of monorail crane. The type of winch, the calculation of the actual traction force, the choice of winch or diesel. Calculation of daily transportation capacity of single monorail crane and determination of mining area. Or the number of monorail cranes required by the whole mine.2.1 selection of monorail crane type(1) The necessary known conditions for monorail crane calculation are: transportation distance. The results show that: 1) the distance between the running track and the running track; 2) the gradient of the running tunnel; 3) whether the running track has branches; 4) the distance between the running track and the running track. The maximum mass of the single piece to be transported;5）whether to transport personnel. (2) According to the known conditions and the applicability of the above monorail cranes. Around, choose wire rope traction monorail crane or diesel monorail crane (also Explosion proof special type battery monorail crane can be selected.)2.2 calculation of traction and power of monorail craneIn order to calculate the traction force of monorail crane, the monorail crane must be determined first. The single maximum transportation volume of the vehicle, that is, the production volume served by the monorail crane is calculated. Point to material and equipment requirements. The calculation should be based on the quality of the material. The weight of each transport unit is 3 T, That is: 1) the transportation volume of each container is 2.5 T, and 3.5 t without container t. (2) materials less than 3.1 m in length are transported in containers, and those more than 3.1 m in length are transported in containers .M.General Monorail.Generally, the monorail crane only hangs 3-4 lifting beams at a time, that is to transport one beam. Each train can only transport 3-4 tons of materials, equipment and personnel each time. Transportation unit (or 3-4 people vehicles); transport large equipment such as hydraulic support. When erecting, the monorail crane can only hang one combined lifting beam. Monorail hanging train. The total mass of the vehicle is g, and the payload is Q. according to the above three conditions, the. The maximum value of (Q + G) is taken to calculate the traction force.(1) Calculation of traction forceF(Q+G)g /1000 B (cos +g sin ) (1)Where: F is the traction force of monorail crane, kn; G is the total mass of monorail Quantity, kg; q is the payload, kg; is the running resistance of monorail crane. Coefficient, = 0.3; is roadway dip angle, (); B is line efficiency, When the line is a straight line, B = 0.8, and b decreases by 0.01 for every 15 increase in horizontal curve.The traction force of winch or diesel locomotive is selected according to f value, and the latter needs to be adjusted, Slightly larger than the former.(2) Calculation of motor power. The shaft power n of traction winch can be calculated according to the following formulaN F v/ A (2)Where: V is the running speed, v = 2 m / S; A is the driving device efficiency75. According to the n value, select the motor capacity n standard, n standard n.2.3 selection calculation of wire rope for monorail crane with wire rope tractionThe traction winch of monorail crane is hydraulic friction winch with steel wire rope Closed loop.Its transmission principle is friction transmission, and the tension on both sides of the large friction wheel is FY And FL. The relationship between the two can be expressed by Eulers formula, that isF yFl e (3)Where: FY Is the tension at the point where the wire rope meets the friction wheel, kn; fl by. Tension at the separation point of wire rope and friction wheel, kn; is the tension between wire rope and friction wheel. Friction factor between wheels, = 0.1; is the friction factor of wire rope on friction wheel. The envelop angle is = 5 and = 900 degrees.(1) Tension calculation of wire rope at winch separation pointBecause f = FY - FL = fl(E - 1), so the wire rope is in the winch. The minimum tension fl min at the separation point of the friction wheel can be calculated by the following formulaFl min F/ (e -1)n (4)Where: n is the friction reserve coefficient, n = 1.15-1.2.(2) Calculation of breaking force of wire rope. The breaking force FB of wire rope can be calculated according to the following formulaFB Q+G 1 000 g ma sin 。 (5)Where: Ma For the safety factor of wire rope, transportation of general materials and hydraulic support Frame time MA= 6.5, when transporting personnel7.5。First, according to formula (5), calculate the damage of steel wire rope when transporting general materials. Breaking force FB1, breaking force FB2 of steel wire rope when transporting personnel and transportation fluid. When the support is pressed, the breaking force of steel wire rope is fb3.Compare FB1, FB2 and fb3, and take the maximum value as f b max,According to B and f b max, the standard values of breaking force FB and FB are selectedF b max, the diameter D of wire rope can be found out by FB standard.2.4 calculation of transportation capacity of monorail craneTo calculate the transportation capacity of a single monorail crane, the first thing is to calculate the capacity. Daily transportation of materials and equipment for each production point served by monorail crane. The total number of transport units is set as a; the transport unit transported by monorail crane each time. Number, set to B. It is known that the transportation distance is l, the running speed is V, and the transportation speed is v. The calculation method of transportation capacity is as follows.(1) Calculation of transportation capacity of monorail crane with wire rope traction. The monorail crane can not be transported on the line with branch due to the wire rope traction. So its transportation distance L is a fixed value. The time required for one cycle of monorail crane operation T1 = 2L /0.75 60 V + . (6)Where: l is the transportation distance, m; V is the running speed, M / S; 0.75. In order to consider the acceleration, deceleration and the reduction of turning speed, is the loading and unloading coefficient. And rest time, = 10-15 min. Daily working cycle number Z1 of monorail crane (take integer)Z1 t R /(t1). (7)Where: Z1. Is the number of working cycles per day of monorail crane; TR is the number of working cycles per day of monorail crane. The working hours of the car are two shifts a day, and each shift works 5-7 hours h. The lower limit is taken for mining area transportation and the upper limit is taken for roadway and ground transportation. The number of cycles the monorail crane should run to complete the calculation task Z2 (take integer)Z21.2/(BA). (8)Where: A is the sum of daily transportation units of each production operation point; B is the sum of daily transportation units The number of transportation units transported by monorail crane each time; 1.2 is the spare capacity system Count.If Z1Z2. It shows that the transportation capacity of monorail crane meets the requirements. On the contrary, other types of transportation equipment should be selected.(2) Calculation of transportation capacity of diesel monorail craneFor the monorail crane with diesel engine, it can be used in the line with branch. The transportation distance of each production operation is different, so in the calculation sheet. Time T1 for one cycle of rail crane operation L in equation (6) According to the weighted average distance Li. Substituting into the calculation.There are n production operation points, and each production operation point needs daily transportation. The units are A1 and A2 respectively， ，An. Transportation distance of each production point. The distance is L1 and L2 respectively， ，Ln. Then the weighted average distance Li byLi L1A1+L2A2+ +Ln An /(A1+A2+ +An). (9)Number of working cycles Z1And Z2 Calculation of single track crane with wire rope traction. The calculation of the car is the same. If Z1Z2. It can be filled with one diesel locomotive. If Z1Z2. According to calculation, several diesel locomotives are required. Diesel locomotives required for each production operation point (whole mining area or whole mine). The total number n (take integer) isN Z2 /(Z1). (10)Considering the need of maintenance and reserve, the number of maintenance and reserve is taken as 20% of the operating units, i.eTotal N = 1.2N. (11）3 characteristics of monorail crane transportation(1) The utility model has the advantages that the track is hung on the top plate or the support, and the operation is not affected. The influence of roadway floor deformation, water accumulation or material accumulation. Handling, lifting transportation is realized by hydraulic lifting beam, which has low labor intensity and high loading and unloading speed. Fast, equipped with working brake, parking brake and emergency brake 3 sets of brake settings. It is safe and reliable. Monorail crane with diesel engine (or battery) Transportation, with the characteristics of mobile and flexible operation, one locomotive can be used in transportation. Realization of continuous straight line in Roadway with variable slope, multi branch and multi branch without transferring. It has the advantages of small running resistance, high speed, high efficiency, less personnel and high efficiency. The amount of steel required for the track is less than that for the common rail.(3) Disadvantages require reliable monorail suspension, arched or the trapezoidal support should have corresponding reinforcement measures. Bolting and shotcreting roadway should be installed in the roof. Two bolts with anchoring force of more than 8 T are installed for suspension. Monorail crane for diesel engine. There is a small amount of pollution and pollution in the exhaust gas discharged by the locomotive, therefore, in addition to the locomotive itself. In addition to purification, the ventilation should be properly strengthened for the roadway, and the air volume should be controlled according to one roadway. The power of locomotive running at the same time is determined.煤矿井下单轨吊车的选型计算摘要：简要介绍了单轨吊车的适用条件、选型计算方法，指出了其应用特点，为井下单轨吊车的合理选型提供了必要的理论依据。 关键词：单轨吊车；适用条件；计算方法；特点单轨吊车是煤矿井下，尤其是在采区上、下山和工作面平巷内运送材料、设备和人员的辅助设备之一。单轨吊车按牵引方式的不同，可分为钢丝绳牵引和机车牵引 2 大类，而机车牵引方式又可分为防爆净化柴油机车和蓄电池机车牵引 2 种。一般情况下，承担材料、设备和人员运输的单轨吊列车均由 3组承载车组成
- 温馨提示:
1: 本站所有资源如无特殊说明，都需要本地电脑安装OFFICE2007和PDF阅读器。图纸软件为CAD,CAXA,PROE,UG,SolidWorks等.压缩文件请下载最新的WinRAR软件解压。
2: 本站的文档不包含任何第三方提供的附件图纸等，如果需要附件，请联系上传者。文件的所有权益归上传用户所有。
3.本站RAR压缩包中若带图纸，网页内容里面会有图纸预览，若没有图纸预览就没有图纸。
4. 未经权益所有人同意不得将文件中的内容挪作商业或盈利用途。
5. 人人文库网仅提供信息存储空间，仅对用户上传内容的表现方式做保护处理，对用户上传分享的文档内容本身不做任何修改或编辑，并不能对任何下载内容负责。
6. 下载文件中如有侵权或不适当内容，请与我们联系，我们立即纠正。
7. 本站不保证下载资源的准确性、安全性和完整性, 同时也不承担用户因使用这些下载资源对自己和他人造成任何形式的伤害或损失。
人人文库网所有资源均是用户自行上传分享，仅供网友学习交流，未经上传用户书面授权，请勿作他用。
|
2:不支持迅雷下载,请使用浏览器下载
3:不支持QQ浏览器下载,请用其他浏览器
4:下载后的文档和图纸-无水印
5:文档经过压缩，下载后原文更清晰
|
川公网安备: 51019002004831号