捣固焦炉铁件工岗位技术操作规程

1、捣固焦炉铁件工岗位技术操作规程II A .   I can fly kites . 1 岗位职责  B .   Good idea! C . 1.1   Here you are .   D . Thank you .  直属班长的领导，执行其布置的工作任务。   It s difficult, but I can try . 1.2按要求进行护炉铁件的管理。  F . 1.3每季对护炉铁件所有弹簧、丝扣等紧固部分设备进行清扫加油。  No, she can t .1.4及时向车间反映有关铁件方面的问题。

2、 1.5 一连词成句 11.6每月上报一次备件计划。 you, see, on, can, river, the, a, boat (1.7负责有关包干区的卫生清洁。 .2工艺说明  _ 2.焦炉砌体主要由硅砖砌成的，在烘炉生产中，由于SiO2的晶型转变和物理作业，使砌体产生膨胀，此外，在生产过程中，炉体受到机械力和温度变化应力的作用，砌体特别是炉头部位产生周期性的收缩和膨胀，以致砌体容易产生裂纹和损坏。因此，在焦炉砌体的外部配置护炉铁件，使其连续不断的向焦炉砌体施加数量足够、分布合理的保护性压力，以保护炉体，延长焦炉寿命。 some, let

3、, pictures, now, us, draw ( .3 _ 3.3.1炉柱曲度的测量can, you, what, see, the, in, picture ( ? _ 4.3.1.1沿机焦两侧纵向在上横铁、下do, what, subjects, like, you ( ? _ 5.1.5mm），并固定在抵抗墙上的测线架上。in, what, the, big, is, box ( ? _ 6. 三条钢线应位于同一垂直平面内，钢线距抵抗墙正面约500mm,钢线不得与任何障碍物接触。 I, some, juice, can, have ( ? _ 93.1

4、.3在每个炉柱上测出与三条钢线的距离，然后按下式计算曲度： can, school, come, tomorrow, she, to (A= .）+ (c-a  _ 10. do, play, when, you, football ( ? _ 11炉柱曲度，mm and, Miss, at, six, Su Hai, meet, Su Yang, Li, thirty ( a mm  _ 12.下横铁处炉柱正面与钢线距离，mmc篦子砖处炉柱正面与钢线距离，mme上横铁处钢线与下横铁处钢线间距，mmE上横铁处钢线与篦子砖处钢

5、线间距，mm 3.1.4在使用中应使三条钢线与焦炉中心的距离保持不变，为此，要每年核对一次钢线与焦炉中心距离，并将校正结果换算在记录中。3.2弹簧压缩量的测量autumn, it, cool, is, in ( ? _ 13.3.2.1用钢板尺找出原始测量的部位进行弹簧高度的测量。short, those, too, are, shorts ( 测量后应当与前一次测量记录比较，与弹簧试压吨位表对照，换算出实际吨位，并视情况进行调节，使弹簧符合规定吨位。  3.3 1.在距焦炉中心约为.的竖直平面上架设钢线。.3.3.2钢线与抵抗墙正面上原始基点的距离作为测量炉体膨胀时每次拉

6、线的标准距离每年核定一次，除遇有障碍物临时改变测线位置外，一般不得改变。.3.3.3沿机焦两侧纵长方向在上、下横铁和斜道（蓄热室顶）等标高处各引一条钢线（ ），并固定在抵抗墙上的测线架上。s, day, hot (3.3.4机焦侧各线的膨胀值应每季度测量一次，每次测量点相同，测量工具为刻有毫米刻度的钢板尺。3.3.5X=a. _ 6. do, like, not, Maths, Science, they, and (.mm.have, do, what, we, Monday, on, lessons (?_ 8原始 any, today, I, dona钢线至

7、炉砖或保护板的距离，mm 3.3.6正常生产的焦炉炭化室部位年膨胀量按炉门上下横铁处平均值计算，在投产两年以后，每年不超过5mm。遇有膨胀异常，例如：年膨胀量超过10mm_ 11. we, in, can, go, winter, skating (,. _ 12.横拉条温度及细度 here, it, is, summer, in, hot (? _ 133.4.1准备好测量用的try, yellow, please, this, coat (. _ 14. my, these, red, are, dresses, cousins (._ 15红外线测

8、温仪对准拉条中间部位测量读数，作好记录。s, now, to, party, the, go (,3.4.4 _ 16.3.4.5small, whose, are, gloves, they, Taotao (,? _ 17. shirt, look, her, at, his, sweater, and (. _ 183.4.7 ill, Mouse, Mrs, Bobby, is (,? _ 19.4 cup, heres, of, coffee, you, for, a (. _ 204.2 come, can, to, I, see, clas

9、s, after, you (? _ 21 are, for, my, party, these, trousers, the (.4.4使用铁制工具，不要碰撞拦焦车摩电道。 cold, has, a, cough, a, she, and (. _ 23. 4.6机车行走时不许上下车。_ 24 . 不得从正准备推焦的炉号前抢过，不许从推焦中的推焦杆下面穿过。 4.8不许上下同时工作，以免工具掉下伤人。 can, make, draw, and, Tom, kite, a, he, can (. _ 26.4.10测量机、焦侧一、二线炉柱曲度和炉体膨胀时

10、，应事先与推焦装煤车和拦焦车司机联系，并且在焦炉检修时方可进行。those, that, the, trees, lake, the, is, are, and (4.11在蓄热室部位测量、调节时，换向期间停止作业。5 设备维修保养规程5.1.设备概要： go, home, every, I, in, the, at, five, afternoon, day (. _ 30炉柱：高 to, go, bed, eight, at, usually, I, the, in, evening (. _ 宽用单词的适当形式填空 厚 520mm单重 1# 4194kg 2# 419

11、4kg 3# 4151kg 4# 4471kg 5# 3937kg This is _ (we school炉门框：高 宽934mm 单重2274kgHow many (lesson do we have? 3.保护板：高6374mm 宽1340mm  4. Wang Bing _ (have a new coatQ345-B 重量276kg 长度17905mm下部横拉条：直径ø50 材料Q345-B 重量21.5kg 长度1390mm纵拉条：扁铁5. Rose _ (make a _(snowmen this afternoon.Q

12、235-B  . We dont have_ (some lessons today. 序号 This is _ (you picture. Its nice. 8. Whats the matter with _(he ? 9. Can you see _ (some trees in the park ? 10. These _( is my new shorts11. Yang Ling can _ ( has dinner at six this evening展开长度 12.

13、 Here _ ( be some trees. d Whats the matter with _(she ? 14. Lets go _(swim in the river. 151 That_(make a week. 16. I like _(sandwich.51.7kg Let _( we go to the park.4.5±0.25 Yang Ling can _(have picnics this Saturday. 19 She _(want t

14、o go to bed at nine.2775mm45-5055 20. _(he sweater is so beautiful. 21. I (like this coat. .±0.25. _(she dress is too big for her. . Look at _(me _(mother dress2470mm Its so beautiful45-50 24. 45. (speak 25225 I_ (can make cakes,

15、its too difficult for_( I 二、用所给词的适当形式填空。 1. What _ (subject do you like? 2. 12.8kg I can see _ (some flowers but I cant see_ (some trees. 6 I _ (have a dog左 Yang Ling _ (have a dog too.We _ (have two dogs in all. 45-50 Where_(be the cats? Where_(be the water?

16、Where_ (be the book and the bag? 6. I like_(swim.258t_(swim tomorrow. 7.60Si2mn May I _ (speak to Nancy? 8 Look at _(this _(shoe. Theyre so nice! I want to try _(this pair! 9 I like _(dance. I want to _(dance with you! 10左 _(who tiger is this? Its_(Wang Bing.&

17、#160;_(who Wang Bing? The boy over there45-50 _(he happy! And_(he eyes are big! 12. - _(be you hungry? - Yes, I _(be. - Here_(be some bread for you220 13. - _(do you have a cake? - No, I _(do. I _(do have a cake. 5.9kg I can _(read books at school.±0.25.&

18、#160;5 15.Look at these _(boat on the river! Lets go _(boat.1990mm16. We have four _(season in a year. - I cant_(hear you! - Im sorry_(hear that! 18. 6 But here _(be some pies for you60Si2mn 19. - Whose_(dress are they? - _(they Yang Ling6.5± - Whose _(ju

19、ice is it? - _(it Yang Lings5 20. - _(I cap is on the desk. - OK. I can see _(you cap. Here_(you are20 21.180. I like_(spring very much. 22. - _(be your good friend ill? - Yes, he _(be C D _ _ 2. She have a new skirt . A B C D some les

20、sons on Sunday. B C D ( 3.Mike and Su Hai dont have A _ ( 4.Where do you A get up every day. B C D _ ( 5.Lets play table tennis at Saturday. A B C at spring . C D D _ ( 6. Its warm A B _ ( 7. Who），常用弹簧规格见表（2.焦炉各部位弹簧负荷 表（ Lets skating A B _ ( 91 A B C D _

21、( 10. I drink an A B C ice cream. 安装部位 I can see a duck in the river.应有压力（t） Can you see any boat ? A B C D 13. How many hill can you A B C 14. Can you draw they ? see ? D _ _ _ _ _ _ _ _ _ _ _ A B C D 15. 16 We B C D usually make snowman in winter A B C

22、D 17. Im thirsty. 1. Whose dress are they ? A B C D 19.1.2 3-9线小弹簧. It10-12小弹簧. 1 Whats the matter with they ? A B C D 焦炉常用的弹簧规格 表（根据中文，完成句子 一完成下列句子 1 这个学期你们有多少门学科？ _ _ _do you have this term？ 2 现在是上体育课的时间，让我们一起去操场吧。 It备注 Lets go to the _. 炉柱曲度测量 你喜欢什么课？我喜欢英语，它是有趣的。 What _ do you like? I like _每季一次 Its _. 4. 星期五早上你有什么课？ _ _ do you have on_ _. 5. 苏洋每天有一节游泳课。 Su Yang_a _lesson _ _. 6 星期日是一周的第一天。 _ is the first _ of a week