鸡西煤机电器图册

1、鄂尔多斯恒邦 专用鸡西煤矿机械有限公司产品编号： 201A24MJ007 发放时间： 年 月 日 前 言整机主要参数表项 目内 容采高范围 m2.34.2装机功率 kW730截割功率 kW2×300牵引功率 kW2×50过煤高度mm600滚筒直径m2.0滚筒截深mm 630摇臂型式整体弯摇臂牵引力 kN687调速方式交流变频工作面倾角15°泵站功率 kW30机面高度 mm1.489m 下切深度 mm465滚筒转速 r/min35摇臂摆动中心距mm7575摇臂长度 mm2160牵引速度 m/min7.1牵引型式齿轮 销排供电电压 V1140配套输送机SGZ764/6

2、30整机布置式积木式组合整机重量 t 55MG300/730-WD型交流电牵引采煤机是采用多电机驱动、横向布置，装机功率大，采煤机截割部设计强度为300kW，电机容量调整范围为200300kW，通过调整截割电机容量，可实现一机多型。即MG200/530-WD、MG250/630-WD、MG300/730-WD三种采煤机型，是中厚煤层综采工作面的理想首选机型之一。本机可通过更换行走部和支承组件分别适应764与800运输机，以适应不同的煤层地质条件而其它部件通用。主要适用于2.33.7m，煤质硬度f 4，煤层倾角15°（或40°）的综采工作面（或高档普采）。可在周围空气中的甲烷

3、、煤尘、硫化氢、二氧化碳等不超过煤矿安全规程中所规定的安全含量的矿井中使用。产品型号及含义：M G 300 / 730 - W D 电牵引 无链牵引 总装机功率（kW） 单侧截割功率（kW） 滚筒式 采煤机 总装机功率730kW，截割功率为2×300kW，牵引功率为2×50kW，调高泵站功率为30kW。牵引型式为齿轮-齿轨式。操作控制点位置设置在机身中间，可直接操作按钮或手把，也可以采用两端操作站或遥控器离机遥控。随机所带图册为受控文件，具有唯一的分发号（即合同号）、更改标识（是否含变更图册）及受控文件专用图章。图册详细描述了MG300/730-WD型交流电牵引采煤机的构成

4、。随机所带图册可作为采煤机使用单位定购配件使用。因局部改进及配套变化，与本图册不同之处，附带产品变更图册。如封面说明含变更图册，订购配件则依据变更图册为准！封面无受控文件专用图章，仅做为学习文件及订购配件参考。目 录24MJD总图0.124MJ01B电控部1.124MJ0102操作盖1.924MJ0103A显示盖板1.1024MJ0104开关腔前盖1.1124MJ-FT5A电气原理图1.1224MJ-FT6A电气接线图1.1624MJ02B左牵引部2.114MJ0201行星减速器2.514MJ0202惰轮轴组件2.710MJ0101一轴2.810MJ0102二轴2.9MDP0216液压制动器2

5、.1024MJ03B右牵引部2.1124MJ0601过滤器2.1615MJ0201控制阀组2.1724MJ0304压力表组2.1824MJ21B行走部3.1MHJ0301行走轮组件3.324MJ34A左截割部4.114MJ0402一轴4.514MJ0403二轴4.614MJ0404A三轴4.714MJ0405四轴4.814MJ0407A行星减速器4.1014MJ0408A内喷雾供水装置（左）4.1214MJ0411C润滑管路4.1424MJ35A右截割部4.1514MJ0505A内喷雾供水装置（右）4.1924MJ06B液压系统5.110MJ0504液压锁5.524MJ07冷却喷雾系统6.12

6、4MJ0701外喷雾分水阀6.324MJ0703水阀6.410MJ0602 分水阀6.514MJ15托缆装置7.110MJ0502B调高油缸8.114MJ17T支承组件（滑靴式）9.124MJD总图24MJD（730）整机明细表序号图号图名数量单重总重序号图号图名数量单重总重124MJ34A左截割部174397439302020504001GB/T 6171-2000 螺母 M42×330.5981.794224MJ-8左操作站护罩159.8459.843124MJ-13油缸铰轴压盖25.9811.96324MJ08-1压板40.2921.1683210MJ-3A铰轴231.162.

7、242071503004GB/T 70.1-2000 螺钉 M6×16120.0050.063314MJ17T支承组件（滑靴式）2154.795309.59524MJ21B行走部21469.262938.52342040503011GB/T 93-1987 垫圈 20100.0150.15610MJ-2定位销412.349.2352011109008GB/T 5783-2000 螺栓 M20×7020.2120.424714MJ15拖缆装置11021023610MJ0502B调高油缸2466.107932.214824MJ02B左牵引部16710.646710.643715

8、T4-2000×660采煤机螺旋滚筒222954590924MJ02-2前盖板151.351.33824MJ-5C弯丝杠169.569.51024MJ07冷却喷雾系统172.882872.88283914MJ-6皮带盖板28.5171124MJ-3铰轴231.863.64010MJ-13压板22.635.261210MJ-7压板22.154.3412011109004GB/T 5783-2000 螺栓 M20×5060.1520.912132011107003GB/T 5783-2000 螺栓 M12×25590.0251.4754220MJ-53垫圈80.342

9、.72142040502007GB/T 93-1987 垫圈 12590.0040.2364324MJ-2C丝杠166.166.11514MJ06-10螺栓 M36×3×150121.75214420MJ-54压板60.10.61624MJ03-3前盖板192.892.8452011106002GB/T 5783-2000 螺栓 M10×16120.0130.1561724MJ03B右牵引部19205.069205.06462040502006GB/T 93-1987 垫圈 10120.0030.0361824MJ-12摇臂铰轴盖板45.4821.92472011

10、110001GB/T 5783-2000 螺栓 M24×5090.2292.0611924MJ-9右操作站护罩191.2291.22482040503013GB/T 93-1987 垫圈 2490.0210.1892024MJ35A右截割部1743974394924MJ06B机外油管组152.252.22124MJ-3C轴275.5151502011109002GB/T 5783-2000 螺栓 M20×4080.1210.9682224MJ-4C轴254.37108.74512071508002GB/T 70.1-2000 螺钉 M16×3040.0770.30

11、823GY42液压螺母M42×352.211522040502009GB/T 93-1987 垫圈 1640.0070.028242040504015GB/T 93-1987 垫圈 36340.0521.7682524MJ-7C螺栓M36×3×205222.3451.482614MJ-2方螺母220.6614.522724MJ01B电控部1855085502824MJ-15B整机铭牌11.61.62924MJ-1C丝杠23570 24MJ01B电控部24MJ01B电控部明细表序号图号图名数量单重总重序号图号图名数量单重总重124MJ0101B电控箱壳体15884.

12、465884.46302071506003GB/T 70.1-2000 螺钉 M12×3050.0390.195224MJ0105牵引变压器腔前盖165.8865.88312040902008GB/T 97.2-2002 垫圈 12120.0050.0634MJA19-2护板20.170.343224MJ0116隔离开关支架119.4119.4144MJA19-3护板10.150.153326MJ08-22A瓦斯传感器压板20.1850.375变频器键盘 TX312R100342071503002GB/T 70.1-2000 螺钉 M6×1240.0050.026GJC4

13、甲烷传感器(配接甲烷传感器电源模块)1113524MJ01-11压条20.0180.036724MJ0104开关腔前盖181.6681.66362070704002GB/T 67-2000 螺钉 M3×540082071503011GB/T 70.1-2000 螺钉 M6×5040.0130.052372040501001GB/T 93-1987 垫圈 3300092040501004GB/T 93-1987 垫圈 66200382040901002GB/T 97.2-2002 垫圈 330001014MJ30-8垫板10.4350.435392071502003GB/T

14、70.1-2000 螺钉 M5×1260.0030.018112071505005GB/T 70.1-2000 螺钉 M10×30520.0271.404402040501003GB/T 93-1987 垫圈 51800122040502006GB/T 93-1987 垫圈 10960.0020.19241变压器 ZQSG-160/1.14/0.38-7301580580132040902007GB/T 97.2-2002 垫圈 10320.0040.128422011108003GB/T 5783-2000 螺栓 M16×3530.0640.1921420715

15、04010GB/T 70.1-2000 螺钉 M8×5040.0240.096432100500011GB/T 1972-2005 碟形弹簧 A31.560.010.06152040501005GB/T 93-1987 垫圈 81040.0020.2084424MJ0110B左上盖板165.98865.9881624MJ0103A显示盖板161.20961.2094524MJ0109B右上盖板154.38854.388172011107021GB/T 5783-2000 螺栓 M12×302900.038.74624MJ01-7支板40.291.16182040502007

16、GB/T 93-1987 垫圈 123040.0041.216472071505004GB/T 70.1-2000 螺钉 M10×2540.0250.11924MJ0114支架组件19.759.754812MJ0129-11尼龙套管240.24.820变送器 TXBS-730166492070704009GB/T 67-2000 螺钉 M3×25300.0010.032124MJ0102操作盖181.281.250插接件 CA-20JW/KA20022主控器 TXZK-730113.513.551插接件 CA-14JW/KA1232071505003GB/T 70.1-20

17、00 螺钉 M10×20200.0220.4452甲烷传感器电源模块DXJ-24/1210.60.6241060103201GB 1235-1976 O形密封绳 5.72100000532071502006GB/T 70.1-2000 螺钉 M5×2040.0040.0162524MJ0115主控器支架17.197.1954空气开关 DZ47-60/C10 230/400V426变频器 TXBP-S4-04-7302326455空气开关 DZ47-60/C5 230/400V1272071505007GB/T 70.1-2000 螺钉 M10×4080.0320.

18、25656整流桥 20A/600V22824MJ01-4压块120.232.7657主控继电器板 ZKJDB129接触器 CKJ5-400/1.14 AC36V311.534.55824MJ0106主控腔上盖263.82127.6424MJ01B电控部总明细表序号图号图名数量单重总重 序号图号图名数量单重总重592071504004GB/T 70.1-2000 螺钉 M8×2080.0130.104892070904003GB/T 65-2000 螺钉 M8×16360.0090.324602040901006GB/T 97.2-2002 垫圈 8160.0020.0329

19、04MJ08-35接地标志70.0160.1126110MJ68-44绝缘管200.00190.038914MJ0815B主接线柱313622070705008GB/T 67-2000 螺钉 M4×25200.0020.04924MJ0816七芯接线柱140.431146.03596632040501002GB/T 93-1987 垫圈 420009324MJ0111接线腔右盖板170.5570.55642040901003GB/T 97.2-2002 垫圈 420009410MJ68-24胶垫30.0160.0486524MJ01-6底板14.254.259514MJ30-17接线

20、弯头34.36313.08966互感器 CS30 300Aac/5Vdc29610MJ68-18密封圈21.4212.84267互感器 CS30 200Aac/5Vdc29710MJ68-19垫圈30.0660.198682070706006GB/T 67-2000 螺钉 M5×2080.0030.0249810MJ68-20堵板30.13680.4104692040901004GB/T 97.2-2002 垫圈 512009910MJ68-21压板31.4814.4437024MJ01-3接触器座板35.6316.8910010MJ68-22压片30.03780.11347124M

21、J0113支架1881012071505009GB/T 70.1-2000 螺钉 M10×50140.0390.54672变压器 GX-0.5/1.14/36V/25V/24V-73016.56.51022071505006GB/T 70.1-2000 螺钉 M10×35140.030.4273变压器 GKB-0.35/1.14/220V/32V/27V/20V/15V14410314MJ30-26密封圈1742070607006GB/T 68-2000 螺钉 M6×25120.0050.0610414MJ30-16接线弯头14.984.9875202030600

22、3GB/T 6170-2000 螺母 M6120.0020.02410510MJ08-42胶垫10.0220.02276隔离开关 GM2-400/1140V10010610MJ08-19接线弯头13.783.7877隔离开关 GM3-250/1140V110714MJ60-3密封圈10.680.687814MJ30-4隔离开关座板15.015.0110810MJ08-17垫圈10.00510.0051792011107020GB/T 5783-2000 螺栓 M12×25150.0250.37510910MJ08-16堵板10.030.0380电抗器电容器组 TX-D4-04LC11

23、1010MJ08-18压板10.560.568124MJ0107开关腔上盖185.2285.2211110MJ08-39压板10.0750.07582熔断器 RT0-200A/150A61122071504005GB/T 70.1-2000 螺钉 M8×25420.0150.63832070608006GB/T 68-2000 螺钉 M8×30120.0120.14411310MJ68-11接线弯头24.8449.688842020308003GB/T 6170-2000 螺母 M8120.0050.0611410MJ68-12密封圈30.4891.4678524MJ010

24、8牵引变压器腔上盖171.3271.3211510MJ68-14垫圈30.09560.28688624MJ01-1小盖板113.113.111610MJ68-13堵板30.20780.62348724MJ0112接线腔左盖板164.3664.3611710MJ68-15压板31.424.268822MJ0807主接线柱120.51936.231611810MJ68-16压片30.0430.12924MJ01B电控部明细表序号图号图名数量单重总重序号图号图名数量单重总重11910MJ68-23胶垫30.020.061204MJ08-24垫圈440.0110.4841214MJ08-23A密封圈1

25、80.0160.2881224MJ08-22堵板220.0270.5941232071504008GB/T 70.1-2000 螺钉 M8×40440.020.881242071503004GB/T 70.1-2000 螺钉 M6×16440.0050.221254MJ08-21压板220.0110.2421264MJ08-20喇叭口220.46810.29612722MJ08-41密封圈40.0220.08812824MJ0188电气系统框图112913013113213313413513613713813914014114214314414514614724MJ0102

26、操作盖24MJ0103A显示盖板24MJ0104开关腔前盖24MJ-FT5A电气原理图24MJ-FT6A电气接线图24MJ02B左牵引部24MJ02B左牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202001液压用液位液温计 YWZ-80T13024MJ02-1后盖板1464622011108006GB/T 5783-2000 螺栓 M16×5040.0920.3683114MJ0202惰轮轴组件132.132332.132332040502009GB/T 93-1987 垫圈 16160.0070.1123210MJ01-10堵11.021.0241110

27、300006接头座 JKU-1910.2710.2713310MJ01-11压盖10.370.3751110200006堵 JKD-1910.1170.117341060102035GB 1235-1976 O形密封圈 80×3.1161110100006U形销 UK-1910.0220.0223524MJ0201B左牵引部机壳15380538071060110011JB982-1977 垫圈 3013614MJ02-7A套25.2410.4881060102017GB 1235-1976 O形密封圈 24×2.413714MJ02-6A套23.286.5692071506

28、002GB/T 70.1-2000 螺钉 M12×25520.0351.823814MJ0201行星减速器1632.609632.609102040502007GB/T 93-1987 垫圈 12520.0040.208392071508003GB/T 70.1-2000 螺钉 M16×35120.0841.008111060103201GB 1235-1976 O形密封绳 5.71260401030101012电动机 YBQYS3-5014204201214MJ0206盖板117.5917.5913MDP0108透气塞10.370.371414MJ0204A盖板139.0

29、539.05151110300005接头座 JKU-1610.2280.228161110100005U形销 UK-1610.0180.018171060110010JB982-1977 垫圈 271181110300003接头座 JKU-1020.0840.168191110100003U形销 UK-1020.0090.018201060110008JB982-1977 垫圈 2220.0040.0082114MJ02-4小盖板19.49.42210MJ0108放油塞10.240.24232100201016Q/JM 861-2001 垫圈 3310.0060.00624矿用本质安全型温度传

30、感器 GWD2001251060110007JB982-1977 垫圈 2012610MJ0101一轴147.11547.11527MDP0216液压制动器110.210.22810MJ01-12小压板10.1340.1342910MJ0102二轴159.46959.46914MJ0201行星减速器14MJ0201行星减速器明细表序号图 号图 名数量单重总重序号图 号图 名数量单重总重110MJ0103-3座142.8542.8530MEK0212-9行星轮46.9727.88214MJ0201-3行星架146.8846.88312050417001Q/JM 114.2-2006 销子 25&

31、#215;5040.1460.584310MJ0103-2齿轮152.252.232MEK0212-12外套40.0660.26442050416002Q/JM 114.2-2006 销子 20×4520.0870.17433MEK0212-13行星架18585510MJ0103-1联接盘115.615.63414MJ0201-1盖174.874.862031008073GB/T 894.1-1986 挡圈 18010.1420.14235MEK0212-14心轴43.112.4714MJ0201-5垫10.040.04361011605018SKF 滚动轴承 16044/220&#

32、215;340×37182030307051GB/T 893.1-1986 挡圈 9010.0250.02537MEK0212-16小盖119.519.5914MJ0201-6垫10.140.1438MEK0212-17套13.43.41014MJ0201-2太阳轮14.864.863914MJ0201-4大太阳轮110.410.4111010617008GB/T 276-1994 滚动轴承 61936/180×250×33211.322.6401060102031GB 1235-1976 O形密封圈 65×3.110.0030.0031210MJ010

33、3-21套10.070.0741MEK0212-3限位垫10.050.051310MJ0103-20挡圈10.190.1942MEK0212-2塞10.040.04142071508002GB/T 70.1-2000 螺钉 M16×3080.0770.616432031007045GB/T 894.1-1986 挡圈 6510.0180.018152040502009GB/T 93-1987 垫圈 1680.0070.056441060102105GB 1235-1976 O形密封圈 205×5.71162071506003GB/T 70.1-2000 螺钉 M12

34、5;30280.0391.092451060108127GB/T 9877.1-1988 密封圈 BD220×250×151172040502007GB/T 93-1987 垫圈 12280.0040.11246MEK0212-18调整垫片50.0240.121814MJ0201-7套30.020.06471060102149GB 1235-1976 O形密封圈 370×8.611914MJ0201-8行星轮36.73520.205481060102159GB 1235-1976 O形密封圈 500×8.61202030307059GB/T 893.1-

35、1986 挡圈 11030.0480.14449MEK0212-19O形圈525x8.610.0020.0022114MJ0201-9内齿圈147.56947.569502030308062GB/T 893.1-1986 挡圈 12040.0570.228221010201008GB/T 288-1994 滚动轴承 22212C/60×110×2861.126.7251GB/T 288-1994 滚动轴承 22311C/55×120×4382.2718.162314MJ0201-10轴32.537.59242030307043GB/T 893.1-198

36、6 挡圈 7030.0160.0482514MJ0201-11联接盘153.8353.832614MJ0201-13环10.140.14271010616010GB/T 276-1994 滚动轴承 61928/140×190×2411.71.72814MJ0201-12齿圈165.3465.3429MEK0212-11内套40.0850.3414MJ0202惰轮轴组件10MJ0101一轴10MJ0102二轴MDP0216液压制动器24MJ03B右牵引部24MJ03B右牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202003液压用液位液温计 YWZ-

37、150T1302040501005GB/T 93-1987 垫圈 840.0020.008215MJ0201控制阀组168.496668.4966311060102039GB 1235-1976 O形密封圈 100×3.110.0040.00432040502009GB/T 93-1987 垫圈 16330.0080.264322100104012Q/JM 864-2001 内六角螺塞 M33×210.110.2242071508009GB/T 70.1-2000 螺钉 M16×65100.131.3332100201016Q/JM 861-2001 垫圈 332

38、0.0060.018524MJ03-4滑轨26.5133424MJ03-5盖11.441.4462100104027Q/JM 864-2001 内六角螺塞 M30×1.510.1090.109351991100019过滤器 WU-160×180-J10.40.472100201014Q/JM 861-2001 垫圈 3010.0060.0063610MJ0108放油塞10.240.24824MJ0304压力表组110.14310.1433714MJ02-7A套25.2410.4892011108003GB/T 5783-2000 螺栓 M16×3530.0640.

39、1923810MJ01-10堵11.021.02102011108006GB/T 5783-2000 螺栓 M16×5040.0920.3683910MJ01-11压盖10.370.37111030101012电动机 YBQYS3-501420420401060102035GB 1235-1976 O形密封圈 80×3.11121990202001液压用液位液温计 YWZ-80T14114MJ0201行星减速器1632.609632.6091324MJ0301B右牵引部机壳1730073004214MJ0202惰轮轴组件132.132332.1323142071506002GB/T 70.1-2000 螺钉 M12×25950.0353.3254310MJ0102二轴159.46959.469152040502007GB/T 93-1987 垫圈 12860.0040.3444424MJ02-1后盖板146461614MJ02-4小盖板19.49.44510MJ01-12小压板10.1340.13