《水性漆废物处》PPT课件.ppt

PRA_CAR_011_Aquabase Plus Waste Process_1205_EM,MODULE NAME,PRA_CAR_011,MODULE NUMBER,Aquabase Plus Waste Process Aquabase Plus 废物处理,Aquabase Plus Waste Process 废物处理,Introduction 介绍,P872-1000, Waterborne Flocculating Agent has been developed for the easy and efficient treatment of waste water, contaminated with Nexa Autocolor waterborne paint residue P872-100 水性絮凝剂，专门用于方便、有效地处理含有Nexa Autocolor 水性漆残留物的废水 This product should not be used with solventborne waste of any type 该产品不可以处理任何溶剂漆的废物,Equipment 设备,The Drester 1000-IS is the Nexa Specification of this gun cleaning machine Drester 1000-IS 是这种洗枪机的型号 “IS” represents the Nexa Autocolor specification, which is the approved design for use with Aquabase “IS” 表示Nexa Autocolor 的规格，已被认可用于 Aquabase This is the optimum piece of equipment for the waterborne waste process 是处理水性漆废物的最理想的设备,Aquabase Plus Waste Process 废物处理,Gun Cleaning清洗喷枪,Remove the air cap and clean as necessary 拆除风帽清洁 Decant excess paint from the pot into a waste paint container 把枪罐剩余的油漆倒入装废油漆的容器内 Half fill the pot with water and shake vigorously 枪罐内装一半水，剧烈摇晃,Aquabase Plus Waste Process 废物处理,Gun Cleaning清洗喷枪,Empty the resulting waste into the gun cleaning machine 产生的废水全部倒入洗枪机中 Clean off any remaining paint 清除残留的油漆 Remove pot and rinse it 拆除枪罐，淋洗,Aquabase Plus Waste Process 废物处理,Waste Treatment 废物处理,On average, 20 guns can be cleaned before the sump of the machine is full of waste, (30L) 洗枪机的污水箱平均可装清洗20把喷枪的污水 (30L) Each new container of Flocculating Powder must be shaken before use 新的絮凝剂粉末加入前必须摇晃,Aquabase Plus Waste Process 废物处理,Waste Treatment 废物处理,When the sump is full remove the separating mesh and start the air stirrer 污水箱装满后，取出分离网，开动空气搅拌器 Add 100g of P872-1000, (1 measure using the scoop provided), to the stirring waste and mix well for 5 minutes 加100克 P872-100, (1勺，用所附的量勺）到搅拌着的废水中，充分搅拌5分钟,Aquabase Plus Waste Process 废物处理,Waste Treatment 废物处理,Stop the stirrer and allow the solid waste to settle 停止搅拌器，让固体物沉淀 Check that the liquid is completely clear 检查废液是否已完全清澈 If not add a further measure of P872-1000 and repeat the process 如果废液不清澈，再加1量勺 P872-100 ，重复上述的过程,Aquabase Plus Waste Process 废物处理,Place the filter in the filter cage and open the valve at the base of the waste treatment sump 把过滤器放在过滤笼中，打开污水箱底部的阀门 When the waste treatment sump is empty, wipe the sides, base and stirrer before replacing the separating mesh 污水箱排空后，擦净侧壁和底部以及搅拌器，再放置分离网 It is important to make sure that the area around and above the separating mesh is free from powder residue 一定要确保分离网四周和上面无残留粉末,Aquabase Plus Waste Process 废物处理,Waste Treatment 废物处理,Waste Disposal 废物处置,The sludge collected in the filter is classified as “Controlled Waste” and should be disposed of in accordance with local regulations 过滤器中收集的淤泥称之 “可控废物”，必须按地方法规处置,Aquabase Plus Waste Process 废物处理,Waste Disposal 废物处置,The filtrate produced from the waste treatment process should not be disposed of into a public sewer without obtaining specific authorisation from the local or national water authority 未得到地方或国家水职能部门的授权，废水处理过程中产生的滤液不得直接排放到下排水系统,Aquabase Plus Waste Process 废物处理,Waste Disposal 废物处置,What do I do until I get approval? 在得到许可证前我们该做什么？,Prior to gaining any approvals it is possible to reuse the filtrate from the process at least ten times 得到许可证之前，该过程应生产的滤液至少应该重复使用10次 When recycled 10 times the filtrate can be taken away as normal controlled waste 滤液循环使用10次以后，可以作为一般可控的废物处理,Waste Disposal 废物处置,What do I do until I get approval? 在得到许可证前我们该做什么？,Once approval has be