S-AD3-WI-034 发配电管理办法 A.docVIP

ASIA VITAL COMPONENTS CO., LTD.更改記錄表 The revising record listAVC 管制文件，不准復印，列入移交AVC confidential, can not copyPDF created with FinePrint pdfFactory trial version 序號No.更改前章節/條款內容Before更改後章節/條款內容After更改後版次Revision afterAlteration提出人Proposed核准人Approved生效日期EffectiveDate1新版發行 New Edition IssueA謝光平Xgp馬填順David2008/07/22文件名稱：發、配電管理辦法Doc. Name：Power Generation and Distribution Management Method版本/ Rev.：A管制印章Stamp文件編號/Doc NO.：S-AD3-WI-034頁次/Page：1/4ASIA VITAL COMPONENTS CO., LTD.1.目的 Purpose為確保公司安全供電，特制定本管理辦法。To ensure the safety of power supply, make this management method.2.適用範圍 Applicable Scope適用於公司發、配電供電管理。Applicable for power generation & distribution management.3.職責 Responsibility3.1 擔當部門：行政部工務課Responsible department: the administration public service division3.1.1 提供給各部門的安全用電，供電電壓，三相 380 伏正負 5，頻率：50HZ，功率：0.98。Provide safe power & voltage to all dep., three-phase 380 V 5%, frequency: 50HZ, power: .2 提供及時的供電 Provide timely power1)市電供電正常時，24 小時市電供電給各用電部門。When supply normal city power, supply 24-hour normal city power to the all using departments.2)市電錯鋒用電時，啟動發電機組供電，以郵件提前一天通知各用電部門，市發電轉換時間為 10 分鐘，具體轉換時間:早上 5：30-5：40，次日 1：15-1：25。When avoid peak hour of using city power, Start power generating machine to supply power,inform all using departments by e-mail one day before changing power, changing time of Citypower is 10 minutes, specific as: 5:30 AM - 5: 40 AM, the next day 1:15 - 1: 25.3)市電在無通知突發性停電，啟動發電機組供電給各用電部門，市電轉換時間為 10 分鐘。When there is sudden power shortage without advance information, Start power generatingmachine to supply power to all using department, changing time of City power is 10 minutes.3.1.3 發電機組電力供應不足時，擬律定分級限電計劃，依重要程度，停止供電，分級計劃如下：When power generating machine can not supply enough power, make power limit as classification;according to importance levels, the classification plan is as the following:1)一級用電：不可停電，如熱管部、資訊部、消防、安全、C1 辦公大樓等專用線路；發電機供電時，優先供電。The first level: always with power, special lines such as heat pipe, MIS, ant fire, security, C1office buildings etc.; when the power generating machine generates power, ensure this level withpower in priority.2)二級用電：非不得己不停電，如一般生產用電、現場辦公室、警衛室等，發電機有多餘電力時，優先供電。The second level: only without power under special circumstances, such as the power used inmanufacture, office on-site, guards office etc.; when there is extra power, supply this level inAVC 管制文件，不准復印，列入移交AVC confidential, can not copyPDF created with FinePrint pdfFactory trial version 文件名稱：發、配電管理辦法Doc. Name：Power Generation and Distribution Management Method版本/ Rev.：A管制印章Stamp文件編號/Doc NO.：S-AD3-WI-034頁次/Page：2/4ASIA VITAL COMPONENTS CO., LTD.priority.3)三級用電：於電力不足時，立即停止供電，如路燈、宿舍、空調等，發電機有多餘電力時，視狀況供電The third level: when there is no enough power, stop to supply power immediately, such as streetlamps, dormitories air condition etc., when there is extra power of the power generating machine,supply power depending on the situation.3.2 用電部門 The Power-using Department3.2.1 嚴格遵守安全用電章程。Abide the power safety constitution strictly.3.2.2 嚴禁私自拉電，各用電部門增加電源，必須向行政部門申請，審批後由工務課執行。Forbidding using extra power without permission; if every power-using department needs to addpower-supply, they must apply with the executive department, after approval by the implementation,the Public service division implement after approval.3.2.3 供電故障後，不得私自排除故障，通知工務課由維修人員排除故障供電。When there is malfunction in the power supply system, should not troubleshoot by themselves;inform the public service division and the maintenance personnel repair it and ensure thepower-supply.3.2.4 積極配合供電人員，排除供電故障，當供電量不夠，切除部分用電電源，保障整體供電。Cooperate with the power- supply personnel actively; solve the problem of power-supply; whenthere is not enough power, cut some power-supply, and ensure the whole power-supply system.3.3 行政部 The Administration Department3.3.1 整體供電策略的制定 Make whole plan for power-supply3.3.2 供電資源調撥，審批Allocate & approve of power resources.3.3.3 監督及督促供電管理部門的供電安全及供電請求。Supervise and urge power-supply safety & power-supply requirements of power-supplymanagement department.4.定義 Definition無 None5.工作程序 Work Procedure5.1 制定公司內部總電路圖，各區域平面圖。Make internal circuit diagram & the regional layout.5.2 制定有關供電設施的保養手冊及保養記錄。Make maintenance manuals and maintenance records of power supply establishment.5.3 停電記錄表。Records list of no-power.5.4 不斷對用電部門倡導，安全用電及節約用電。AVC 管制文件，不准復印，列入移交AVC confidential, can not copyPDF created with FinePrint pdfFactory trial version 文件名稱：發、配電管理辦法Doc. Name：Power Generation and Distribution Management Method版本/ Rev.：A管制印章Stamp文件編號/Doc NO.：S-AD3-WI-034頁次/Page：3/4ASIA VITAL COMPONENTS CO., LTD.Advocate using-power security and saving to power-using department continuously.5.5 值班人員安排 On duty arrangement5.5.1 電房 24 小時上班分二班制，白班 7：00-19：00 夜班 19：00-7：00，每班二人。There are 2 shifts of power room within 24 hours; day shift: 7：00-19：00, night shift: 19：00-7：00, two staffs per shift.5.5.2 制訂轉接班工作記錄表。Make shift record list.5.5.3 節假日由配電人員輪流值班，每月制訂輪流值班表。The staffs are on duty by turn on holidays, make shift duty list every month.5.5.4 值班人員每月 1 日抄各部門上月用電表數，逢發電期間每小時記錄發電機運行系數。Staffs who are on duty copy the power quantity used in last month at the first of every month,record run coefficient every hour during power generation.6.相關文件和記錄 Relevant Documents and Records6.1發電機維修記錄表(Generator Repair Record List)6.2停電記錄表(Power Failure Record List)6.3發電機運行記錄表(Operation Record List of Generator)6.4配電櫃保養計劃(Electricity Distribution Cabinet Maintenance Plan)6.5配電櫃巡視檢查表(Electricity Distribution Cabinet Point Checklist)6.6市電運