海瑞克盾构设备

1、CYLINDER 油缸DIV.SPARE PARTS SEGMENTFEEDER待定管片喂送器备件SEGMENTCRANE管片吊机GEAR MOTOR 齿轮马达DRIVE MOTOR驱动马达SPARE PART PACK SEGMENT CRANE管片吊机备件包DIV.SPARE PARTS 待定备件DIV.SPARE PARTS ERECTORPULT待定拼装机备件拼装机控制面板SCREW TENSION CYLINDER M42M42螺栓拉伸油缸SCREW TIGHTENING DEVICE M60M60螺栓上进装置HIGH PRESSURE POWER PACK 高压动力包 HIGH-P

2、RESSUREHOSE高压油管 HIGH PRESSURE HOSE 1600Bar高压油缸HIGH POWER AGGREGATE G20G20高压泵站HIGH PRESSURE HOSE高压油管INSERT FOR SCREW DRIVER SW 65SW65套筒INSERT FOR SCREW DRIVER SW 55SW55套筒POWER SCREW DRIVER HYDRAULIC液压动力扳手DISPLACEMENT CYLINDER +AGGREGAT移位油缸+液压泵站TOOL BOX工具箱CABLESHEARS电缆剪SCREWDRIVER螺丝刀SOCKETWRENCHSET 12

3、K12K套筒扳手装置DRILLINGMACHINE钻机GAS SOLDERINGIRON SET气体烙铁TIN 锡罐KALIBRATIONDEVICE校准装置MULTIMETER万用表PLIERS 钳子TORCH 手电筒 TOC o 1-5 h z TWIST DRILL螺旋钻INDICATION指示器FAN 风扇TORQUE WRENCH扭矩扳手COAL DRILL煤钻GRINDER 电砂轮Segment data:管片参数：Outside diameter: 15,000mm外径:15,000mmInside diameter 13,700mm内径：13,700mmLength 2,000

4、mm宽度：2,000mmRing distribution: 9+1管片分布：9+1MIX shield with back-up system 混合 式盾构机及后配套系统Shield body 盾体segmental steel structure (front and rear shields)钢结构块(前盾和后盾)pressure wall 压力壁submerged wall (air bubble chamber) 分隔板(气泡调压舱)pressure sensors土压传感器Access door in the pressure wall 压力 舱壁中的进入门Access door

5、in the submerged wall 分 隔板中的进入门flange manlock 人闸法兰 lange for material lock 材料闸法兰 main drive support主驱动支架agitators ? 1,900mm 搅拌器？1,900mmfront gate 前闸门 protection grid保护隔条Flushing circuit in the excavation chamber 开挖舱内的冲洗回路19 x triple thrust cylinders 19 x 3 个推 进油缸Injection points 2” for shield lubric

6、ation2”盾体润滑注入点Tailskin 盾尾sandwich type steel structure 夹层“三明治”式钢结构rows of wire brush seal 排密封钢丝 刷emergency seal system紧急密封系统injection pipes for tailskin grease per grease chamber每个油脂舱盾尾注脂管single grout injection channels for mortar 单液砂浆注入管道Grout and grease pipes are integrated in the tailskin steel s

7、tructure 注浆管和注 脂管集成在盾尾钢结构里Cutting wheel 刀盘spokes star design星形轮辐设计centre cone to connect the cutting wheel the main drive unit中心锥用于连接刀盘和主驱动单元with man access to change the tools from within the arms 有人员通道，可以从 刀盘臂内进入进行换刀First dress of cutting tools including exchangeable cutting tools, standard cuttin

8、g tools and standard bucket lips, 初装刀，包括可更换刀具、标准切刀和标准 铲刀copy cutter,仿型刀Center flushing circuit equipment中心冲刷设备rotary unit DN150mm for bentonite 膨 润土旋转单元DN150mmstandard scrapers equipped with wear detection equipment 标准舌U刀，带磨损 监测装置bucket lips equipped with wear detection equipment 铲刀，带磨损监测装置Main driv

9、e including main bearing ? 8m and lubrication system 主驱动，包括主 轴承？ 8m和润滑系统Inner and outer sealing system内夕卜密封系统Main bearing ? 8,000mm 主轴承？ 8,000mmElectric motor 250kW with safe set 电 机250kW，带安全单元Planetary gear box行星齿轮箱Frequency drive units 变频驱动单元Installed power 3,500kW 安装功率3,500kWSegment erector管片安装机E

10、rector beam 安装机梁Base frame 基架Rotation frame with telescope 伸缩旋 转架Traverse with erector head横梁及安装机头Lift for ring building管片安装升降系统Erector bearing 安装机轴承 remote control (radio)遥控设备(无线和线控)auxiliary crane for installation of the auxiliary invert segment 辅助吊机，用 于安装辅助仰拱块counter weight 平衡块Vacuum gripping dev

11、ice incl. vacuum pump 真空抓取系统，包括真空泵 Man lock incl. each人闸，每个包括Steelwork 钢架Double chamber两个舱体According to DIN EN 12110 依据 DIN EN 12110Pipes and installations 管道和安装设 施air lock is equipped with flange 空气 闸，有法兰盘Material lock incl. each 材料闸，每个包 括Steelwork 钢架Single chamber 单舱体According to DIN EN 12110 依据 D

12、IN EN 12110Pipes and installations 管道和安装设 施Hydraulic system 液压系统Thrust cylinder hydraulic 推进油缸液 压系统Grout pumps hydraulic砂浆泵液压系统Erector hydraulic 管片安装机液压系统Erector auxiliary hydraulic 管片安装 机辅助液压系统Copy cutter hydraulic 仿型刀液压系 统Auxiliary hydraulic (front gate, bento nite nozzles,) 辅助液压系统(前闸 门、膨润土喷嘴、.)Fi

13、lter and cooling circuit 过滤器和冷却 回路Electrical equipment电气设备Transformers变压器Main and sub distribution 主、副配 电柜Lighting and emergency lighting with ba ttery照明及应急照明系统，备电池Control voltage system电压控制系统Control cabin with air conditioning devic e控制室，带空调设备Earth leakage relay units接地泄漏继电器Medium voltage switch un

14、its 中压开 关单元Compensation units 补偿单元Electrical equipment (continue) 电气设 备(续)Emergency stops 紧急停止开关PLC configuration S7 incl. USV batter y PLC系统S7，包括USV电池 HV cable drum incl. 200m HV cable 高压电缆卷筒，包括200m高压电缆earth cable box 接地电缆盒 communication cable drum incl. 200m o f communication cable通讯电缆卷筒，包括200m通讯电

15、缆Secondary ventilation system二次通风系统booster fan 鼓风扇silencers消声器air duct cassette w/o air duct风管盒,不含风管handling device for air duct cassette风管盒操作设备Back-up gantries and installation: 后 配套拖车及装备：gantry 1 running on auxiliary rails 1 号拖车，行走于辅助轨道bridge section 连接桥部分gantry 2 running on auxiliary rails 2 号拖车，

16、行走于辅助轨道segment feeder running on auxiliary inv ert segment 喂片机，行走于辅助仰拱块 上turning table 转板segment crane 1 管片吊机 1segment crane 2 管片吊机 2 road element crane 箱涵吊机set of cranes to handle the auxiliary raiIs/ consoles套吊机设备，用于操作辅助轨道/托架Place reservation for the air lock shuttl e transport预留空气闸穿梭运输的空间grease p

17、ump station油脂泵站grease pump for main drive 主驱动油 脂泵grease pump for labyrinth (HBW) 迷 宫环油脂泵(HBW)control cabin with air conditioning 控 制室，带空调设备Communication system (10 telephone s) 通讯系统(10部电话机)CCTV system incl. 4 cameras CCTV 系统，包含4个摄像机diesel generator 柴油发电机 fire fighting equipment灭火设备gas detection equi

18、pment气体检测设备storage area with shelves 存储区域， 含架子storage area for the tunnel pipes 隧 道内管子存储区域workshop area with work bench (w/o to ols) 工作台(不含工具)操作区域 recreation room with air conditionin g 休息室，带空调engineer room with air conditioning 工程师办公室，带空调Infirmary & toilet with washing facilities医务及盥洗室，有清洗设施Auxilia

19、ry rails incl. consoles and the i nvert segment are to be provided by th e Buyer. 辅助轨道(包括托架，仰拱块) 由买方提供Data acquisition system 数据采集系统 industrial PC (located at the surface) wi th modem 工业计算机(在地面上)，带 调制解调器Screen and messages in Chinese andEnglish languages显示屏及中英文信息Software (windows, excel, PC anywhere

20、, word) in English英文软件(windows,excel, PC anywhere, word)Modem to connect to the surface (with out telephone cable) 连接到地面的调 制解调器(不含电话线)Telephone cable drum电话电缆卷鼓Guidance system (SLS-T APD) 导向 系统(SLS-T APD) laser station 激光站ELS target ELS 电子靶industrial PC (located on the machine) 工业计算机(在机器上)software i

21、n English英文软件data acquisition unit数据采集单元Pre-calculation of the ring sequence管片序列预计算Tailskin measurement system 盾尾测量系统Slurry circuit on the TBM TBM 上的泥 水回路Output 3,000m3/h 输出 3,000m3/hset of slurry pipes on the TBM ? 500mm 套TBM上的泥水管？ 500mm density measurement system密度测量系统1 set of valves DN 500mm1 套阀，

22、DN 500mmby pass in shield旁通站，在盾体上flow meter devices 流量表booster pump for center flushing 中 心冲刷增压泵discharge pump 300 SHG type 排泥 泵，型号300 SHGslurry pipes extension system (hose loop)泥水管延伸系统(胶管回路)Slurry circuit in the tunnel 隧道内的泥 水回路Output discharge line : 3,000m3/h 排 泥管输出：3,000m3/hOutput feed line : 2,700m3/h 进泥管 输出：2,700m3/h200m of discharge and feed pipes ? 6 00mm 200m排泥管和进泥管？ 600mmdensity measurement system 密度测 量装置by pass in shaft 竖井内的旁通 pressure sensors installed on the disch arge line incl. communication cable 压力传感器，安装在排泥管上，