鸡西730煤机电子图册机械图

1、 MG300/730-WD型交流电牵引采煤机图册鄂尔多斯中税煤矿24MJD鸡西煤矿机械有限公司分发号（产品合同号）： 发放时间： 年 月 日 变更图册：有 无 共77页 第68页整机主要参数表项 目内 容采高范围 m2.34.2装机功率 kW730截割功率 kW2×300牵引功率 kW2×50过煤高度mm600滚筒直径m2.0滚筒截深mm 660摇臂型式整体弯摇臂牵引力 kN680调速方式交流变频工作面倾角15°泵站功率 kW30机面高度 mm1478m 下切深度 mm460；360；260滚筒转速 r/min42；40；35；29摇臂摆动中心距mm7575摇臂长

2、度 mm2160牵引速度 m/min7.1；8.7牵引型式齿轮 销排供电电压 V1140配套输送机SGZ730/320整机布置式积木式组合整机重量 t 55MG300/730-WD型交流电牵引采煤机是采用多电机驱动、横向布置，装机功率大，采煤机截割部设计强度为300kW，电机容量调整范围为200300kW，通过调整截割电机容量，可实现一机多型。即MG200/530WD、MG250/630WD、MG300/730WD三种采煤机型，从而能够更好地适应不同工作面煤质变化要求。三种容量截割电机的联接尺寸完全相同。结构先进、运行可靠、可实现电液互换、爬坡能力强等特点，是目前国内中厚煤层综采工作面理想的首

3、选机型之一。主要适用于2.34.2m，煤质硬度f 4，煤层倾角40°的综采工作面，完成落煤与装煤作业。可在周围空气中的甲烷、煤尘、硫化氢、二氧化碳等不超过煤矿安全规程中所规定的安全含量的矿井中使用。产品型号及含义：M G 300 / 730 - W D 电牵引 无链牵引 总装机功率（kW） 单侧截割功率（kW） 滚筒式 采煤机 总装机功率730kW，截割功率为2×300kW，牵引功率为2×50kW，调高泵站功率为30kW。牵引型式为齿轮-齿轨式。操作控制点位置设置在机身中间，可直接操作按钮或手把，也可以采用两端操作站或遥控器离机遥控。随机所带图册为受控文件，具有唯

4、一的分发号（即合同号）、更改标识（是否含变更图册）及受控文件专用图章。图册详细描述了MG300/730-WD型交流电牵引采煤机的构成。随机所带图册可作为采煤机使用单位定购配件使用。因局部改进及配套变化，与本图册不同之处，附带产品变更图册。如封面说明含变更图册，订购配件则依据变更图册为准！封面无受控文件专用图章，仅做为学习文件及订购配件参考24MJC整机明细表序号图号图名数量单重总重序号图号图名数量单重总重124MJ34A左截割部19327.699327.69322020504001GB/T 6171-2000 螺母 M42×330.5981.794224MJ-8左操作站护罩159.8

5、459.843324MJ-5C弯丝杠169.569.5324MJ08-1压板40.2921.1683424MJ-13油缸铰轴压盖25.9811.9642071503004GB/T 70.1-2000 螺钉 M6×16120.0050.063510MJ-3A铰轴231.162.2524MJ21A行走部21453.852907.73614MJ13A支承组件（滑靴式）2154.795309.59624MJ-1C丝杠235703714MJ-6皮带盖板28.517710MJ-2定位销412.349.23810MJ-13压板22.635.26814MJ15拖缆装置1102102392011109

6、004GB/T 5783-2000 螺栓 M20×5060.1520.912924MJ02B左牵引部16710.646710.64402040503011GB/T 93-1987 垫圈 20100.0150.151024MJ02-2前盖板151.351.3412011109008GB/T 5783-2000 螺栓 M20×7020.2120.4241124MJ-3铰轴231.863.64210MJ0502B调高油缸2466.107932.214122011107003GB/T 5783-2000 螺栓 M12×25710.0251.7754315T4-2000&#

7、215;660采煤机螺旋滚筒222954590132040502007GB/T 93-1987 垫圈 12710.0040.284442011109002GB/T 5783-2000 螺栓 M20×4080.1210.9681424MJ-14牵引铰轴压盖23.587.164520MJ-53垫圈80.342.721524MJ07冷却喷雾系统172.882872.88284624MJ-2C丝杠166.166.11614MJ06-10螺栓 M36×3×150121.75214720MJ-54压板60.10.61724MJ06B机外油管组152.252.248201110

8、6002GB/T 5783-2000 螺栓 M10×16120.0130.1561824MJ03-3前盖板192.892.8492040502006GB/T 93-1987 垫圈 10120.0030.0361924MJ03B右牵引部19205.069205.065024MJ14护板焊接组件168.6968.692024MJ-12摇臂铰轴盖板45.4821.92512011110001GB/T 5783-2000 螺栓 M24×5090.2292.0612124MJ-9右操作站护罩191.2291.22522040503013GB/T 93-1987 垫圈 2490.021

9、0.1892224MJ35A右截割部19327.699327.695324MJ13护板焊接组件168.6968.692324MJ-3C轴275.51515411201080119高压软管 KJR32-172/2000082424MJ-4C轴254.37108.7455251991603005液压螺母 M42×352.21156262040504015GB/T 93-1987 垫圈 36340.0521.768572724MJ-7C螺栓M36×3×205222.3451.48582814MJ-2方螺母220.6614.52592924MJ01B电控部18550855

10、0603024MJA-3铭牌11.41.4613124MJA-3A铭牌11.41.46224MJ01B电控部总图明细表序号图 号图 名数量单重总重序号图 号图 名数量单重总重124MJ0101B电控箱壳体15884.465884.46302071505007GB/T 70.1-2000 螺钉 M10×4080.0320.256224MJ0105牵引变压器腔前盖165.8865.883124MJ01-4压块120.232.7634MJA19-2护板20.170.3432104020101004接触器 CKJ5-400/1.14 AC36V311.534.544MJA19-3护板10.1

11、50.15332071506003GB/T 70.1-2000 螺钉 M12×3050.0390.1955104030700003变频器键盘 TX312R100342040902008GB/T 97.2-2002 垫圈 12120.0050.066104020600001GJC4 甲烷传感器(配接甲烷传感器电源模块)1113524MJ0116隔离开关支架119.4119.41724MJ0104开关腔前盖181.6681.663626MJ08-22A瓦斯传感器压板20.1850.3782071503011GB/T 70.1-2000 螺钉 M6×5040.0130.05237

12、2071503002GB/T 70.1-2000 螺钉 M6×1240.0050.0292040501004GB/T 93-1987 垫圈 662003824MJ01-11压条20.0180.0361014MJ30-8垫板10.4350.435392070704002GB/T 67-2000 螺钉 M3×5400112071505005GB/T 70.1-2000 螺钉 M10×30520.0271.404402040501001GB/T 93-1987 垫圈 33000122040502006GB/T 93-1987 垫圈 10960.0020.19241204

13、0901002GB/T 97.2-2002 垫圈 33000132040902007GB/T 97.2-2002 垫圈 10320.0040.128422071502003GB/T 70.1-2000 螺钉 M5×1260.0030.018142071504010GB/T 70.1-2000 螺钉 M8×5040.0240.096432040501003GB/T 93-1987 垫圈 51800152040501005GB/T 93-1987 垫圈 81040.0020.20844104020201022变压器 ZQSG-160/1.14/0.38-730158058016

14、24MJ0103A显示盖板161.20961.209452011108003GB/T 5783-2000 螺栓 M16×3530.0640.192172011107021GB/T 5783-2000 螺栓 M12×302900.038.7462100500011GB/T 1972-2005 碟形弹簧 A31.560.010.06182040502007GB/T 93-1987 垫圈 123040.0041.2164724MJ0110B左上盖板165.98865.9881924MJ0114支架组件19.759.754824MJ0109B右上盖板154.38854.388201

15、04030200002变送器 TXBS-7301664924MJ01-7支板40.291.162124MJ0102操作盖181.281.2502071505004GB/T 70.1-2000 螺钉 M10×2540.0250.122104030100013主控器 TXZK-730113.513.55112MJ0129-11尼龙套管240.24.8232071505003GB/T 70.1-2000 螺钉 M10×20200.0220.44522070704009GB/T 67-2000 螺钉 M3×25300.0010.03241060103201GB 1235-

16、1976 O形密封绳 5.7210000053104020801001插接件 CA-20JW/KA2002524MJ0115主控器支架17.197.1954104020801002插接件 CA-14JW/KA126104030300016变频器 TXBP-S4-04-730(一拖一四象限用)2326455104020600025甲烷传感器电源模块DXJ-24/1210.60.627104030300043变频器 TXBP-S2-04-730(一拖一两象限用)23264562071502006GB/T 70.1-2000 螺钉 M5×2040.0040.0162810403030001

17、6变频器 TXBP-D4-04-730(一拖二四象限用)1323257104020304007空气开关 DZ47-60/C10 230/400V429104030300015变频器 TXBP-D2-04-730(一拖二两象限用)1323258104020304005空气开关 DZ47-60/C5 230/400V124MJ01B电控部总图明细表序号图 号图 名数量单重总重序号图 号图 名数量单重总重59104040400002整流桥 20A/600V2882020308003GB/T 6170-2000 螺母 M8120.0050.0660104030100029主控继电器板 ZKJDB189

18、24MJ0108牵引变压器腔上盖171.3271.326124MJ0106主控腔上盖263.82127.649024MJ01-1小盖板113.113.1622071504004GB/T 70.1-2000 螺钉 M8×2080.0130.1049124MJ0112接线腔左盖板164.3664.36632040901006GB/T 97.2-2002 垫圈 8160.0020.0329222MJ0807主接线柱120.51936.23166410MJ68-44绝缘管200.00190.038932070904003GB/T 65-2000 螺钉 M8×16360.0090.3

19、24652070705008GB/T 67-2000 螺钉 M4×25200.0020.04944MJ08-35接地标志70.0160.112662040501002GB/T 93-1987 垫圈 42000954MJ0815B主接线柱313672040901003GB/T 97.2-2002 垫圈 42000964MJ0816七芯接线柱140.431146.035966824MJ01-6底板14.254.259724MJ0111接线腔右盖板170.5570.5569104020500020互感器 CS30 300Aac/5Vdc29810MJ68-24胶垫30.0160.04870

20、104020500019互感器 CS30 200Aac/5Vdc29914MJ30-17接线弯头34.36313.089712070706006GB/T 67-2000 螺钉 M5×2080.0030.02410010MJ68-18密封圈21.4212.842722040901004GB/T 97.2-2002 垫圈 5120010110MJ68-19垫圈30.0660.1987324MJ01-3接触器座板35.6316.8910210MJ68-20堵板30.13680.41047424MJ0113支架18810310MJ68-21压板31.4814.4437510402020202

21、8变压器 GX-0.5/1.14/36V/25V/24V-73016.56.510410MJ68-22压片30.03780.113476104020202004变压器 GKB-0.3/1.14/32V/20V/27V/15V1441052071505009GB/T 70.1-2000 螺钉 M10×50140.0390.546772070607006GB/T 68-2000 螺钉 M6×25120.0050.061062071505006GB/T 70.1-2000 螺钉 M10×35140.030.42782020306003GB/T 6170-2000 螺母

22、M6120.0020.02410714MJ30-26密封圈179104020301001隔离开关 GM2-400/1140V10010814MJ30-16接线弯头14.984.9880104020301002隔离开关 GM3-250/1140V110910MJ08-42胶垫10.0220.0228114MJ30-4隔离开关座板15.015.0111010MJ08-19接线弯头13.783.78822011107020GB/T 5783-2000 螺栓 M12×25150.0250.37511114MJ60-3密封圈10.680.6883104030900028电抗器电容器组TX-S4

23、-04LC一拖一四象限用211210MJ08-17垫圈10.00510.005184104030900029电抗器电容器组TX-D4-04LC一拖二四象限用111310MJ08-16堵板10.030.038524MJ0107开关腔上盖185.2285.2211410MJ08-18压板10.560.5686104020703002熔断器 RT0-200A/150A611510MJ08-39压板10.0750.075872070608006GB/T 68-2000 螺钉 M8×30120.0120.1441162071504005GB/T 70.1-2000 螺钉 M8×254

24、20.0150.6324MJ01B电控部总图明细表序号图 号图 名数量单重总重11710MJ68-11接线弯头24.8449.68811810MJ68-12密封圈30.4891.46711910MJ68-14垫圈30.09560.286812010MJ68-13堵板30.20780.623412110MJ68-15压板31.424.2612210MJ68-16压片30.0430.12912310MJ68-23胶垫30.020.061244MJ08-24垫圈440.0110.4841254MJ08-23A密封圈180.0160.2881264MJ08-22堵板220.0270.594127207

25、1504008GB/T 70.1-2000 螺钉 M8×40440.020.881282071503004GB/T 70.1-2000 螺钉 M6×16440.0050.221294MJ08-21压板220.0110.2421304MJ08-20喇叭口220.46810.29613122MJ08-41密封圈40.0220.08813224MJ0188电气系统框图124MJ02B左牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202001液压用液位液温计 YWZ-80T100301060103201GB 1235-1976 O形密封绳 5.712600

26、022011108006GB/T 5783-2000 螺栓 M16×5040.0920.3683114MJ0206盖板117.5917.5932040502009GB/T 93-1987 垫圈 16160.0070.112321990701020液压排气阀 QLY-10×0.63141110300006接头座 JKU-1910.2710.2713314MJ0204A盖板139.0539.0551110200006堵 JKD-1910.1170.1173414MJ02-4小盖板19.49.461110100006U形销 UK-1910.0220.022352071508003

27、GB/T 70.1-2000 螺钉 M16×35120.0841.00871060110011JB982-1977 垫圈 3013681060102017GB 1235-1976 O形密封圈 24×2.410037914MJ02-7A套25.2410.48381024MJ0201B左牵引部机壳15380538039111060102035GB 1235-1976 O形密封圈 80×3.1100122071506002GB/T 70.1-2000 螺钉 M12×25160.0350.56132040502007GB/T 93-1987 垫圈 12520.0

28、040.2081410MJ01-11压盖10.370.371510MJ01-10堵11.021.021624MJ02-1后盖板14646171110300005接头座 JKU-1630.2280.684181110100005U形销 UK-1630.0180.054191060110010JB982-1977 垫圈 2732010MJ0102二轴154.421154.42112110MJ01-12小压板10.1340.1342210MJ0101一轴147.24747.247232071506003GB/T 70.1-2000 螺钉 M12×30360.0391.404241.0402

29、1E+11一体化温度变送器 GW2001251060110007JB982-1977 垫圈 2012614MJ02-6A套23.286.562714MJ0201行星减速器1632.609632.6092814MJ0202惰轮轴组件132.132332.1323291030101012电动机 YBQYS3-50142042014MJ0201行星减速器明细表序号图 号图 名数量单重总重序号图 号图 名数量单重总重110MJ0103-3座142.8542.8530MEK0212-9行星轮46.9727.88214MJ0201-3行星架146.8846.88312050417001Q/JM 114.2

30、-2006 销子 25×5030.1460.438310MJ0103-2齿轮152.252.232MEK0212-12外套40.0660.26442050416002Q/JM 114.2-2006 销子 20×4520.0870.17433MEK0212-13行星架18585510MJ0103-1联接盘115.615.63414MJ0201-1盖174.874.862031008073GB/T 894.1-1986 挡圈 18010.1420.14235MEK0212-14心轴43.112.4714MJ0201-5垫10.040.04361011605018SKF 滚动轴承

31、 16044/220×340×3710082030307051GB/T 893.1-1986 挡圈 9010.0250.02537MEK0212-16小盖119.519.5914MJ0201-6垫10.140.1438MEK0212-17套13.43.41014MJ0201-2太阳轮14.864.863914MJ0201-4大太阳轮110.410.4111010617008GB/T 276-1994 滚动轴承 6193625.0410.08401060102031GB 1235-1976 O形密封圈 65×3.11001210MJ0103-21套10.070.07

32、41MEK0212-3限位垫10.050.051310MJ0103-20挡圈10.190.1942MEK0212-2塞10.040.04142071508002GB/T 70.1-2000 螺钉 M16×3080.0770.616432031007045GB/T 894.1-1986 挡圈 6510.0180.018152040502009GB/T 93-1987 垫圈 16200.0070.14441060102105GB 1235-1976 O形密封圈 205×5.7100162071506003GB/T 70.1-2000 螺钉 M12×30280.0391

33、.092451060108127GB/T 9877.1-1988 密封圈 BD220×250×15100172040502007GB/T 93-1987 垫圈 12280.0040.11246MEK0212-18调整垫片50.0240.121814MJ0201-7套30.020.06471060102149GB 1235-1976 O形密封圈 370×8.61001914MJ0201-8行星轮36.73520.205481060102159GB 1235-1976 O形密封圈 500×8.6100202030307059GB/T 893.1-1986 挡

34、圈 11030.0480.14449MEK0212-19O形圈525x8.610.0020.0022114MJ0201-9内齿圈147.56947.569502030308062GB/T 893.1-1986 挡圈 12040.0570.228221010201008GB/T 288-1994 滚动轴承 22212C61.227.32511010201051GB/T 288-1994 滚动轴承 22311C82.3518.82314MJ0201-10轴32.537.59242030307043GB/T 893.1-1986 挡圈 7030.0160.0482514MJ0201-11联接盘153

35、.8353.832614MJ0201-13环10.140.14271010616010GB/T 276-1994 滚动轴承 6192811.91.92814MJ0201-12齿圈165.3465.3429MEK0212-11内套40.0850.3424MJ03B右牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202003液压用液位液温计 YWZ-150T1003110MJ0102二轴154.421154.4211215MJ0201控制阀组168.496668.49663214MJ0202惰轮轴组件132.132332.132332040502009GB/T 93-198

36、7 垫圈 16330.0080.264331060102035GB 1235-1976 O形密封圈 80×3.1142071508009GB/T 70.1-2000 螺钉 M16×65100.131.33410MJ01-11压盖10.370.37524MJ03-4滑轨26.5133510MJ01-10堵11.021.0261110100006U形销 UK-1910.0220.0223614MJ02-7A套25.2410.4871110300006接头座 JKU-1910.2710.2713714MJ02-6A套23.286.5681110200006堵 JKD-1910.1

37、170.1173814MJ0201行星减速器1632.609632.60991060102017GB 1235-1976 O形密封圈 24×2.413922MJ01-19联接盘118.518.5101060110011JB982-1977 垫圈 3014022MJ01-18花键轴10.580.581124MJ0304压力表组19.39.34122MJ01-18A花键轴10.580.58122011108003GB/T 5783-2000 螺栓 M16×3530.0640.192421990100001三联齿轮泵 PGP511B0190/0190/00401132011108

38、005GB/T 5783-2000 螺栓 M16×4540.0830.332431990100062三联齿轮泵 BMK3-200451141030101012电动机 YBQYS3-501420420441990100037三联齿轮泵 CBK1020/20/4-452R112.212.2151990202001液压用液位液温计 YWZ-80T1452040502006GB/T 93-1987 垫圈 1060.0020.0121624MJ0301B右牵引部机壳173007300462071505004GB/T 70.1-2000 螺钉 M10×2560.0250.1517103

39、0302004电动机 YBRB-30（D）1348.5348.5472100104006Q/JM 864-2001 内六角螺塞 M20×1.510.0380.038182071508006GB/T 70.1-2000 螺钉 M16×5040.1060.4244814MJ02-4小盖板19.49.4192071506003GB/T 70.1-2000 螺钉 M12×30580.0392.2624914MJ0204A盖板139.0539.05202040502007GB/T 93-1987 垫圈 12860.0040.344501990701020液压排气阀 QLY-

40、10×0.6320.20.42124MJ03-1后盖板167.867.85114MJ0206盖板117.5917.59221.04021E+11一体化温度变送器 GW2001521060103201GB 1235-1976 O形密封绳 5.71260231060110007JB982-1977 垫圈 202531060103201GB 1235-1976 O形密封绳 5.713002410MJ0101一轴147.24747.2475424MJ03-2油箱盖板125.225.22510MJ01-12小压板10.1340.134552071506001GB/T 70.1-2000 螺钉

41、M12×20120.0320.384262071506002GB/T 70.1-2000 螺钉 M12×25160.0350.56562100104012Q/JM 864-2001 内六角螺塞 M33×210.110.112724MJ02-1后盖板14646572100201016Q/JM 861-2001 垫圈 3310.0060.006281110100005U形销 UK-1630.0180.054582071508003GB/T 70.1-2000 螺钉 M16×35120.0841.008291110300005接头座 JKU-1630.2280.6845924MJ0601过滤器123.