环氧树脂地坪漆工程施工方案12.28.doc

temporary construction organization design requires the implementation of the overall layout. 2 site near the high voltage line protection near power lines to have a reliable protective measures protective closely, to meet safety requirements. 3 branch set up distribution box into outlet sleeve and a cross arm to be used; Access to wires neatly, reasonable matching; Prohibited the use of insulation is poor, aging skin, broken wires, to prevent leakage; Should be fixed by insulators, and overhead laying; Line the hallway to have a reliable protection; Direct buried lines, laying depth of not less than 0.6m, leads to the ground from the 2m height to the ground at 0.2m, you must set up protective casing. 4 spot lights hand-held lamp 36V safe voltage should be used; 36V safety at hazardous voltages, particularly in hazardous areas using 12V; Lighting wires should be fixed on the insulators; Insulated rubber sheathed cable for field lights, lighting the use of sheathed wires; Lighting circuits and lighting from the ground not less than the prescribed distance, prohibited the use of electric arc furnace; To prevent the wire insulation is poor, aged, broken skin and leakage, with tungsten heating is strictly prohibited. 5 to set up low-voltage lines are not allowed to use bamboo poles, pole cross arm should be established and insulators; Fine wires can not be mounted on scaffolding or tree branch; Overhead lines required high enough off the ground. 6 electric . Project name: 5-5-2 sequential order of the subsidence observation observation point number support (supporting) and diagrams year month day year month day year month Day, the distance (m) deformation (mm) the relative distance (m) deformation (mm) the relative distance (m) deformation (mm) today this this this this cumulation Engineering formwork supporting system self-test State observer records form template project name: construction site: construction: support materials: Ann 5-6 serial number check project check requirements behave records results 1 construction programme programme full, support system design calculation, and approval procedures complete, job Qian should for security low-down, low-down material full 2 support material support column material: wood Rod application pine or FIR, shall not used easy deformation, and decay, and split crack, and dry section of wood; as used pipe, pipe od shall not is less than 48x3.5 of pipe, no serious rust, and crack, and deformation 3 column stable column bottom of pad material, Shall conform to the construction design requirement, do not use bricks blocked up by construction organization design requirements, support height () when m, between columns of the level of support set () road horizontal support, vertical scissors spacing (), m, spacing for horizontal scissors () m. Column spacing in accordance with design requirements, portrait () mm, transverse () mm pole joints should be staggered, long barstavebn tm vdce mst een. een by mlo zahrnovat analzu rizik, monost nehod charakteristik a nouzovch postup, nouzov zpracovn a obsah opaten. 4, integrovan pohotovostn plny, speciln havarijn plny a mst een by mly bt mezi sebou a s ostatnmi jednotky zapojeny v nouzi, kter jsou vzjemn propojeny. 5, havarijn pln by ml zahrnovat havarijn personl a organizace kontakt, nouzov rezervn seznam a dal informace. Informace by mly bt pravideln aktualizovny a zajist, e informace jsou pesn a platn. tyi, havarijn pln revize 1, Recenze pohotovostn plny pezkoumn formul a prvky pezkumu a opaten pijatch dvma zpsoby. Kdy host slou pedevm pro havarijn plny pro zznam v podob Recenze, prvek hodnocen pro nouzov hodnocen. . Kd pro porn ochranu konstrukce budov a nsk republice ny exploze nebezpen oblasti elektrick bezpenostnch pedpis a pedpis o porn ochranu design rafinaci ropy a chemickch podnik, napklad poadavky na pedpisech a nazench. 2. pi provdn instalace me zpsobit por, exploze, kter sti by mly bt pln nastaven peht, petlaku, micch pstroj, alarm (zvuk a svtla). 3. kde je holav plyn (pra) me unikat , holav plyn koncentrac detekce, alarm by mla bt nastavena. 4. vechny komunikoval s holav, vbun zazen s inertnm plynem, plynov penosov potrub, by mla bt nastavena zabrnit holavch a vbunch ltek do zazen, ale nemla bt samostatn zptn ventil. 5. holav plyn (pra) nastavit plamen svodi odvzduovac vvod, snadno pracovat, kde se zastavit ventily, aby pi vstupn vtrac potrub je v plamenech, peruil por plynu odvzduovac potrub ml bt nainstalovn v nejni hasicho zazen. 6. kdy dopravu holavch materil by mla odpovdat prmru potrub a stedn mrn odpor, sprvn zen prtoku, co nejvce se vyhnout statick elektiny. Antistatick opaten, jako jsou zazen, potrub, by mlo bt v souladu s technickmi pedpisy pro uzemnn design pro chemick podniky pslunch ustanoven. 7. nhl vbun petlaku nebo rychlho rozkladu vrobnch zazen nebo skladovacch zazen by mly bt vybaveny vbuchu (nevbun membrna), vvoz nonel trubice smrem k bezpenosti a aby prevence sekundrnch exploz, protiporn opaten. 8. vrobnthe principle of simplified EIA of construction projects in the region. In terms of land, linked to the implementation of urban and rural construction land increase and decrease, replacement indicators for priority areas project. Charges, into the projects of water, electricity, administrative charges and preferential policies. In the area of taxation, and settled in areas of industry and its production company, within 5 years after the completion of fiscal incentives to enterprises. In terms of financing, integration of land, tax, financial and other resources, and construct Government credit + business credit credit system, establishment of marketization, commercialization and modernization of the investment and financing platform; effective Bank-enterprise docking, encourages private capital into the Park, to raise industry development fund. 5, optimize the environment and service industries. To create policy lowlands, Highlands, integrity of service land, development land as the goal, to optimize the area under development environment. All administrative law enforcement departments to appoint a full-time personnel stationed in areas dedicated to coordinating and solving problems associated with businesses in this sector. When there are substantial issues, sector leaders arranged to personally intervene, in-person, in-person push tangible area building a green light, easy line. To further reduce and standardize administrative examination and approval items, simplify examination and approval links, improve efficiency; according to the .Since the educational practice of the mass line of the party, himself seriously in the education, practical control central eight rules and opposing the four winds and practicing three Suns, and check the spirit of Jiao Yulu, ideology, solicit opinions based on outstanding problems checked swing, careful analysis and reflection. Will now check report is as follows: first, adherence to the partys political discipline, eight in the central provision, change the style of the basic situation of 1, in compliance with the partys political disciplines. Conscientiously abide by the partys political discipline, abide by the Constitution and the rules and regulations of the party, in the political, ideological and maintain highly consistent with the CPC Central Committee on the action, there is no violation of the partys political discipline problems. 2, in the implementation of the central authorities of the eight provisions. Improving research, improving research methods, but there are less grass-roots units, primary first-hand an inadequate grasp of the problem, which is to be strengthened in the future. Second, construction, strictly in accordance with the provisions to streamline and improve the quality of meetings of the Conference. Third, streamlining file briefs, culture involves all aspects of propaganda and ideology, sometimes due to the practical needs of invention notifications, this area needs further环氧树脂地坪漆工程技术要求一、施工技术说明1楼梯环氧树脂地坪漆施工方案(1) 工法： 2.0mm环氧光面平涂工法（2）质量性能评估： 1）化学性能符合国家标准和行业标准。2）物理性能符合国家标准和行业标准。3）漆膜成型厚度：最薄处不得小于1.8。4）漆膜成型止滑功能：为轻度止滑效果。5）漆膜成型表面色泽：整体表面统一（3）图示：2.0mm环氧树脂地坪漆工程施工说明（图示）面涂一道 （面涂一道）面涂一道 （平涂面涂一道）中涂二道 （腻子粉二道）中涂一道 （砂浆层一道）环氧底涂一道 （底涂一道）基础面 （基面补平打磨处理）（4）需提供1的样板。2.环氧树脂地坪施工工艺1）主要施工流程A. 施工准备+基面处理B. 环氧底涂涂装一道C. 环氧腻子中层+腻子粉二道D. 环氧树脂平涂面涂涂装一道E. 环氧树脂面涂涂装一道F. 清 理 维 护、地 坪 养 护2）施工工艺A.基面处理用专业打磨机对基面进行打磨，并检查基底有无裂缝、空壳，如有，则须深层切割清理后用环氧树脂砂浆填补。由于环氧树脂不溶水，所以在处理过程中只能进行干处理，清理时不可野蛮敲打，以免敲松边上的基层。B.环氧树脂底涂涂装对基面吸尘干净后，在进行基底处理的同时，可进行环氧底涂涂装，保证材料在涂装时仍符合可使用时间，在胶化前被涂刷完，让材料保持良好的渗透性，保证粘接性能。C.环氧中涂涂装 在底涂固化干后（约8小 时），首先采用环氧砂浆将脱层破损的地面修补平，再将已按比例搅拌混好的环氧砂浆用平刀批刮，使用小型专业手磨机充分打磨环氧砂浆层，使达到初步平整；D.环氧树脂面涂涂装 环氧腻子砂浆层固化后打磨修饰平整并吸尘干净，在确保封闭的表面滚涂平涂面涂一道，固化后再滚涂面涂一道，以达到现场所要求的轻度止滑表现效果。涂装施工的环境要求：施工基面应保持干净，无其他工程施工交叉作业。E.现场清理维护、地坪养护 面涂完成后将有关施工材料、工具搬离现场，严密封闭保护完成饰面，至少24小时后才可允许人进入行走。并不可带进泥沙，漆膜完全固化一般需7天时间，期间应避免进行其他工程施工、搬运、安装等施工。F.现场派驻工程技术人员现场监督，以保证工程质量及工程进度顺利完成。3.地脚线施工1）清除表面灰尘、墙面少量开裂涂料，按要求打水平线。涂刷专用环氧封闭底漆。对空洞、裂缝处使用环氧树脂腻子修补；固化干透后打磨、除尘。面涂漆二道2）检查立面有无气孔残留未封闭、有无突出粉粒，并及时填补气孔及打磨除尘，滚涂平涂面涂一道，固化干透后再滚涂面涂一道，以达到现场所要求的轻度止滑滚面表现效果。3、注意事项3.1施工注意事项3.1.1雨期施工：如空气湿度超出施工条件时，应增加人工排风设施（排风扇等）控制湿度。遇大雨、高湿度等天时应停止施工。3.1.2树脂整体面层施工时，环境温度不得过低、过高，湿度不得过大，防止树脂砂浆产生假固化（根据材料说明书）。3.1.3施工场所应注意通风良好。3.1.4施工中涂料避免接触皮肤，最好双手能有保护手套。3.1.5施工中玷污处要清洗干净，施工后顺将场地、垃圾清除完毕。3.1.6地面灰尘须彻底清除，以确保底漆之接着效果。3.1.7地面潮湿时须使之干燥，含水率8%以下，或者选用特殊底漆。3.1.8环氧树脂的各层涂料若出超出有效接着地间，须将材料表面打粗并处理干净，涂上一层底漆（依间隔时间长短），再进行上层涂料施工。3.1.9底漆须待完全挥发后方可进行施工，以免起泡现象。3.1.10材料调配时，须以底布（或纸板）垫底半避免任何一种材料单独滴于素地上，造成不干，若已滴于素地上时须立即擦去。3.1.11搅拌后的材料应在可使用时间内涂布完毕，避免表面接近硬化无法流平。3.1.12涂布发现砂粒或其它杂质时，应立即清除。3.1.13环氧树脂防尘耐磨地坪施工时应注意其混合比例，混合搅拌均匀才可使用。3.1.14施工现场条件湿度应低于RH85%，温度在5以上，如不合于此标准时，请停止施工或改用其它低温耐湿产品以免表层不干或发白。3.2安全操作要求：3.2.1施工现场临时用电应符合国家现行标准施工现场临时用电安全技术规程和现行地方标准的要求。3.2.2对某些物质有过敏反应的施工者不得参加施工。3.2.3在易燃、易爆区域内动火时，必须采取防范措施，办理动火证后，方可动火。3.2.4临时用电线路、设备，必须经认真检查，符合安全使用要求后，方可使用。用电设备必须进行接地；在防爆区域内施工，必须采用防爆电器开关，其照明灯具必须彩用36V低压和防爆灯。3.2.5在通风条件不好的空间施工，应有通风排气设备。有害气体、粉尘不得超过允许浓度。操作人员应佩戴口罩、手套、工作服等。3.3环保措施3.3.1施工垃圾和零散碎料要及时清理，集中消纳。3.3.2装卸材料应做到轻拿轻放，夜间运输车辆进入施工现场，严禁鸣笛，减少噪声扰民。3.3.3防腐蚀所用的各种材料应封闭存放，不得遗撒，废料和包装容器应及时回收，统一处理。3.4消防保卫管理措施3.4.1施工现场必须坚持“预防为主，防消结合”的工作方针，认真贯彻中华人民共和国消防条例，逐级落实防火责任制，利用多种形式对工人进行宣传教育，做到人人重视消防工作。3.4.2参加施工的所有人员，入场前都要进行“四防”教育，学习现场的各项规章制度和国家法规，使每个施工人员做到制度明确、安全生产、文明施工。3.5成品保护措施3.5.1对所覆盖的隐蔽工程要有可靠的保护措施，不得因为地面施工造成漏水、堵塞、破坏或降低等。3.5.2树脂面层完工后应采取挂牌、拦挡给以施工人员提示，避免受到破坏。3.5.3施工中不得污染、损坏其他工种的半成品、成品。二、质量保证（一） 工程质量保证期（简称“质保期”）为两年。质保期自工程竣工验收之日起计算，质保费用计入总价。（二） 质保期内，中标人负责对其提供的货实行包修、包换、包退、包维护保养，不再收取任何费用，但不可抗力（如火灾、雷击等）造成的故障除外。（三） 工程质量报修12小时内响应。（四） 所有质保服务方式均为中标人上门服务。（五） 在质保期内，中标人应在一定时间内对所提供的工程及设备做定期检查和保养。三、技术参数： 地板类别技术参数项 目2.0mm环氧树脂平涂地坪干燥时间表干2h实干24h承 载2000kg耐 磨 性(750g/1000r失重)0.03 g铅笔硬度1-2H抗弯强度18 MPa抗压强度50 MPa耐冲击性30.cm附着强度1级耐机油、柴油60天无变化耐20%硫酸20天无明显变化 注：以上数据系依据实验室条件制样检测而得，仅供参考。四、环氧树脂地坪涂料用量2.0环氧树脂地坪 方案项目2.0mm环氧树脂地坪主材底 涂0.2/（环氧树脂固含量70%）环氧中涂1.0/（环氧树脂固含量95%）面 涂0.3/（环氧树脂固含量80%）主材合计1.5/2.0mm环氧树脂防静电地坪方案项目2.0mm环氧树脂防静电地坪主材底 涂0.2/（环氧树脂固含量70%）环氧中涂1.0/（环氧树脂固含量95%）面 涂0.3/（环氧树脂固含量80%）主材合计1.5/temporary construction organization design requires the implementation of the overall layout. 2 site near the high voltage line protection near power lines to have a reliable protective measures protective closely, to meet safety requirements. 3 branch set up distribution box into outlet sleeve and a cross arm to be used; Access to wires neatly, reasonable matching; Prohibited the use of insulation is poor, aging skin, broken wires, to prevent leakage; Should be fixed by insulators, and overhead laying; Line the hallway to have a reliable protection; Direct buried lines, laying depth of not less than 0.6m, leads to the ground from the 2m height to the ground at 0.2m, you must set up protective casing. 4 spot lights hand-held lamp 36V safe voltage should be used; 36V safety at hazardous voltages, particularly in hazardous areas using 12V; Lighting wires should be fixed on the insulators; Insulated rubber sheathed cable for field lights, lighting the use of sheathed wires; Lighting circuits and lighting from the ground not less than the prescribed distance, prohibited the use of electric arc furnace; To prevent the wire insulation is poor, aged, broken skin and leakage, with tungsten heating is strictly prohibited. 5 to set up low-voltage lines are not allowed to use bamboo poles, pole cross arm should be established and insulators; Fine wires can not be mounted on scaffolding or tree branch; Overhead lines required high enough off the ground. 6 electric . Project name: 5-5-2 sequential order of the subsidence observation observation point number support (supporting) and diagrams year month day year month day year month Day, the distance (m) deformation (mm) the relative distance (m) deformation (mm) the relative distance (m) deformation (mm) today this this this this cumulation Engineering formwork supporting system self-test State observer records form template project name: construction site: construction: support materials: Ann 5-6 serial number check project check requirements behave records results 1 construction programme programme full, support system design calculation, and approval procedures complete, job Qian should for security low-down, low-down material full 2 support material support column material: wood Rod application pine or FIR, shall not used easy deformation, and decay, and split crack, and dry section of wood; as used pipe, pipe od shall not is less than 48x3.5 of pipe, no serious rust, and crack, and deformation 3 column stable column bottom of pad material, Shall conform to the construction design requirement, do not use bricks blocked up by construction organization design requirements, support height () when m, between columns of the level of support set () road horizontal support, vertical scissors spacing (), m, spacing for horizontal scissors () m. Column spacing in accordance with design requirements, portrait () mm, transverse () mm pole joints should be staggered, long barch zazen, budov a konstrukc, tanky a jin zsuvky prmyslov vody, krom ustanoven vodu tak, by mlo bt instalovno v oblasti s vodou k utsnn vrtu, uzavrac ventil, aby se zabrnilo velk mnostv holavch a vbunch materil do kanalizace. 9. pouit v holavch, vbunch plyn pojistn ventil a vtrac potrub, je nutn export trubice je umstn mimo a vy ne 2 metry nad budovou. (B) pouvn ohn, ohe (viz systm sprvy prce) (c) porn zazen a organizac 1. realizace prevence prvn a integrovan prevence ohe politiku, pijmout modern technologie poru a vbuchu prevence a pomoci, provdn zen podle cl. 2. zzen veden spolenosti a vedouc jednotlivch oddlen Porn bezpenost vboru, workshop zaloena porn ochrany, vedouc skupiny a nastavit dobrovolnch hasi. 3. spolenost tvaru ochrany spotebitele na pln vazek hasii, hasii formulovat pln protiporn prevence a akn pln, provdn zen podle cl, pravideln proveden publicitu porn prevence a vzdlvn a kolen, v kombinaci s oekvan porn cvien. 4. soubor stacionrn ohn uvnit spolenosti zazen, protiporn zazen mus bt v Sprva slueb, rozvoj provozn postupy a systmy zen. 5. porn zazen na serveru nastavit jasn, pstup k pohodln a bezpen msto, pravideln kontroly drby, ti (to je, pevn, fixn typ a mnostv, podle odbornk), a nem nikdo nenapadal, pachatel dle systmu ke zpracovn. 6. vechny holav a vbun ltky ve spolenosti a potenciln ped porem a vbuchem nebezpen vroby, skladovn, prodej a pouvn procesu a jeho souvisejc vybaven, psn zen. 7. kdy je ohe, pole tby okamit uspodejte do boje s ohnm, a ohledn vroby, plnovn, alarmy a ohn a adresu urit sti ohn a pinastreamlining. Four are standard visits, except as required to participate in training, no other activity. Five is to improve news reporting, for propaganda work strictly according to the regulations. Six is strictly your presentation published strictly according to the regulations. Seven is strictly thrift, required the use of vehicles and office space and corporate hospitality. 3, change the style. Propaganda and ideological work of the new situation and new requirements of the new tasks, had done a lot of fruitful work, has made many achievements, but further closer to the grass roots, close to reality, close to the masses and also inadequate innovation must continue to improve. Second, the four winds some outstanding issues 1, oppose formalism. One theory is that he didnt, with less close contact. Theoretical study of consciousness is not high enough, system performance is not strong enough; more passive learning, active learning few generalities and learn more, delving into less. Especially based on rational thinking on major issues, applying theory to guide the work done is not good enough, not really understand and grasp the spirit and essence of the scientific Outlook on development, did not truly achieve mastery, to apply, to a certain extent, affe