E66A520B-1140H2汽车空调电动压缩机技术规格书

1、汽车空调电动涡旋压缩机技术规格书SPECIFICATIONS OF 540VDC COMPRESSORModel: E66A520B-1140H2stDate: March 29.,2015南京奥特佳新能源科技有限公司1.范围RANGE本技术规格书适用于E66A520B-1140H2压缩机。This specification is applied for Aotecar E66A520B-1140H2 compressor.2.标准依据BASED ON THE STANDARDGB/TGB/TGB/TGB/T4208-1993GB/T5773-2004GB/T17619-1998GB/GB/

2、T18655-2002GB/T19951-2005JB/T9617-1999QC/T413-2002QC/T660-2000ISO7637-2:2004ISO7637-3:20073.一般要求GENERAL REQUIREMENTS冷媒refrigera ntR134a转速范围speed range10004000 rpm运转压力吸气压力(A) Suction pressure排气压力(A) Discharge pressurewWork ing pressure压力比pressure ratiow 10温度temperature环境温度temperaturew 85C排气温度discharg

3、e temperaturew 110C油保持量lubricating oil rate系统冷媒量的8%-10% of refrigera nt4.技术参数基本参数4.1.1压缩机COMPRESSOR压缩机型号COMPRESSOR MODEL NO.E66A520B-1140H2压缩机方式COMPRESSOR STYLE全封闭卧式涡旋压缩机Hermetic horiz on tal scroll compressor使用冷媒refrigerantR134a排气容积displacement66cm/rev常用转速范围no rmal speed1000-4000rpm额定电压最高转速max. spe

4、ed4000rpm蒸发温度范围evaporator no rmal temperature-10C冷凝温度范围conden ser no rmal temperature68 C压缩机冷去卩方式compressor cooli ng method吸气冷去卩suction gas cooling制冷齐U泄漏量refrigera nt leakage rate50MQ (20 C时)When powered with 500VAC, i nsulationresistance50M Q (Ambienee temperature20 C)4.1.3驱动器特性DRIVER电机控制方式motor dr

5、ived by120度方波驱动方式120 degree squarewave磁极位置检测方式magn etic pole positi on in spect ion method无位置传感器no positi on tran sducer输入特性In putpower额定输入电压rated voltage520VDC输入电压范围in put voltage range420V700V过压恢复值overvoltage recovery value685V欠压恢复值under voltage recovery value435V最大输入电流max. incoming curre nt15A最大输

6、入功率max. applied power4800W200W冷却方式cooling method吸气冷去卩Suction gas cooling防护等级protective classicIP67平均无故障时间 MTBF10000hours性能PERFORMANCE4.2.1制冷性能cooling performaneeRemark: Speed tolera nee1%, actual test cooli ng capacity data not less tha n 90% of data in the table, actual testpower rate not exceed 11

7、0% of data in the table探 制冷能力测试条件COOLING CAPACITY TEST CONDITIONS注：转速误差土1%,实测制冷量不小于表中数值的93%,实测功率不大于表中数值的110%.性能蛾刃试 H 耳；尸代0芒2节琳衣P/訂封-卩口也亦丿 过划twx：过冷虚5r關為祉Rd工况蒸发温度冷凝温度吸气温度过冷度环境温度con diti onsEvaporati ngCondensingSucti onSubAmbie nt airtemperaturetemperaturetemperaturecooli ngtemperatureCCC5 C35 C422噪声N

8、oise level转速Speed ( rpm)4000噪声Noise level ,dB(A)w 86注：噪声传感器安装在压缩机正上方15cm.Remark: Noise sen sor locate at 15cm above compressor.很噪声测试条件Noise level TEST CONDITIONS工况蒸发温度Evaporating冷凝温度吸气过热度过冷度环境温度con diti onstemperatureCondensingSuctio nSubAmbie nt airtemperaturesuperheatcooli ngtemperatureCC10 C5 -10 C35 C压缩机运行范围Compressor running envelope安装尺寸In stal