废旧钢铁综合循环利用项目环境影响报告表

—/r/n/r/n1/r/n—/r/n(/r/n污染影响类)/r/n废旧钢铁综合循环利用项目/r/n/r/n建设/r/n单/r/n位(盖章)：/r/n山东多阳再生资源有限公司/r/n/r/n/r/n—/r/n/r/n2/r/n—/r/n/r/n铁综合循环利用项目/r/n220/r/n8-370812-04-01-952349/r/n/r/n /r/n庄工业园区/r/n标/r/n9/r/n秒，北纬/r/n35/r/n度/r/n31/r/n分/r/n9.296/r/n秒)/r/n/r/nC/r/n金属废料和碎屑加/r/n/r/n加工处理/r/n421/r/n团/r/n/r/n新建(迁建)/r/n改/r/n建/r/n扩/r/n建/r/n技/r/n术改造/r/n不予/r/n批准后再次申报项目/r/n超/r/n五年重新/r/n/r/n重/r/n大变动重新报批项目/r/n项目审批/r/n/r/n /r/n核准/r/n//r/n备案)部/r/n/r/n服务局/r/n项目审批(核准/r/n//r/n/r/n备/r/n案/r/n)文号(选填)/r/n220/r/n8-370812-04-01-952349/r/n/r/n(万元)/r/n环保投资(万元/r/n)/r/n环保投/r/n资/r/n/r/n占比(/r/n%/r/n)/r/n工期/r/n2/r/n/r/n个月/r/n/r/n否/r/n用/r/n地(用海)/r/n/r/n面/r/n积(/r/nm/r/n2/r/n)/r/n根据《建设项目环境影响报告表编制技术指南(污染影响类)》(试行)：/r/n/r/n要设置地表水专项评价。/r/n厂区风险物质均未超过临界量，不需要设置环境风险专项评价。/r/n/r/n/r/n洋排放污染物的海洋工程建设项目。/r/n况/r/n《济宁市城市/r/n总体规划(/r/n2014-2030/r/n年)》/r/n兖州部分/r/n—/r/n/r/n3/r/n—/r/n况/r/n无/r/n析/r/n无/r/n析/r/n本项目为废旧钢铁综合循环利用项目，根据国家发展和改革委/r/n员会《产业结构调整指/r/n/r/n/r/n49)/r/n。因此，本项目的建设符合国家产业政策。/r/n(/r/n1/r/n)项目用地符合性分析/r/n项目位于山东省济宁市兖州区兴隆庄街道工业园。根/r/n据济宁市兖州区国土规划局出具/r/n的《关于兖土/r/n201/r/n7-47/r/n号地块出具行业准入条件的函》，本项目所在地属于工业用地。项/r/n目与济宁市城市总体规划关系图：见附图/r/n8/r/n。符合兖州区兴隆/r/n庄街道产业发展规划，选址/r/n(/r/n2/r/n)土地使用的合法性分析/r/n/r/n项目用地属于工业用地(镇街道证明见附件/r/n4/r/n)，根/r/n据《限制用地项目目录》(/r/n2012/r/n年本)/r/n/r/n和《禁止用地项目目录》(/r/n2012/r/n年本)，本项目的建设不属于限制用地和禁止用地范/r/n围/r/n，/r/n限/r/n制/r/n用/r/n地项目目录(/r/n2012/r/n年本)》和《禁止用地项目目录(/r/n2012/r/n年本)》的通知/r/n”/r/n中规定，/r/n/r/n项目不属于《禁止目录》和《限制目录》中的建设项目，不属于/r/n该文件中限批或禁批的范/r/n—/r/n/r/n4/r/n—/r/n评/r/n[/r/n2016]150/r/n号)的符合性分析见如下内容。/r/n/r/n区，见下表。/r/n表/r/n/r/n1-1/r/n/r/n兖州/r/n区生态保护红线区一览表/r/n红/r/n描述/r/n涵养生态保/r/nJN/r/n-/r/nB/r/n1-/r/n03/r/n/r/n维护/r/n/r/n/r/n/r/nJN/r/n-/r/nB/r/n1-/r/n02/r/n源地外围井的外接多/r/n边形，向外径向距离为/r/n/r/n180m/r/n的多/r/n多边形，向外径向距离为/r/n/r/n/r/n/r/n/r/n离为/r/n80m/r/n的多边形区/r/n为半径向外径/r/n向距离为/r/n30m/r/n的圆/r/n以水源地外围井多/r/n/r/n/r/n维护/r/n该/r/n项目位于山东省济宁市兖州区兴隆庄街道工业园，具体地理位置为/r/n116/r/n度/r/n51/r/n分/r/n/r/n。/r/n/r/n/r/n管控，其中优先保护单元主要涵盖生态保/r/n护红线、一般生态空间和饮用水水源保护区等/r/n生态功能重要区、生态环境敏感区。区域/r/n以绿色发展为导向，严守生态保护红线，在南/r/n湖等各类自然保护地、河湖岸线利用管理规划保护区等严格执行有关管理要求。/r/n控单元，/r/n。/r/n—/r/n/r/n5/r/n—/r/n(一)/r/n/r/n“/r/n三线/r/n”/r/n：生态保护红线、环境质/r/n量/r/n/r/n底线、/r/n资源利用上限/r/n/r/n殊重/r/n要/r/n生态功能必须实行强制性严格保护/r/n/r/n的区/r/n域/r/n。相关规划环评应将生态空间管控/r/n/r/n作为/r/n重/r/n要内容，规划区域涉及生态保护红/r/n/r/n线的/r/n，/r/n在规划环评结论和审查意见中应落/r/n/r/n/r/n策措/r/n施/r/n。除受自然条件限制、确实无法避/r/n/r/n让的/r/n铁/r/n路、公路、航道、防洪、管道、干/r/n/r/n/r/n在生/r/n态/r/n保护红线范围内，严控各类开发建/r/n/r/n不予审批新建工业项目和矿/r/n于山东省济宁市兖/r/n/r/n态保护红线区兴隆/r/n/r/n/r/n2/r/n、环境质量底线是国家和地方设置的大/r/n/r/n气、/r/n水和土壤环境质量目标，也是改善环/r/n/r/n境质量的基准线。有关规划环评应落实区/r/n/r/n区域或者/r/n行业污染物排放总量管控建议以及优化区/r/n/r/n域或行业发展布局、结构和规模的对策措/r/n/r/n施。项目/r/n环评应对照区域环境质量目标，/r/n/r/n深/r/n入分析预测项目建设对环境质量的影/r/n/r/n响，强化污染防治措施和污染物排放控制/r/n/r/n本项目所在区域环境空气为不/r/n达/r/n/r/n/r/n经/r/n15m/r/n高排/r/n/r/n/r/n /r/n/r/n污水经化粪池处理后外运周边农/r/n/r/n/r/n水环境影响较小。项目建设过程/r/n/r/n/r/n/r/n项目建成后对周围环境质量的影/r/n/r/n/r/n源、水、土地等资源消耗不得突破/r/n源资/r/n发等量或减量替代、开采方式和规模/r/n、利用效率和保护措施等方面提出建/r/n/r/n/r/n(/r/n二)/r/n“/r/n一单/r/n”/r/n：环境准入负面清单/r/n环/r/n境/r/n准入负面清单是基于生态保护红线、/r/n/r/n环境质量底线和资源利用上线，以清单方/r/n/r/n式列出的禁止、限制等差别化环境准入条/r/n/r/n件和要求。要在规划环评清单式管理试点/r/n/r/n的/r/n基/r/n础上，从布局选址、资源利用效率、/r/n/r/n环境准入/r/n负面清单，充分发挥负面清单对产业发展/r/n/r/n目准入的指导和约束作用。/r/n/r/n/r/n/r/n/r/n有效的/r/n“/r/n三废/r/n”/r/n治理措施，/r/n能够确/r/n/r/n/r/n—/r/n/r/n6/r/n—/r/n通过上表对照，项目的建设符合环境保护部《关于以改善环/r/n境质量为核心加强环境影/r/n响评价管理的通知/r/n》/r/n(环评/r/n[2016]150/r/n号)要求。/r/n表/r/n/r/n1-3/r/n/r/n项目与兖州区环境/r/n管控单元生态环境准入清单符合性分析一览表/r/n控/r/n控/r/n/r/n性/r/nZH/r/n370/r/n81/r/n20004/r/n/r/n/r/n./r/n大气环境受体敏感重点管控区内加/r/n境布局敏感重点管控区内布/r/n论证区域环境影响。/r/n于山东省济/r/n集由旋风除尘/r/n+/r/n除尘器处理/r/n/r/n小。/r/n/r/n/r/n/r/n/r/n在生态保护/r/n空间原则上按限制开发区/r/n/r/n/r/n/r/n垃圾，应在具备集中处/r/n理条件的港口/r/n染物直接排入河流或湖/r/n/r/n3./r/n重要湿地保护区污染物排放管控/r/n执/r/n/r/n准》/r/n(/r/nDB/r/n37/2376-2019/r/n)排放要求/r/n。全面加/r/n、治理/r/n和去除率达到国家和/r/n控制。加强移动源污染防治，逐/r/n/r/n点行业，/r/n粒物废/r/n气罩收集由旋/r/n+/r/n脉冲袋式除尘/r/n池处理/r/n边农田堆肥/r/n/r/n湿地保/r/n—/r/n/r/n7/r/n—/r/n/r/n/r/n强化城镇生活污染防治，采取有效/r/n/r/n/r/n/r/n/r/n措施/r/n。/r/n污染天气应急/r/n/r/n/r/n./r/n新建高耗能项目能耗要达到相关要/r/n/r/n/r/n/r/n高耗能项/r/n/r/n4/r/n、与/r/n《/r/n山东省深入打好蓝天保卫战行动计划》(/r/n2021-2025/r/n年)符合性分析。/r/n落后产能/r/n炭、/r/n/r/n/r/n本项目不属于/r/n/r/n8/r/n个/r/n/r/n重/r/n点行业，不属于/r/n/r/n“/r/n散乱污/r/n”/r/n、重污染/r/n/r/n企业/r/n消费量/r/n/r/n大集中供热范围，因地制宜推行气代煤、电代煤/r/n、热/r/n/r/n项目生产不用热；/r/n/r/n源污染管控/r/n加强国六重型柴油货车环保达标监管。落实/r/n新生产重/r/n/r/n严禁生产、进口、销售和注册登记不符合/r/n国家第六阶/r/n准要求的重型柴油车。/r/n本/r/n项目不涉及移动/r/n源/r/n严格扬尘污染管控/r/n加强施工扬尘精细化管控，建立并动态更新/r/n施工工地/r/n清单。全面推行绿色施工，将扬尘污染防治/r/n费用纳入/r/n/r/n施工工地严格执行/r/n“/r/n六项措施/r/n”/r/n。/r/n本/r/n项目施工期仅安/r/n/r/n装/r/n设备，扬尘产生/r/n/r/n量/r/n较少，且采用洒/r/n/r/n施降尘/r/n综上所述，本项目不属于新增钢铁、焦化、电解铝、铸造、/r/n水泥和平板玻璃等产能项/r/n求。/r/n—/r/n/r/n8/r/n—/r/n表/r/n1-5/r/n/r/n/r/n“/r/n四减四增/r/n”/r/n方案的符合性/r/n“/r/n四减四增”三年行动方案(2021-2023/r/n/r/n情况/r/n/r/n/r/n/r/n/r/n、/r/n/r/n/r/n效落后产/r/n/r/n置一起/r/n”/r/n的原则，实施分类整/r/n治。(/r/n省生态环境厅、省工业和信息化厅/r/n/r/n按/r/n职责分工负责)各市要制定实施方案，/r/n/r/n/r/n/r/n/r/n后产能退出。/r/n汰落后/r/n/r/n/r/n必须首先满足环境质量/r/n“/r/n只能更好，/r/n不能变/r/n坏/r/n”/r/n的底线，严格落实污染物排放/r/n/r/n量替代是例外/r/n”/r/n的总/r/n量/r/n控/r/n制刚性要求。(省生态环境厅牵头)/r/n/r/n按照国家/r/n相关产业政策，深入实施/r/n“/r/n四上/r/n/r/n四压/r/n”/r/n，坚持/r/n“/r/n上新压旧/r/n”“/r/n上大压/r/n小/r/n”“/r/n上高/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n要求的高耗/r/n能/r/n、高排放项目要坚决拿下/r/n/r/n来/r/n。/r/n/r/n风除尘/r/n+/r/n脉/r/n处理后通/r/n/r/n放总量指/r/n/r/n于不符合高耗/r/n能、高排放的“两高/r/n”/r/n/r/n/r/n/r/n/r/n/r/n责)/r/n优/r/n化整合钢铁、地炼、焦化、/r/n/r/n能布局/r/n。(省发展改革委、省工业和信息/r/n/r/n/r/n/r/n施重点管控，推进产业布/r/n/r/n/r/n电能，/r/n/r/n—/r/n/r/n9/r/n—/r/n/r/n建设、重大项目选址和审批/r/n/r/n/r/n/r/n消费压减，增加清洁能源供/r/n能源供给/r/n耗能源为电/r/n“/r/n洁净煤/r/n炭/r/n+/r/n节能环保炉具/r/n”/r/n模式。鼓励火/r/n炭使用量。(省能源局牵头)各市要开/r/n展/r/n行为/r/n用煤/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n急期间全社会采用国五及以上排放/r/n/r/n/r/n迹、排放水平等。/r/n及产品/r/n/r/n车辆进行/r/n应重污染/r/n移动源使/r/n6/r/n、/r/n与《济/r/n宁/r/n市大气污染防治条例》(/r/n2021.5.28/r/n/r/n修订)符合性分析/r/n第/r/n十二条市人民政府应当依据重污染天气预报信/r/n/r/n/r/n市、/r/n县/r/n(市、区)人民政府应当依据重污染天气的预/r/n/r/n/r/n行驶、禁/r/n筑物拆除/r/n织的户外/r/n企/r/n业根据重污染天/r/n/r/n气的预警等级启/r/n动/r/n/r/n案/r/n第十五条/r/n市能源主管部门会同市生态环境主管部门/r/n/r/n/r/n门负责指/r/n导/r/n督/r/n促工业领域重点高耗煤行业淘汰落后产能任务/r/n/r/n解落实。/r/n代燃/r/n燃油等常规能源。/r/n/r/n热/r/n，办公取暖使用/r/n/r/n第二十条/r/n产生扬尘的单位应当实施扬尘污染防治措/r/n/r/n频监控设/r/n本项目施工期扬/r/n尘/r/n/r/n—/r/n10/r/n—/r/n主管部门及生态环境主管部门联网。/r/n降尘/r/n本项目位于山东省济宁市兖州区兴隆庄街道工业园，距离南水北/r/n调距离京杭运河东北/r/n/r/n/r/n项要求。/r/n—/r/n11/r/n—/r/n/r/n收；资源/r/n再生利用技术研发；再生资源回收(除生产性废旧金属)；金属材料销售；建筑材/r/n/r/n/r/n/r/n/r/n建设地点：本项目/r/n位于东省济宁市兖州区兴隆庄街道工业园，项目西侧为巨兴北路，北/r/n侧为空地、东侧为农田，南侧/r/n为闲置厂房。项目所在地地理位置优越，交通便利。具体地理/r/n/r/n/r/n生产车间、仓储车间、办公楼等/r/n，生产车间位于厂区东北侧，办公楼位于厂区西侧，仓储车/r/n区南侧。/r/n项目所处/r/n位置地势平坦，交通便利，结合地形等因素，按照国家有关标准和规定，对生/r/n产、运输、绿化进行了优/r/n化，并配有较为完善的供电、供水、排水等基础设施。本项目厂区/r/n面布置图见附图/r/n3/r/n。/r/n生产/r/n车/r/n间，长、宽、高/r/n50/r/nm/r/n*22/r/nm/r/n*9/r/nm/r/n，面积/r/n/r/n0m/r/n2/r/n，位于厂区东北侧，布置抓钢机等设备。/r/n2/r/n#/r/n生产车间/r/n生产车/r/n间/r/n，长、宽、高/r/n101/r/nm/r/n*22/r/nm/r/n*9/r/nm/r/n，面积/r/n/r/n2222/r/nm/r/n2/r/n，位于车间东北侧，布置破/r/n碎机、车床、/r/n剪/r/n切/r/n机等设备。/r/n车间/r/n/r/n统/r/n统/r/n//r/n制冷系统/r/n粪池处理后外运周边农田堆肥处/r/n—/r/n12/r/n—/r/n生产过/r/n程中破碎工序产生的颗粒物经集气罩收/r/n/r/n集/r/n由旋风除尘/r/n+/r/n脉冲袋式除尘器处理后通过/r/n/r/n15/r/nm/r/n/r/n高排气筒(/r/nDA/r/n001/r/n)排放/r/n；/r/n/r/n/r/n/r/n称/r/n吨/r/n2/r/n0/r/n万/r/n//r/n辅材料/r/n(/r/n/r/n1/r/n)主要原辅材料/r/n1/r/n钢板/r/n吨/r/n2/r/n钢筋/r/n吨/r/n5/r/n/r/n万/r/n本项目原料来源主要为废品/r/n厂、附近厂矿企业产生的废钢铁，原料入场前，都是经各供/r/n/r/n/r/n灭火器、液压缸、液化/r/n气罐，禁止收购盛装过有毒有害、易燃易爆、强腐蚀化学品或放射源/r/n的金属容器；企业须设专人严格按照《国家危险废物名录》(/r/n2021/r/n版)对原料进行检/r/n查/r/n，严/r/n禁危险废物或混入原料/r/n的危险废物入厂，原料符合上述所有条件后方可进厂。此外，评价要/r/n所有原材料必须入棚入库，不得露天存放。/r/n1/r/n台/r/n5/r/n2/r/n10/r/n型/r/n2/r/n台/r/n6/r/n3/r/n筋滾剪机/r/n台/r/n2/r/n2/r/n2/r/nT/r/n-/r/nS/r/n/r/n型/r/n4/r/n机/r/n台/r/n2/r/n—/r/n13/r/n—/r/n5/r/n机/r/n台/r/n1/r/n//r/n6/r/n台/r/n7/r/n7/r/n台/r/n5/r/n//r/n8/r/n台/r/n2/r/n//r/n9/r/n机/r/n台/r/n1/r/n//r/n台/r/n1/r/n//r/n筛选机/r/n台/r/n1/r/n//r/n筛选机/r/n台/r/n2/r/n.3m*2m/r/n磁选机/r/n台/r/n1/r/nm/r/n2m/r/n盘/r/n台/r/n1/r/n钢破碎机/r/n台/r/n1/r/n台/r/n2/r/n855/r/n型/r/n机/r/n台/r/n4/r/n饼机/r/n台/r/n1/r/n块机/r/n台/r/n1/r/n台/r/n1/r/n射监测仪/r/n台/r/n1/r/nNH/r/n1003/r/n台/r/n1/r/n//r/n器/r/n台/r/n1/r/nPPC/r/n96-2*/r/n5/r/n型/r/n料输送机/r/n台/r/n1/r/nm*3m/r/n台/r/n1/r/n3/r/n米/r/n*18/r/n米/r/n*30/r/n吨/r/n筛选机/r/n台/r/n1/r/n.3m*2m/r/n台/r/n1/r/n2/r/n500/r/n型/r/n(/r/n1)给水/r/n/r/n/r/n/r/n(2)/r/n/r/n排水/r/n—/r/n14/r/n—/r/n生活污水：生活污水的产生量按使用量的/r/n8/r/n0%/r/n计算，则产生量为0.8/r/nm/r/n3/r/n/d，/r/n240/r/nm/r/n3/r/n/a/r/n。/r/n0/r/n0/r/n粪池处理后外/r/n农田堆肥处理/r/n区抑尘用水/r/n(/r/n3/r/n)/r/n/r/n供电/r/n项目用电由厂区配电室线路提供/r/n，主要为生产设备用电和办公用电、生活用电等，年用/r/n2/r/n2/r/n/r/n/r/n饰管线短捷；人货流动/r/n畅通，并充分考虑到工程行业特点、安全间距、卫生防护、货物运输/r/n—/r/n15/r/n—/r/n/r/n电、气等辅助设施均已齐备并/r/n能正常使用，总体来说，施工期对环境影响较小，故本项目不/r/n污进行详细分析。/r/n称重入/r/n称重入/r/n场/r/n检验/r/n整形、剪/r/n切/r/n废旧钢/r/n板/r/n破碎/r/n称重入/r/n称重入/r/n场/r/n检验/r/n钢筋滚剪/r/n废旧钢/r/n筋/r/n切/r/n称重、入厂检验：将收购的废金属(废旧钢板、废旧钢筋)先经地磅称重后进行检验筛/r/n/r/n/r/n《国家危险废物名录》(2021/r/n版/r/n)对原料进行检查，对于含危险废物、辐射源的原料禁止入/r/n/r/n整形剪切：将不易破碎的超长、超厚、/r/n超粗料捡出用剪切机剪切，较大的钢板料先用车/r/n床、折弯机、铣床、转床等/r/n进行整形，然后进行剪切。本过程为整形剪切作用，不会产生可/r/n悬浮粉尘，但会产生少量废橡/r/n胶、废塑料等边角料与大块原料一起进入下一工序，故本过程/r/n生，但会产生一定机械性噪声和少量边角料。/r/n/r/n不会产生可悬浮粉尘，滚剪之后/r/n直接进行打包，故本过程无粉尘和固废产生，但会产生一定/r/n性噪声，/r/n破碎：项目废钢经皮带机输送至项目破碎/r/n机中，经破碎成小块物料。破碎过程中会产生/r/n以及机械性噪声。/r/n分选：破碎完成后的物料，经皮带/r/n机进入磁选系统中，废金属被吸起送至输送机上，其/r/n它物料经磁选下部的料斗/r/n落入非磁性物质输送机上归堆。在非磁性物质输送机上方设有一悬/r/n挂式磁选机，可将非磁性/r/n物质输送机上的游离黑金属吸出，然后送至收集料斗，非磁性物质/r/n输送机单侧设置站台，可/r/n供分拣人员进行人工挑选，将夹在非磁性物质中的铜、铝等有色金/r/n属挑选出来，剩余的废橡胶、废塑料由输/r/n送机落至地面归堆。该过程会产生废橡胶、废塑料/r/n—/r/n16/r/n—/r/n营期污染物分析/r/n环节/r/n分析，项目生产过程中污染物产生环节汇总如下表所示。/r/n罩收集旋风除尘/r/n+/r/n脉冲袋/r/n筒/r/n(/r/nDA/r/n001/r/n)排放/r/n处理后外运周/r/n/r/n工序/r/n门清运/r/n机、车床等设备运行时产生/r/n—/r/n17/r/n—/r/n/r/n有污染情况和环境问题。/r/n—/r/n18/r/n—/r/n在地区域环境质量现状及主要环境问题(环境空气、地面水、地下水、声环境、/r/n生态环境等)：/r/n状/r/n划分原则与技术方法》(/r/nHJ14-1996/r/n)，项目所在地环境空气质/r/n量功能区属/r/n二类区，执行《环境空气质量标准》(/r/nGB/r/n3095-2012/r/n)二级标准。根据济宁市生态/r/n/r/n/r/n目/r/n(μg/m/r/n3/r/n)/r/nμg/m/r/n3/r/n)/r/nPM/r/n1/r/n0/r/n(μg/m/r/n3/r/n)/r/nPM/r/n2./r/n5/r/nμg/m/r/n3/r/n)/r/n2/r/n021/r/n年/r/n1/r/n月/r/n2/r/n021/r/n年/r/n2/r/n月/r/n2/r/n021/r/n年/r/n3/r/n月/r/n2/r/n021/r/n年/r/n4/r/n月/r/n2/r/n021/r/n年/r/n5/r/n月/r/n2/r/n021/r/n年/r/n6/r/n月/r/n9/r/n2/r/n021/r/n年/r/n7/r/n月/r/n6/r/n2/r/n021/r/n年/r/n8/r/n月/r/n6/r/n2/r/n021/r/n年/r/n9/r/n月/r/n7/r/n2/r/n021/r/n年/r/n10/r/n月/r/n2/r/n021/r/n年/r/n11/r/n月/r/n2/r/n021/r/n年/r/n12/r/n月/r/n准/r/n表/r/n/r/n3-2/r/n/r/n兖州区大/r/n气环境质量现状评价表/r/n指标/r/n情况/r/n1/r/n浓度/r/n2/r/nNO/r/n2/r/n浓度/r/n3/r/nPM/r/n1/r/n0/r/n浓度/r/n4/r/nPM/r/n2/r/n.5/r/n浓度/r/n5/r/n24/r/n小时平均/r/n95/r/n百分/r/n%/r/n6/r/nO/r/n24/r/n小时平均/r/n95/r/n百分/r/n根据评价结果，/r/n2021/r/n年兖州区二氧化硫、二氧化氮年均浓度符合《环境空气质量标准/r/n》/r/n /r/n(/r/nGB/r/n3095-2012/r/n)中二级标准要求，/r/nPM/r/n1/r/n0/r/n、/r/nPM/r/n2.5/r/n年均浓度超标，根据/r/nHJ663-2013/r/n判定，项目/r/n所在区域为不达标区，可吸入颗粒物及细颗粒物为影响该区/r/n域空气质量的首要污染物。根据兖/r/n—/r/n19/r/n—/r/n/r/n/r/n治攻/r/n替/r/n代，推进煤炭清洁高效利用，推动产业优化升级，推动交通运输/r/n结构优化升级，加强重点示范/r/n季重点/r/n行业错峰生产等方面的行动，加快以细颗粒物为重点的大气污染治/r/n理，项目所在区域环境空气/r/n得到改善。/r/n特征污染物/r/n本项目/r/n涉/r/n及的污染物为颗粒物。根据《建设项目环境影响报告表编制技术指南/r/n(/r/n污染影响/r/n/r/n/r/n特征污染物/r/n”/r/n之列，故本次环评无需开展特征污染物调查和环境质量达标分析。/r/n/r/n/r/n/r/n(/r/nhttp/r/n:///r/ndbsfb/r/n./r/nsdem/r/n./r/norg/r/n./r/ncn/r/n:8003//r/nwaterpublic/r/n/#/r/n)/r/n，项目所在地/r/n水质较好，各项水质指标均能/r/n地下水/r/n区域属于工业和农业用水区域，确定地下水质量功能为Ⅲ类，执行《地下水质量标/r/n—/r/n20/r/n—/r/n/r/n/r/n位/r/n果/r/n5/r/nTU/r/n.5L/r/n.5L/r/n.5L/r/n.5L/r/n.5L/r/npH/r/n(/r/n无量纲/r/n)/r/nmg/r/nL)/r/n0/r/n9/r/n5/r/n4/r/n450/r/n体/r/n(/r/nmg/r/n//r/nL/r/n)/r/n5/r/n1000/r/n硫酸盐/r/n(mg/L/r/n.8/r/n3.2/r/n7.7/r/n6.1/r/n250/r/nmg/r/nL/r/n.6/r/n.9/r/n250/r/ng/L)/r/n1L/r/n1L/r/n1L/r/n1L/r/n1L/r/n1L/r/n≤0/r/n.3/r/ng/r/nL)/r/n04L/r/n04L/r/n04L/r/n04L/r/n04L/r/n04L/r/ng/r/nL)/r/n06L/r/n06L/r/n06L/r/n06L/r/n06L/r/n06L/r/n≤/r/n1.0/r/ng/L)/r/n04L/r/n4/r/n6/r/n6/r/n9/r/n04L/r/n≤/r/n2.0/r/ng/r/nL/r/n2/r/n8/r/n0/r/n1/r/n5/r/n0.20/r/n(mg/L)/r/n50L/r/n50L/r/n50L/r/n50L/r/n50L/r/n50L/r/n≤0/r/n.3/r/nmg/L)/r/n≤/r/n3.0/r/nmg/r/nL)/r/n93/r/n10/r/n.80/r/n0/r/nmg/r/nL)/r/n2L/r/n2L/r/n≤1.5/r/n物/r/n(mg/L)/r/n05L/r/n05L/r/n05L/r/n05L/r/n05L/r/n05L/r/n≤0/r/n.02/r/nmg/L)/r/n.8/r/n.8/r/n.5/r/n200/r/nmg/L)/r/n0/r/n2/r/n1/r/n5/r/n3/r/n2/r/n≤1.5/r/n/r/n(mg/L)/r/nL/r/n01L/r/n01L/r/n01L/r/n01L/r/n01L/r/n.2/r/n/r/n(mg/L)/r/nL/r/n01L/r/n01L/r/n01L/r/n01L/r/n01L/r/n≤0/r/n.08/r/ng/L)/r/nL/r/n01L/r/n01L/r/n01L/r/n01L/r/n01L/r/nmg/r/nL)/r/nL/r/n04L/r/n04L/r/n04L/r/n04L/r/n04L/r/n≤0/r/n.05/r/n/r/nMPN/r/nml)/r/n≤/r/n3.0/r/n100/r/n烷/r/n(μg/L)/r/n2L/r/n2L/r/n2L/r/n2L/r/n2L/r/n2L/r/n0/r/n3L/r/n3L/r/n3L/r/n3L/r/n3L/r/n≤/r/n2.0/r/n—/r/n21/r/n—/r/ng/r/nL/r/n≤/r/n10.0/r/n3L/r/n3L/r/n3L/r/n3L/r/n3L/r/n3L/r/n700/r/n/r/n放射性/r/n(/r/nBq/r/n//r/nL/r/n)/r/n1/r/n43L/r/n43L/r/n43L/r/n43L/r/n43L/r/n≤0.5/r/n放射性/r/n0/r/n15L/r/n8/r/n5/r/n5/r/n1/r/n：/r/n参照《声环境功/r/n能区划分技术规范》(/r/nGB/r/n//r/nT/r/n15190-2014/r/n)，项目所在地属于/r/n3/r/n类声环境/r/n/r/n/r/n声环境质量能够满足《声环境质量标准》(/r/nGB/r/n3096-2008/r/n)/r/n3/r/n类功能区标准限值/r/n。/r/n为生产经营场所，生产区、原料区、产品区布置在车间内，车间地面/r/n(污/r/n类)(试行)，不开展环境质量现状调查。/r/n以绿化、农作物为主，周围绿化较好，项目区内无珍稀动植物和/r/n重大环境制约因素。由于近年来工业企业的迅速发展，工业生产交通对当地农/r/n造成了不利影响，主要表现在地表植被系统的破坏、天然河道功能衰退、大气/r/n。/r/n—/r/n22/r/n—/r/n主/r/n要环境保护目标(列出名单及保护级别)：/r/n/r/n/r/n/r/n感目/r/n/r/n标/r/n/r/n与/r/n厂区最近距离(/r/nm/r/n)/r/n/r/nE/r/n0/r/n/r/n /r/n/r/nS/r/nW/r/n水/r/nW/r/n/r/n(/r/nGB/r/n3838-2002/r/n)Ⅲ/r/n类/r/n水/r/n/r/n、矿泉水、温泉等特殊地下水资源/r/n《/r/n地下水质量标准》(/r/nGB/r/n//r/nT/r/n境/r/n/r/n(/r/nGB/r/n3/r/n0/r/n96-2008/r/n)/r/n3/r/n类标准/r/n/r/n有厂房，占地范围内无生态环境保护目标/r/n—/r/n23/r/n—/r/n准/r/n破/r/n碎工序产生的颗粒物浓度执行《区域性大气污染物综合排放标准》(/r/nDB/r/n37/2376-2019/r/n)/r/n/r/n/r/n /r/n(/r/n10/r/nmg/r/n//r/nm/r/n3/r/n/r/n，/r/n3.5/r/nkg/r/n//r/nh/r/n)。/r/n准/r/n/r/n排/r/n放浓度/r/n/r/n(/r/nmg/r/n//r/nm/r/n3/r/n/r/n)/r/n浓/r/n(/r/nmg/r/n//r/nm/r/n3/r/n/r/n)/r/n/r/n/r/n/r/n /r/n《/r/n区域性大气污染物综合排放标/r/n/r/n准》(/r/nDB/r/n37/2376-2019/r/n)表/r/n1/r/n重/r/n点/r/n/r/n控制区标/r/n准；《大气污染物综合排/r/n/r/n放标/r/n准/r/n》(/r/nGB/r/n16297-1996/r/n)表/r/n2/r/n要/r/n求/r/n厂界噪声排放执行《工业企业厂界环境噪声排放标准》(/r/nGB/r/n12348-2008/r/n)/r/n3/r/n类标准/r/n。/r/n准/r/n境噪声排放标/r/n准》(/r/nGB/r/n12348-2008/r/n)/r/n3/r/n类标准/r/n3/r/n/r/n法》中的规定；一般固废执行《一/r/n般工/r/n业固体废物贮存和填埋污染控制标准》(/r/nGB/r/n18599-2020/r/n)。/r/n—/r/n24/r/n—/r/n根据《中华人民共和国国民经济和社会发展第十三个五年规划纲/r/n要》及《山东省国民经济/r/n/r/n》(鲁/r/n环发/r/n[2019]132/r/n号)，将/r/nVOCs/r/n/r/n纳入大气污染物/r/n排放总量替代指标体系。/r/n本项目无生产废水，主要为生活污水。本项目生活污水经化粪池/r/n处理后外运周边农田堆肥/r/n无需申请废水总量管理考核指标。/r/n大气污染物/r/nt/r/na/r/n东省建设项目主要大气污染物排放总量替/r/n代指标核算/r/n及管理办法》(鲁环发/r/n[2019]132/r/n号)，应按照建设项目所需替代的污染物排放总/r/n/r/n—/r/n25/r/n—/r/n—/r/n26/r/n—/r/n施工期环境保护措/r/n施/r/n本项目租赁已建成/r/n的闲置车间，仅在车间内进行设备的安装，设备安装时间较短，对/r/n/r/n运营期/r/n/r/n环境影响和保护措施/r/n(/r/n1/r/n)/r/n/r/n有组织排放/r/n产生的废气主要为破碎工序产生的颗粒物。/r/n/r/n/r/n/r/n经/r/n集气罩收集(收集效率为/r/n90%/r/n)通过旋风除尘/r/n+/r/n脉冲袋式除尘器处理后(处理效率/r/n99.9%/r/n)经/r/n15/r/nm/r/n/r/n高/r/n/r/n/r/n/r/n放满足《区域性大气污染物综合排放标准》(/r/nDB/r/n37/2376-2019/r/n)表/r/n1/r/n重点控制区标准；《大气污染/r/n物综/r/n合排放标/r/n准/r/n》(/r/nGB/r/n16297-1996/r/n)表/r/n2/r/n要求。(/r/n3.5/r/nkg/r/n//r/nh/r/n，/r/n10/r/nmg/r/n//r/nm/r/n3/r/n)。/r/n(/r/n2/r/n)/r/n/r/n无组织排放/r/n/r/n/r/n/r/n/r/n/r/n/r/n/r/n况/r/n况/r/n数/r/n施/r/n/r/nmg/m/r/n3/r/n/r/n/r/n/r/nmg/m/r/n3/r/n/r/n/r/n.6/r/n2/r/n2/r/n—/r/n27/r/n—/r/n序/r/n55000m/r/n3/r/n/h/r/n+/r/n脉/r/n况/r/n/r/n/r/nm/r/n/r/n℃/r/n/r/n/r/n况/r/nDA0/r/nP/r/n筒/r/n/r/n′6.9/r/n00/r/n况/r/n况/r/n//r/n//r/n5/r/n(/r/n3/r/n)/r/n/r/n废气治理设施可行性分析/r/n对照《排污许可证申请与核发技术规范废弃资源加工工业》(/r/nHJ/r/n1034-2019/r/n)如下表所/r/n示。/r/n污环节/r/n类/r/n情况/r/n破碎/r/n收集/r/n+/r/n布袋除尘/r/n收集/r/n+/r/n旋风/r/n/r/n气筒排放(风机风量/r/n55000/r/nm/r/n³//r/nh/r/n)/r/n，在破碎机上方采用顶部集气罩通过负压抽风收集，集气罩四周设置/r/n/r/n/r/n核/r/n发技术规范废弃资源加工工业》(/r/nHJ/r/n1034-2019/r/n)要求，废气处理措施可行。/r/n/r/n(/r/n4/r/n)/r/n/r/n废气环境影响分析/r/n/r/n物经/r/n“/r/n旋风除尘/r/n+/r/n脉冲袋式除尘器/r/n”/r/n处理后，排放量为/r/n0.052/r/nt/r/n//r/na/r/n，排放浓度为/r/n0.39/r/nmg/r/n//r/nm/r/n³/r/n，排放速率/r/n为/r/n/r/n0.022/r/nkg/r/n//r/nh/r/n/r/n，颗粒物排放浓度和排放速率执行《区域性大气污染物综合排放标准/r/n》(/r/nDB37/2376-2019/r/n)表/r/n/r/n因此对周边环境影响较小。/r/n(/r/n5/r/n)/r/n/r/n非正常工况/r/n要是除尘设备发生故障时，造成颗粒物的处理效率下降，按照效率/r/n0%/r/n计算，/r/n—/r/n28/r/n—/r/n/r/n类/r/n/r/n/r/n间/r/n度/r/nDA/r/n01/r/n排气筒/r/n//r/n年/r/nmg/m/r/n3/r/n21.6kg/h/r/n超标，对环境的危害和影响较大，因此需设/r/n外，/r/n/r/n小。一/r/n旦发生非正常生产排放，应及时进行检修，并采取相应措施进行污染物集中处理，确保事故状态/r/n，污染物对环境的影响程度降到最低。/r/n(/r/n6/r/n)/r/n/r/n监测计/r/n划/r/n根据《排污许可证申请与核发技术规范废弃资源加工/r/n工/r/n总则》(/r/nHJ/r/n942-2018/r/n)和《排污单位自行监测技术指南总则/r/n》/r/n(/r/nHJ/r/n制定污染源监测计划，项目大气污染源监测计划见下表。/r/n节/r/n/r/n工序/r/nDA/r/n0/r/n01/r/n次/r/n/r/n未收集废气/r/n/r/n/r/n/r/nm/r/n3/r/n/a/r/n/r/n/r/n及/r/n/r/n向/r/n/r/nmg/r/nL/r/n0/r/n4/r/n-/r/n-/r/n肥/r/n88/r/n-/r/n-/r/n6/r/n-/r/n-/r/nBOD/r/n5/r/n32/r/n-/r/n-/r/n本项目噪声源主要为剪切机、破碎机、车床等设备运转噪声，/r/n声级范围在/r/n75-85dB/r/n(/r/nA/r/n)左右。/r/n—/r/n29/r/n—/r/nn/r/nLpe/r/n/r/n=/r/n10×/r/nlg/r/n[/r/ni/r/n/r/n=/r/n1/r/nL/r/nPI/r/n10/r/n10/r/n]/r/n用上述公式计算出各噪声源点至基准预测点的总声压级，然后以基准预测点的噪声强度为工程噪声/r/n4-8/r/n/r/n/r/n项目设备噪声源强表/r/n(/r/nA/r/n)/r/n1/r/n6/r/n/r/n2/r/n筋滾剪机/r/n2/r/n3/r/n机/r/n2/r/n4/r/n机/r/n1/r/n5/r/n7/r/n6/r/n5/r/n7/r/n2/r/n8/r/n机/r/n1/r/n9/r/n1/r/n筛选机/r/n1/r/n筛选机/r/n2/r/n磁选机/r/n1/r/n钢破碎机/r/n1/r/n4/r/n4/r/nL/r/np/r/n/r/n(/r/nr/r/n)/r/n=/r/nL/r/np/r/n/r/n(/r/nr/r/n0/r/n)/r/n−/r/n(/r/nA/r/ndiv/r/n/r/n+/r/nA/r/nbar/r/n/r/n+/r/nA/r/natm/r/n/r/n+/r/nA/r/ngr/r/n/r/n+/r/nA/r/nmisc/r/n/r/n)/r/n—/r/n30/r/n—/r/n表/r/n/r/n4-9/r/n/r/n主/r/n要噪声设备对各厂界的预测值(单位：/r/ndB/r/n(/r/nA/r/n))/r/n距/r/n各厂界的距离(/r/nm/r/n)/r/n8/r/n/r/n值/r/n.9/r/n经预测，设备噪声采用上述隔声、减振等措施后，再经过距离衰减，厂界处噪声值＜/r/n55/r/ndB/r/n(/r/nA/r/n)/r/n。可/r/n/r/n见，本项/r/n目建设完成后厂界噪声能够满足《工业企业厂界环境噪声排放标准》(/r/nGB/r/n12348-2008/r/n)/r/n3/r/n类标/r/n/r/n节/r/n/r/n/r/n(/r/n1/r/n)生活垃圾/r/n：/r/ng/r/n/r/n(/r/n2/r/n)/r/n/r/n边角料/r/n：/r/n边角料/r/n主要为剪切、破碎、分选产生的废橡胶、废塑料及有色金属固废，项目分选过程中产生的废/r/n(/r/n3/r/n)除尘器收集粉尘：/r/n/r/n产生量/r/n废物代/r/n码/r/n处/r/n/r/n量/r/n(/r/nt/r/n//r/na/r/n)/r/n/r/n施/r/n环境/r/n管理要求/r/n1/r/na/r/n//r/n//r/n//r/n//r/n/r/n量)/r/n环/r/n理/r/n处置符合一般固废/r/n/r/n/r/n/r/n(/r/nGB/r/n18599-2020/r/n)/r/n/r/n标/r/n准要/r/n求/r/n—/r/n31/r/n—/r/n2/r/n角/r/n料/r/n//r/n//r/n//r/n4/r/n21-001-09/r/n(/r/n处置/r/n/r/n/r/n3/r/n//r/n//r/n//r/n4/r/n21-001-66/r/n/r/n(/r/n处置/r/n/r/n量)/r/n只在厂内作短时间的堆放，对环境产生影响较小。固体废物处/r/n置符合《一般工业固体废物贮/r/n存和填埋污染控制标准》(/r/nGB/r/n18599/r/n－/r/n2020/r/n)。/r/n、污染途径/r/n目正常情况下，化粪池均采取防渗措施，无污染途径，对地下水和土壤均无影响。废气均采取/r/n/r/n3/r/n、污染物类/r/n型及危害/r/n型/r/n发生的危害/r/nOD/r/n破裂/r/n漏污染地下水和土壤/r/n1/r/n)地下水、土壤污染源头控制措施/r/n/r/n对区域地下水质的影响。/r/n目选址区域建设前地面全部硬化，因此，本项目开发建设对地下水带来的直接影响主要反映在/r/n对地/r/n下水质的影响上。项目建成后，污水的排放、固体废弃物的堆放、垃圾收集间处置不当等都有可能/r/n应对垃圾收集系统、化粪池等做好防渗处理，若不能采取长期有效的防渗措施，在长期渗/r/n必将造成地下水的化学组成含量增高或发生水质变异，从而使地下水遭受污染。这些/r/n/r/n下水的污染。/r/n—/r/n32/r/n—/r/n/r/n/r/n/r/n外，/r/n严格按照厂区的绿化方案进行喷洒绿化，对于所有的输水管道等均采取防渗措施，如对地面进行碾/r/n/r/n/r/n事故隐患，采取有效的应对措施以防事故的发生。/r/n)/r/n/r/n分区防渗/r/n据项目区可能泄漏至地面区域、污染物的性质和建筑物的构筑方式，结合所建项目总平面布置情/r/n区分为重点防治区、一般污染防治区。/r/n1/r/n渗/r/n/r/n废水渗漏/r/n防渗层和基地上方都铺上至少/r/ncm/r/n压实粘土层，这样就能使渗透系/r/n2/r/n采用抗渗钢筋混凝土管沟或/r/nHDPE/r/n膜防渗/r/n.8%~1.5%/r/n，渗透系数不应大于/r/n/r/n3/r/n)/r/n/r/n跟踪监测/r/n根据/r/n《/r/n环境影响评价技术导则地下水环境》(/r/nHJ/r/n610-2016)/r/n和《环境影响评价技术导则土壤环境/r/n/r/n /r/nV/r/n/r/n环境/r/n/r/n标。/r/n—/r/n33/r/n—/r/n/r/n区内无珍稀动植物和文物保护区，无重大环境制约因素，本项目租赁厂房，对当地生态环境现状影/r/n风险/r/n目主要原辅料为废旧钢铁，均属于无毒无味，项目能源为电能，项目生产过程中无有毒有害物/r/nHJ/r/n018/r/n)进行环境风/r/n境风险评价应以突发性事件导致的危险物质环境应急损害防控为目标，对建设项目的环境风险进/r/n/r/n(/r/n1)风险潜势/r/n物质及工艺系统危险性分级/r/nB/r/n/r/n当存在多种危险物质时/r/n，则按式(/r/nC/r/n.1/r/n)计算物质总量与其临界量比值/r/nQ/r/n：/r/nQ/r/n/r/n=/r/n+/r/n+/r/n…/r/n/r/n+/r/n(/r/nC/r/n.1/r/n)/r/nQ/r/nI/r/n。/r/n/r/n(/r/n2/r/n)/r/n/r/n风险调/r/n查/r/n本项目生产过程中不涉及《建设项目环境风险评价技术导则》(/r/nHJ/r/n169-/r/n2018/r/n)规定的风险物质。/r/n险管理/r/n/r/n④项目如若/r/n发生火灾等事故，采用二氧化碳、干粉灭火器等进行灭火，事故情况下不向外环境排放/r/n—/r/n34/r/n—/r/n2)/r/n应急措施/r/na/r/n发生过程及处理后伴生/r/n//r/n次伴生污染消除处置措施/r/nO/r/n/r/n/r/n，项目的环境风险是可以接受的。/